Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
510–25K
1625–50K
1850–75K
2175–100K
16100–150K
7150K+
129 reports with mileage · 46 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Wheels. Review the 32 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Service Brakes, Hydraulic. Review the 28 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 24 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
10 crash reports13 fire reports8 injury reports
What owners actually said
175 reports
Mileage unknown · Aug 3, 2005
Wheels
DT: THE CONTACT OWNS A 2004 KIA SEDONA. HE RECEIVED NHTSA RECALL 05V232000 ON JUNE 13, 2005. CONTACT WASU NABLE TO GET THE REPAIR WORK DONE. WHEN CONTACT TOOK VEHICLE TO DEALER TO GET TIRES ROTATED WAS TOLD BY DEALER THAT HUB ASSEMBLY WAS FIXE, BUT THEY DID NOT REPLACE THE RECALL PART. CONTACT COMPLAINED THAT DEALER DID N…
Read full complaint
DT: THE CONTACT OWNS A 2004 KIA SEDONA. HE RECEIVED NHTSA RECALL 05V232000 ON JUNE 13, 2005. CONTACT WASU NABLE TO GET THE REPAIR WORK DONE. WHEN CONTACT TOOK VEHICLE TO DEALER TO GET TIRES ROTATED WAS TOLD BY DEALER THAT HUB ASSEMBLY WAS FIXE, BUT THEY DID NOT REPLACE THE RECALL PART. CONTACT COMPLAINED THAT DEALER DID NOT NOTIFY HIM THAT THEY DID NOT COMPLETE THE RECALL. *AK
NHTSA ODI #10131410
15,000 miles · Aug 3, 2005
Wheels
DT: RECEIVED RECALL LETTER FROM KIA ON JUNE 13, 2005 FOR THE HUB ASSEMBLEY. CONTACTED THE DEALER, THEY DO NOT HAVE THE PARTS. CONTACTED THE MANUFACTURER THEY WERE SHORT ON PARTS. *AK
NHTSA ODI #10131386
Mileage unknown · Jul 25, 2005
Wheels
DT: THE CONSUMER OWNS A 2004 KIA SEDONA. HE STATED HE RECEIVED A RECALL LETTER ON JUNE 13, 2005 AND SINCE THEN HE HAS BEEN UNABLE TO GET HIS VEHICLE REPAIRED. THE DEALERSHIP KEEPS TELLING HIM THEY DO NOT HAVE THE PARTS AVAILABLE HE DID SPEAK WITH THE MANUFACTURER AND THEY JUST TELL HIM TO GO TO ANOTHER DEALERSHIP TO GET THE REP…
Read full complaint
DT: THE CONSUMER OWNS A 2004 KIA SEDONA. HE STATED HE RECEIVED A RECALL LETTER ON JUNE 13, 2005 AND SINCE THEN HE HAS BEEN UNABLE TO GET HIS VEHICLE REPAIRED. THE DEALERSHIP KEEPS TELLING HIM THEY DO NOT HAVE THE PARTS AVAILABLE HE DID SPEAK WITH THE MANUFACTURER AND THEY JUST TELL HIM TO GO TO ANOTHER DEALERSHIP TO GET THE REPAIR WORK DONE. HE DOES NOT FEEL SAFE DRIVING THIS VEHICLE BECAUSE HE CAN'T GET THIS DONE. THE RECALL WAS ON THE ALLOY WHEELS, MOISTURE COULD ACCUMULATE AROUND THE REAR HUBCAPS.*JB
NHTSA ODI #10129953
Mileage unknown · Jul 22, 2005
Wheels
