Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 3 of 3 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Steering. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Visibility. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
What owners actually said
3 reports
130,000 miles · Aug 28, 2008
Steering
TL*THE CONTACT OWNS A 2007 KENWORTH T300. WHILE DRIVING APPROXIMATELY 18 MPH, THE STEERING WHEEL LOCKED WHEN A LEFT TURN WAS MADE. THE CONTACT HEARD AN EXCESSIVELY LOUD NOISE AT THE TIME OF THE FAILURE. HE ALSO EXPERIENCED DIFFICULTY WITH THE STEERING WHEEL PULLING TOWARDS THE LEFT. AFTERWARDS, THE STEERING WHEEL RELEASED AN…
Read full complaint
TL*THE CONTACT OWNS A 2007 KENWORTH T300. WHILE DRIVING APPROXIMATELY 18 MPH, THE STEERING WHEEL LOCKED WHEN A LEFT TURN WAS MADE. THE CONTACT HEARD AN EXCESSIVELY LOUD NOISE AT THE TIME OF THE FAILURE. HE ALSO EXPERIENCED DIFFICULTY WITH THE STEERING WHEEL PULLING TOWARDS THE LEFT. AFTERWARDS, THE STEERING WHEEL RELEASED AND WAS OPERABLE. THE FAILURE OCCURRED WITHOUT PRIOR WARNING. THE FAILURE RECURRED ON FIFTEEN SEPARATE OCCASIONS. THE VEHICLE WAS TAKEN TO THE AUTHORIZED DEALER ON THREE OCCASIONS, BUT THE FAILURE PERSISTS. THE VEHICLE HAS BEEN TAKEN TO THE AUTHORIZED DEALER FOR DIAGNOSTIC TESTING. THE VIN WAS UNKNOWN. THE FAILURE WAS MILEAGE 130,000 AND CURRENT MILEAGE WAS 149,615.
NHTSA ODI #10240128
130,000 miles · Aug 28, 2008
Steering
TL*THE CONTACT OWNS A 2007 KENWORTH T300. WHILE DRIVING APPROXIMATELY 18 MPH, THE STEERING WHEEL LOCKED WHEN A LEFT TURN WAS MADE. THE CONTACT HEARD AN EXCESSIVELY LOUD NOISE AT THE TIME OF THE FAILURE. HE ALSO EXPERIENCED DIFFICULTY WITH THE STEERING WHEEL PULLING TOWARDS THE LEFT. AFTERWARDS, THE STEERING WHEEL RELEASED AN…
Read full complaint
TL*THE CONTACT OWNS A 2007 KENWORTH T300. WHILE DRIVING APPROXIMATELY 18 MPH, THE STEERING WHEEL LOCKED WHEN A LEFT TURN WAS MADE. THE CONTACT HEARD AN EXCESSIVELY LOUD NOISE AT THE TIME OF THE FAILURE. HE ALSO EXPERIENCED DIFFICULTY WITH THE STEERING WHEEL PULLING TOWARDS THE LEFT. AFTERWARDS, THE STEERING WHEEL RELEASED AND WAS OPERABLE. THE FAILURE OCCURRED WITHOUT PRIOR WARNING. THE FAILURE RECURRED ON FIFTEEN SEPARATE OCCASIONS. THE VEHICLE WAS TAKEN TO THE AUTHORIZED DEALER ON THREE OCCASIONS, BUT THE FAILURE PERSISTS. THE VEHICLE HAS BEEN TAKEN TO THE AUTHORIZED DEALER FOR DIAGNOSTIC TESTING. THE VIN WAS UNKNOWN. THE FAILURE WAS MILEAGE 130,000 AND CURRENT MILEAGE WAS 149,615.
NHTSA ODI #10240100
10,000 miles · Jun 27, 2008
Visibility
TL*THE CONTACT OWNS A 2007 KENWORTH T300. WHEN THE CONTACT CLOSED THE DRIVER'S SIDE DOOR WHILE THE VEHICLE WAS PARKED, THE WINDSHIELD DETACHED FROM THE BODY STRUCTURE. THERE WAS NO WARNING PRIOR TO THE FAILURE. HE WAS VERY CONCERNED OF THE SAFETY RISK INVOLVED AND THE POSSIBILITY OF THE WINDSHIELD DETACHING WHILE THE VEHICLE …
Read full complaint
TL*THE CONTACT OWNS A 2007 KENWORTH T300. WHEN THE CONTACT CLOSED THE DRIVER'S SIDE DOOR WHILE THE VEHICLE WAS PARKED, THE WINDSHIELD DETACHED FROM THE BODY STRUCTURE. THERE WAS NO WARNING PRIOR TO THE FAILURE. HE WAS VERY CONCERNED OF THE SAFETY RISK INVOLVED AND THE POSSIBILITY OF THE WINDSHIELD DETACHING WHILE THE VEHICLE WAS IN MOTION. THE VEHICLE HAS NOT BEEN REPAIRED. THE VIN WAS UNKNOWN. THE FAILURE AND CURRENT MILEAGES WERE 10,000. THE CONSUMER STATED THE DESIGN OF THE GASKET THAT WAS SUPPOSE TO HOLD THE GLASS TO THE TRUCK. THE WINDSHIELD WAS HELD IN PLACE BY A LARGE RUBBER GASKET. THE CONSUMER BELIEVED THE MANUFACTURER WAS LOOKING TO CUT INSTALLATION TIME AND COST WITHOUT DEVELOPING A NEW WINDSHIELD. UPDATED 07/15/08
PACCAR IS RECALLING 36 MY 2007-2008 T270, T370 AND MY 207 T300 TRUCKS EQUIPPED WITH DUAL UNDER-CAB FUEL TANKS AND AN IN-CAB BATTERY BOX (ICBB). A HARNESS SUPPORT BRACKET MOUNTED ON THE UNDERSIDE OF THE CAB MAY COME IN CONTACT WITH THE FUEL LINE AT THE TOP OF THE FUEL SPLITTER VALVE.
