TL* THE CONTACT OWNS A 2004 KIA RIO. WHILE DRIVING APPROXIMATELY 50 MPH, THE WHEEL BEARING AND THE HUB FROM BOTH REAR WHEELS DETACHED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE WHEEL BEARINGS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE CONTACT STATED THAT THE REAR TIRE B…
Read full complaint
TL* THE CONTACT OWNS A 2004 KIA RIO. WHILE DRIVING APPROXIMATELY 50 MPH, THE WHEEL BEARING AND THE HUB FROM BOTH REAR WHEELS DETACHED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE WHEEL BEARINGS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE CONTACT STATED THAT THE REAR TIRE BEARINGS WERE PREVIOUSLY REPLACED MULTIPLE TIMES. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 163,000.
DT*: THE CONTACT STATED THE VEHICLE'S FRONT END MADE A LOUD CLANKING NOISE AND WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DETERMINED UPON EXAMINATION THAT BOTH ROTORS NEEDED TO BE REPLACED. THE MECHANIC REPLACED THE ROTORS. THEN, THE VEHICLE HAD PROBLEMS WITH THE REAR END, AND WAS TAKEN TO A LOCAL DEALER WHO DETERMINED THAT THE …
Read full complaint
DT*: THE CONTACT STATED THE VEHICLE'S FRONT END MADE A LOUD CLANKING NOISE AND WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DETERMINED UPON EXAMINATION THAT BOTH ROTORS NEEDED TO BE REPLACED. THE MECHANIC REPLACED THE ROTORS. THEN, THE VEHICLE HAD PROBLEMS WITH THE REAR END, AND WAS TAKEN TO A LOCAL DEALER WHO DETERMINED THAT THE AXLE BEARING WAS BAD AND THAT THE REAR WHEELS WERE BENT. THE DEALER PROVIDED THE VEHICLE WITH PROPER MAINTENANCE AND BRAKE SERVICE AND REPAIRED THE FUEL PUMP. THE VEHICLE WAS CURRENTLY AT THE DEALER FOR FURTHER EXAMINATION OF ONGOING PROBLEMS. NO FURTHER REPAIRS WERE MADE. UPDATED 03/19/07. *JB THE FUEL PUMP WAS REPALCED. UPDATED 09/25/07 *JB
CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, 'CHILD RESTRAINT ANCHORAGE SYSTEMS.' CERTAIN CHILD RESTRAINT ANCHORS WILL NOT FULLY LATCH ONTO THE LOWER LATCH ANCHORS LOCATED BETWEEN THE REAR SEAT BACK AND REAR SEAT CUSHION BECAUSE OF INTERFERENCE BETWEEN THE CHILD SEAT ANCHORS AND A METAL WIRE LOCATED IN THE FRAME OF THE REAR SEAT BACK. UNTIL THE RECALL REPAIR IS COMPLETED, FOLLOW THE INSTRUCTIONS PROVIDED BY YOUR CHILD SEATS MANUFACTURER ON HOW TO PROPERLY INSTALL THE CHILD SEAT WITH YOUR VEHICLE'S REAR SAFETY BELTS RATHER THAN USING THE LATCH SYSTEM.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, IF THE CHILD SEAT IS NOT PROPERLY INSTALLED, PERSONAL INJURY OR DEATH COULD OCCUR.
Remedy: DEALERS WILL REPLACE THE LOWER ANCHORS FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 30, 2006. OWNERS MAY CONTACT KIA AT 1-800-333-4542.
ON CERTAIN PASSENGER VEHICLES, THE FUEL INTAKE NIPPLE OF THE FUEL DISTRIBUTOR IS SUBJECT TO FRACTURE OR CRACKING DURING REMOVAL OF THE QUICK CONNECT COUPLING SECURING THE MAIN FUEL TUBE ASSEMBLY TO THE FUEL INTAKE NIPPLE, OR WHEN FORCE IS ACCIDENTALLY APPLIED TO THE INTAKE NIPPLE DURING THE VEHICLE ASSEMBLY PROCESS OR DURING ENGINE COMPARTMENT REPAIRS.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL DISTRIBUTOR AND MAIN FUEL TUBE ASSEMBLIES. THE RECALL BEGAN JUNE 18, 2004. OWNERS SHOULD CONTACT KIA AT 1-800-333-4542.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2004 Kia Rio Problems, Complaints & Recalls | Skip That Year
Illustration