DT: CALLER HAS RECALL THAT CAN'T GET FIXED BECAUSE DEALER HAS PARTS ON BACK ORDER. RECALL NUMBER IS NOT AVAILABLE. DEALER INSISTS THEY CAN'T FIX THE PROBLEM NOW BECAUSE THEY DON'T HAVE THE PARTS ON HAND. MANUFACTURER ALSO SAID THE PARTS WERE ON BACK ORDER. *AK
NHTSA ODI #10129710
Mileage unknown · Jul 22, 2005
Wheels
DT: THE CALLER RECEIVED A RECALL NOTICE AND CAN'T GET THE WORK DONE. THE CALLER HAD THREE DIFFERENT APPOINTMENTS TO GET IT FIXED, AND ALL THREE TIMES THEY TOLD HER THAT THEY DID NOT HAVE THE PARTS. THE DEALER AND THE MANUFACTURER HAVE TOLD HER THAT THEY COULD NOT GET THE PARTS. *AK AS OF 08/02/05 THE PARTS HAD NOT COME IN. …
Read full complaint
DT: THE CALLER RECEIVED A RECALL NOTICE AND CAN'T GET THE WORK DONE. THE CALLER HAD THREE DIFFERENT APPOINTMENTS TO GET IT FIXED, AND ALL THREE TIMES THEY TOLD HER THAT THEY DID NOT HAVE THE PARTS. THE DEALER AND THE MANUFACTURER HAVE TOLD HER THAT THEY COULD NOT GET THE PARTS. *AK AS OF 08/02/05 THE PARTS HAD NOT COME IN. *SC
NHTSA ODI #10129688
15,000 miles · Jul 20, 2005
Electrical SystemFire
AFTER PARKING VAN AFTER A SHORT TRIP OF APPROXIMATELY 2 TENTHS OF A MILE THE VAN WAS TURNED OFF AND THE KEY WAS OUT OF THE IGNITION AND DOORS WERE LOCKED, FOUR HOURES LATER SOMEONE NOTICED SMOKE COMING FROM THE VAN. WHEN THE DRIVERS SIDE DOOR WAS OPENED FLAMES SHOT OUT OF THE VAN. AFTER A FIRE EXTINGUISHER WAS USED TO EXTINGUISH…
Read full complaint
AFTER PARKING VAN AFTER A SHORT TRIP OF APPROXIMATELY 2 TENTHS OF A MILE THE VAN WAS TURNED OFF AND THE KEY WAS OUT OF THE IGNITION AND DOORS WERE LOCKED, FOUR HOURES LATER SOMEONE NOTICED SMOKE COMING FROM THE VAN. WHEN THE DRIVERS SIDE DOOR WAS OPENED FLAMES SHOT OUT OF THE VAN. AFTER A FIRE EXTINGUISHER WAS USED TO EXTINGUISH THE FIRE, IT WAS NOTICED BE ME THAT THE MAIN WIRING HARNESS GOING TO THE FUSE PANEL AS WELL AS THE FUSE PANEL WAS MELTED AND SMOLDERING. I ALSO NOTICED THAT THE RADIO WAS PLAYING AND THE DASH LIGHTS WERE FLASHING AND THE DOOR BUZZER WAS BUZZING, ALL WITHOUT THE BEING IN THE IGNITION. I THEN PROCEEDED TO UNHOOK THE POSITIVE BATTERY CABLE TO KILL POWER TO THE VAN. KIA MOTERS CAME AND GOT THE VAN AND TOOK IT TO A LOCAL DEALER. UPON INSPECTION BY THE DEALERSHIP THEY AND KIA MOTORS CONCLUDED THAT IT WAS NOT AN WARRENTY ISSUE. IT WAS OBVIOUS THAT THIS WAS A WIRING FIRE AND WAS NOT CAUSED BY ANY FREAK ACT OF NATURE OR NEGLEGIENCE OF ME THE OWNER. KIA SAYS THAT IT IS NOT A MANUFACTURER DEFECT. KIA SAID TO TAKE PICTURES AND MAIL THEM TO THEM AND TURN IN A CLAIM TO MY INSURANCE COMPANY. WE HAVE READ OF NUMEROUS FIRES JUST LIKE THE ONE THAT OCCURED ON MY VAN ON THE INTERNET.