Consequence & remedy
Consequence: THE EDGE OF THE BRACKET MAY COMPROMISE THE FUEL LINE CAUSING AN INTERRUPTION IN FUEL FLOW, OR LOSS OF FUEL RESULTING IN COMPROMISED VEHICLE PERFORMANCE OR POTENTIALLY CAUSING A FIRE.
Remedy: DEALERS WILL RE-WORK THE EXISTING ICBB CABLE ROUTING BRACKET AND REPLACE THE FUEL SPLITTER VALVE BRACKET TO PROVIDE ADEQUATE CLEARANCE BETWEEN COMPONENTS. THE RECALL BEGAN O JUNE 30, 2008. OWNERS MAY CONTACT KENWORTH AT 1-425-828-5440.
ON CERTAIN TRUCKS EQUIPPED WITH CUMMINS ISC OR PACCAR PX8 ENGINES, THE JUMPER WIRE BETWEEN THE GRID HEATER RELAY TO THE FUSE BLOCK HAS BEEN ROUTED IN SUCH A WAY THAT THE POTENTIAL EXISTS FOR IT TO RUB AGAINST THE RADIATOR SUPPORT.
Consequence & remedy
Consequence: THE SUSPECT WIRE IS DOWN STREAM OF THE FUSE; THIS CHAFF POINT COULD CAUSE THE 250 AMP CHARGE WIRE TO ARC, POTENTIALLY CAUSING A FIRE.
Remedy: DEALERS WILL INSPECT THE ROUTING OF THE JUMPER WIRE. IF THE WIRE IS NOT ROUTED CORRECTLY, IT WILL BE INSPECTED FOR RUBBING OR CHAFFING AND REPLACED IF NECESSARY FREE OF CHARGE. THE RECALL BEGAN ON JUNE 22, 2007. OWNERS MAY CONTACT KENWORTH AT 425-828-5440.
ON CERTAIN TRUCKS, THE AXLE HOUSINGS MAY HAVE BEEN MANUFACTURED WITH STEEL THAT WAS OUT OF SPECIFICATION WHICH COULD RESULT IN A FATIGUE FAILURE OVER TIME.
Consequence & remedy
Consequence: IF A FATIGUE FAILURE OCCURS AND IS LEFT UNATTENDED, THE AXLE MAY LOCK UP OR THE END OF THE AXLE COULD COME OFF, WHICH MAY RESULT IN A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT AND REPLACE THE AXLES FREE OF CHARGE. THE RECALL BEGAN ON MAY 9, 2007. OWNERS MAY CONTACT KENWORTH AT 425-828-5440 AND PETERBILT AT 1-940-591-4196.
ON CERTAIN TRUCKS, THE WIRING, PARTS, OR TRANSMISSION PROGRAMMING REQUIRED FOR THE AUTO NEUTRAL FEATURE TO FUNCTION AS DESIGNED WERE EITHER NOT INSTALLED, CONNECTED, OR PROGRAMMED PROPERLY.
Consequence & remedy
Consequence: IF ANY OF THESE CONDITIONS EXISTS, THE TRANSMISSION WILL NOT AUTOMATICALLY SHIFT INTO NEUTRAL WHEN LEFT IN DRIVE WITH THE PARKING BRAKE SET ENGAGED. THE VEHICLE COULD MOVE WITHOUT WARNING INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE AFFECTED VEHICLES TO ENSURE THE AUTO NEUTRAL FEATURE FUNCTIONS PROPERLY AND, IF NEEDED, WILL MAKE THE NECESSARY REPAIRS FREE OF CHARGE. THE RECALL BEGAN ON MAY 9, 2007. OWNERS MAY CONTACT KENWORTH AT 425-828-5440.
CERTAIN TRUCKS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 121, "AIR BRAKE SYSTEMS." THE TRAILER LIGHT LINE MAY HAVE BEEN ROUTED USING TOO TIGHT OF A BEND RADIUS. THIS ROUTING METHOD COULD CAUSE THE WIRES WITHIN THE HARNESS PLUG TO BE PULLED AWAY FROM THE CHASSIS PLUG RESULTING IN AN INTERMITTENT OR COMPLETE ELECTRICAL POWER LOSS TO THE TRAILER.
Consequence & remedy
Consequence: SHOULD POWER BE LOST, THE ELECTRICAL CIRCUITS WOULD NOT PROVIDE POWER TO THE ANTILOCK SYSTEM ON THE TOWED VEHICLE INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REROUTE THE LIGHT LINE TO ELIMINATE THE EXCESSIVE BEND RADIUS AND REPLACE ANY PLUG OR HARNESS THAT HAS BEEN DAMAGED FREE OF CHARGE. THE RECALL BEGAN ON APRIL 16, 2007. OWNER MAY CONTACT KENWORTH AT 425-828-5440.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
EA09008 · Horton Fan Hub Failures
Opened May 29, 2009 · Closed Aug 27, 2010
Status: closed (inferred from source dates) · Engine And Engine Cooling:cooling System:fan
PACCAR is conducting an Owner Notification Program (ONP) for select vehicles within the subject and peer populations.The ONP are attached to the closing report and can be found in the NHTSA Technical Service Bulletin (TSB) database. (TSB: 10033585, 10033584)See Closing report for investigation details.
2007 Kenworth T300 Problems, Complaints & Recalls | Skip That Year
Illustration