NHTSA ODI #10129485
15,000 miles · Jul 18, 2005
Suspension
DT: CONSUMER RECEIVED A RECALL NOTICE ON REAR OUTER BEARINGS. CONSUMER COULD NOT GET REPAIR WORK DONE AT DEALERSHIP BECAUSE THEY DID NOT HAVE ENOUGH PARTS TO FIX THE RECALL . CONSUMER WAS PLACED ON A WAITING LIST, BUT NO CALLS WERE RETURNED. CONCERNED, CONSUMER CALLED KIA. AND WAS TOLD THEY ONLY RECEIVED 400 PARTS A WEEK FR…
Read full complaint
DT: CONSUMER RECEIVED A RECALL NOTICE ON REAR OUTER BEARINGS. CONSUMER COULD NOT GET REPAIR WORK DONE AT DEALERSHIP BECAUSE THEY DID NOT HAVE ENOUGH PARTS TO FIX THE RECALL . CONSUMER WAS PLACED ON A WAITING LIST, BUT NO CALLS WERE RETURNED. CONCERNED, CONSUMER CALLED KIA. AND WAS TOLD THEY ONLY RECEIVED 400 PARTS A WEEK FROM KOREA TO SUPPLY ALL OF THEIR US DEALERSHIPS, AND DID NOT OFFER ANY TIME FRAME AS TO WHEN THE REPAIRS COULD BE HANDLED. NO REPAIRS AT ALL, BUT HAS NOT BEEN EXPERIENCING A PROBLEM. *AK
NHTSA ODI #10129067
Mileage unknown · Jul 12, 2005
Wheels
I WAS NOTIFIED VIA A LETTERDATED JUNE 13,2005 OF A RECALL TO CORRECT A DEFECT ON MY VEHICLE. (CAMPAIGN ID# 05V232000). I IMMEDIATELY CALLED THE DEALER TO SCHEDULE AN APPOINTMENT FOR THE REPAIRS. DEALER NOTIFIED ME OF AWARENESS OF THE RECALL BUT NO PARTS WERE AVAILABLE AT THAT TIME TO COMPLETE THE REPAIRS. DEALER INDICATED H…
Read full complaint
I WAS NOTIFIED VIA A LETTERDATED JUNE 13,2005 OF A RECALL TO CORRECT A DEFECT ON MY VEHICLE. (CAMPAIGN ID# 05V232000). I IMMEDIATELY CALLED THE DEALER TO SCHEDULE AN APPOINTMENT FOR THE REPAIRS. DEALER NOTIFIED ME OF AWARENESS OF THE RECALL BUT NO PARTS WERE AVAILABLE AT THAT TIME TO COMPLETE THE REPAIRS. DEALER INDICATED HE WOULD CALL ME WHEN THE PARTS WERE AVAILABLE. I WAITED APPROX. FOUR WEEKS THEN CALLED THE DEALER. AGAIN NO PARTS. I THEN CALLED KIA CUSTOMER AFFAIRS DEPT. THEY HAVE NO IDEA WHEN PARTS WILL BE AVAILABLE. THEY SUGGESTED I TAKE THE VEHICLE TO THE DEALER FOR INSPECTION AND IF A DEFECT WAS FOUND THE VEHICLE WOULD BE IMPOUNDED UNTIL PARTS BECAME AVAILABLE. I THINK KIA IS TAKING FAR TO LONG TO CORRECT THIS PROBLEM. THE RECALL WAS TO BEGIN JUNE 5, 2005. OWNERS WERE NOTIFIED VIA LETTER DATED JUNE 13, 2005. AS OF JULY 12, 2005 THEY HAVE NO IDEA WHEN REPAIRS CAN BE MADE. MUST PEOPLE BE KILLED BEFORE ACTION IS TAKEN?
NHTSA ODI #10128462
Mileage unknown · Jul 12, 2005
Structure
DT: WHILE LOADING GROCERIES INTO THE TRUCK OF THE VEHICLE THE HYDRAULICS WOULD NOT HOLD UP THE WEIGHT OF THE HATCHBACK. WHEN THE CONSUMER FIRST OPEN THE HATCHBACK HE NOTICED THAT IT DID FEEL HEAVIER THAN USUAL BUT THERE WERE NO SIGNS OF THE HATCHBACK FAILING. THE DEALERSHIP HAS BEEN NOTIFIED AND THE PART IS ON BACK ORDER. …
Read full complaint
DT: WHILE LOADING GROCERIES INTO THE TRUCK OF THE VEHICLE THE HYDRAULICS WOULD NOT HOLD UP THE WEIGHT OF THE HATCHBACK. WHEN THE CONSUMER FIRST OPEN THE HATCHBACK HE NOTICED THAT IT DID FEEL HEAVIER THAN USUAL BUT THERE WERE NO SIGNS OF THE HATCHBACK FAILING. THE DEALERSHIP HAS BEEN NOTIFIED AND THE PART IS ON BACK ORDER. THE MANUFACTURER OF THE VEHICLE HAS NOT BEEN NOTIFIED. *NM
NHTSA ODI #10128414
30,000 miles · Jul 5, 2005
Wheels
DT: CONSUMER RECEIVED A RECALL LETTER AROUND JUNE 13, 2005. SHE CONTACTED THE LOCAL DEALERSHIP, AND WAS TOLD THE PARTS WERE NOT IN. SHE CALLED BACK TODAY AND THE PARTS STILL WERE NOT AVAILABLE. SHE CALLED KIA, AND THEY TOLD HER TO CALL BACK AND HAVE THE VEHICLE INSPECTED UNTIL THE PARTS WERE AVAILABLE. SHE HAS TO CALL BACK A…
Read full complaint
DT: CONSUMER RECEIVED A RECALL LETTER AROUND JUNE 13, 2005. SHE CONTACTED THE LOCAL DEALERSHIP, AND WAS TOLD THE PARTS WERE NOT IN. SHE CALLED BACK TODAY AND THE PARTS STILL WERE NOT AVAILABLE. SHE CALLED KIA, AND THEY TOLD HER TO CALL BACK AND HAVE THE VEHICLE INSPECTED UNTIL THE PARTS WERE AVAILABLE. SHE HAS TO CALL BACK AGAIN TO ARRANGE FOR THAT. *AK
ON CERTAIN MINI VANS, FREEZING CONDITIONS CAN CAUSE WATER ON THE THROTTLE CABLE TO FREEZE DURING NORMAL OPERATION. RESISTANCE TO MOVEMENT OF THE THROTTLE CABLE CAN OCCUR WHEN THE DRIVER LIFTS THEIR FOOT OFF OF THE GAS PEDAL.
Consequence & remedy
Consequence: THIS CAN CAUSE THE CABLE TO STICK, THUS PREVENTING THE ENGINE FROM RETURNING TO IDLE AND CAUSING THE VEHICLE TO MAINTAIN SPEED OR ACCELERATE. SUCH AN EVENT CAN OCCUR WITHOUT WARNING AND COULD CAUSE A CRASH.
Remedy: DEALERS WILL MODIFY A PROTECTIVE SLEEVE AROUND THE THROTTLE CABLE. THE RECALL BEGAN ON AUGUST 15, 2005. OWNERS MAY CONTACT KIA AT 1-800-333-4542.
ON CERTAIN MINI VANS EQUIPPED WITH ALLOY WHEELS, MOISTURE CAN ACCUMULATE AROUND THE REAR HUB CAPS CAUSING DAMAGE TO THE OUTER WHEEL BEARING.
Consequence & remedy
Consequence: WHEEL BEARING FAILURE MAY OCCUR WITHOUT WARNING WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE REAR HUB CAPS FREE OF CHARGE. UPON INSPECTION, SOME VEHICLES WILL ALSO REQUIRE REPLACEMENT OF THE REAR OUTER BEARINGS AND/OR HUB ASSEMBLY. THE RECALL BEGAN ON JUNE 13, 2005. OWNERS MAY CONTACT KIA AT 1-800-333-4542.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
EA08017 · Steering Intermediate Shaft Binding
Opened Aug 28, 2008 · Closed Jul 1, 2009
Status: closed (inferred from source dates) · Steering
ODIS ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED AT A RELATIVELY HIGH FREQUENCY IN SALT-BELT STATES (5.9 PERCENT).HOWEVER, THE TESTS CONDUCTED BY ODI AND KIA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL EFFECT ON STEERING EFFORTS.IN ADDITION, ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT SHOWED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS AND WAS MORE OF A NUISANCE CONCERN. THERE HAS BEEN ONE ALLEGATION OF A MINOR CRASH RELATED TO THE ALLEGED DEFECT, INVOLVING A MY 2003 KIA SEDONA WITH 59,900 MILES.THE VEHICLE HAD BEEN CHECKED TWICE IN THE PREVIOUS NINE MONTHS BY A DEALER FOR COMPLAINTS OF STIFF STEERING AND THAT THE VEHICLE FELT LIKE IT WAS INTERMITTENTLY LOSING POWER ASSIST.THE CRASH OCCURRED AS THE DRIVER WAS ATTEMPTING TO MAKE A LEFT TURN WHILE TRAVELING AT APPROXIMATELY 20 MILES PER HOUR AND STRUCK A VEHICLE PARKED ON THE RIGHT SIDE OF THE STREET THAT THE VEHICLE WAS TURNING INTO. THE CRASH RESULTED IN MINOR INJURIES TO THE DRIVER. AFTER THE CRASH, IT WAS DETERMINED THAT THE INTERMEDIATE SHAFT WAS EXHIBITING SOME BINDING OF THE STEERING INTERMEDIATE SHAFT BEARINGS.WHILE THE ABSENCE OF ADDITIONAL CRASHES OR INJURIES DOES NOT MEAN THAT THERE IS NOT A SAFETY-RELATED DEFECT, THERE HAVE BEEN NO REPORTED ADDITIONAL CRASHES CAUSED BY THE ALLEGED DEFECT IN THE PAST THREE YEARS. THE RELEASE OF THE TECHNICAL SERVICE BULLETIN SHOULD ASSIST SERVICE PERSONAL IN DIAGNOSING THIS POTENTIAL PROBLEM LONG BEFORE IT BECOMES POTENTIALLY DANGEROUS.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-017 CLOSING REPORT.
PE08033 · Steering Binding
Opened Apr 28, 2008 · Closed Aug 28, 2008
Status: closed (inferred from source dates) · Steering
ON APRIL 28, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED PRELIMINARY EVALUATION PE08-033 TO INVESTIGATE COMPLAINTS ALLEGING STEERING BINDING IN MODEL YEAR 2002 THROUGH 2004 KIA SEDONA MINIVANS.KIA'S RESPONSE TO ODI'S REQUEST FOR INFORMATION IN PE08-033 INDICATED THAT CONCERNS WITH BINDING OF THE STEERING INTERMEDIATE SHAFT WERE FIRST IDENTIFIED AND INVESTIGATED IN AUGUST 2002, IN VEHICLES SOLD IN INDONESIA.THIS INVESTIGATION RESULTED IN THE ADDITION OF A STIFFENING RIB TO THE BEARING CAP SEAL.IN JUNE 2003, KIA AGAIN INVESTIGATED OWNER COMPLAINTS OF STEERING NOISE AND HIGHER THAN NORMAL STEERING RESISTANCE AND IN OCTOBER AND NOVEMBER OF 2003 DESIGN CHANGES TO THE SHAFT UNIVERSAL JOINT BEARINGS WERE MADE TO IMPROVE LUBRICANT RETENTION AND ELIMINATE WATER INTRUSION THAT COULD LEAD TO EARLY BEARING FAILURE.ACCORDING TO KIA, THE ALLEGED DEFECT RESULTS IN A PROGRESSIVE CHANGE IN STEERING EFFORT THAT SHOULD BE APPARENT TO THE DRIVER THROUGH NOISE AND GRADUAL CHANGES IN STEERING STIFFNESS LONG BEFORE THE CONDITION COULD BECOME DANGEROUS. ODI'S ANALYSES OF COMPLAINT AND WARRANTY DATA RELATING TO THE ALLEGED DEFECT SHOW THAT THE CONDITION IS OCCURRING AT SIGNIFICANTLY HIGHER RATES IN SALT-BELT STATES (NOTE:FOR PURPOSES OF THIS INVESTIGATION THE SALT BELT INCLUDES CONNECTICUT, DELAWARE, THE DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA AND WISCONSIN).THE WARRANTY RATE FOR REPLACEMENT OF THE STEERING INTERMEDIATE SHAFT IS 5.5% FOR VEHICLES SOLD IN THE SALT BELT AND 0.5% FOR THE REST OF THE UNITED STATES.THE COMPLAINT RATE FOR THE ALLEGED DEFECT IS 186.8 PER 100,000 VEHICLES IN THE SALT BELT AND 29.4 PER 1000,000 VEHICLES FOR THE REST OF THE UNITED STATES.THERE IS ONE ALLEGATION OF A CRASH RELATED TO THE ALLEGED DEFECT.A SUBJECT VEHICLE STRUCK TWO PARKED CARS WHILE ATTEMPTING TO MAKE A LEFT TURN, ALLEGEDLY RESULTING IN MINOR INJURIES TO THE DRIVER. ODI HAS UPGRADED THIS INVESTIGATION TO AN ENGINEERING ANALYSIS (EA08-017) COVERING MY 2002 THROUGH 2004 KIA SEDONA VEHICLES SOLD OR CURRENTLY REGISTERED IN SALT BELT STATES TO ASSESS THE FREQUENCY AND TREND OF THE ALLEGED DEFECT AND ITS EFFECT ON STEERING EFFORT.
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Additional source detail variants (6)
Vehicle Speed Control:cables
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:cables
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
2004 Kia Sedona Problems, Complaints & Recalls | Skip That Year
Illustration