ON CERTAIN TRUCKS EQUIPPED WITH CUMMINS ISC OR PACCAR PX8 ENGINES, THE JUMPER WIRE BETWEEN THE GRID HEATER RELAY TO THE FUSE BLOCK HAS BEEN ROUTED IN SUCH A WAY THAT THE POTENTIAL EXISTS FOR IT TO RUB AGAINST THE RADIATOR SUPPORT.
Consequence & remedy
Consequence: THE SUSPECT WIRE IS DOWN STREAM OF THE FUSE; THIS CHAFF POINT COULD CAUSE THE 250 AMP CHARGE WIRE TO ARC, POTENTIALLY CAUSING A FIRE.
Remedy: DEALERS WILL INSPECT THE ROUTING OF THE JUMPER WIRE. IF THE WIRE IS NOT ROUTED CORRECTLY, IT WILL BE INSPECTED FOR RUBBING OR CHAFFING AND REPLACED IF NECESSARY FREE OF CHARGE. THE RECALL BEGAN ON JUNE 22, 2007. OWNERS MAY CONTACT KENWORTH AT 425-828-5440.
ON CERTAIN TRUCKS, THE WIRING, PARTS, OR TRANSMISSION PROGRAMMING REQUIRED FOR THE AUTO NEUTRAL FEATURE TO FUNCTION AS DESIGNED WERE EITHER NOT INSTALLED, CONNECTED, OR PROGRAMMED PROPERLY.
Consequence & remedy
Consequence: IF ANY OF THESE CONDITIONS EXISTS, THE TRANSMISSION WILL NOT AUTOMATICALLY SHIFT INTO NEUTRAL WHEN LEFT IN DRIVE WITH THE PARKING BRAKE SET ENGAGED. THE VEHICLE COULD MOVE WITHOUT WARNING INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE AFFECTED VEHICLES TO ENSURE THE AUTO NEUTRAL FEATURE FUNCTIONS PROPERLY AND, IF NEEDED, WILL MAKE THE NECESSARY REPAIRS FREE OF CHARGE. THE RECALL BEGAN ON MAY 9, 2007. OWNERS MAY CONTACT KENWORTH AT 425-828-5440.
AN INCORRECT SWITCH WAS INSTALLED IN THE CRUISE CONTROL SYSTEM ON CERTAIN MODEL T300 TRUCKS.
Consequence & remedy
Consequence: A LIGHT APPLICATION OF THE BRAKES WILL NOT DEACTIVATE THE CRUISE CONTROL AND THE SYSTEM WILL HAVE TO BE SHUT OFF BY THE DASH SWITCH. THIS COULD LEAD TO UNINTENDED ACCELERATION AND A CRASH WITHOUT WARNING.
Remedy: KENWORTH WILL INSTALL THE CORRECT SENSOR SWITCH. THE RECALL BEGAN ON JANUARY 10, 2007. OWNERS MAY CONTACT KENWORTH AT 1-425-828-5440.
ON CERTAIN TRUCKS EQUIPPED WITH HYDRAULIC BRAKES, THERE MAY BE A DEFECT IN THE ANCHOR BOLT OF SOME BOSCH MODEL #305 PARKING BRAKE ASSEMBLIES. A DIFFERENT COATING WAS APPLIED TO THE BOLT WHICH DID NOT MEET PACCAR SPECIFICATIONS. THIS COULD REDUCE THE FATIGUE LIFE OF THE BOLT AND LEAD TO PREMATURE FAILURE.
Consequence & remedy
Consequence: IF THIS BOLT WERE TO FAIL, THE TRUCK COULD ROLL AWAY WHILE PARKED WITHOUT WARNING, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSPECT THE PARKING BRAKE ASSEMBLY AND REPLACE THE DEFECTIVE BOLTS FREE OF CHARGE. PETERBILT'S RECALL BEGAN ON NOVEMBER 4, 2005; AND KENWORTH BEGAN ON NOVEMBER 4, 2005. OWNERS MAY CONTACT KENWORTH AT 1-425-828-5440 OR PETERBILT AT 1-940-591-4201.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS PRELIMINARY EVALUATION OF KENWORTH PRODUCTS BASED ON THEIR FIELD COMMUNICATION TIB # 34-31.KENWORTH INTRODUCED THE QCS II STA-DRY TRAILER CABLE IN MAY 2006.THE TECHNICAL INFORMATION BULLETIN STEMMED FROM FIELD FEEDBACK THAT INDICATED A FLEXIBILITY PROBLEM WITH THE QCS II CABLE CONNECTION, WHICH COULD RESULT IN A LOSS OF LIGHTING TO THE TRAILER.ODI BELIEVES A LOSS OF LIGHTING WOULD ADVERSELY AFFECT THE TRAILER'S VISIBILITY. FURTHER, THE RESULTING LOSS OF BRAKE LIGHTS IS INHERENTLY CRITICAL TO HIGHWAY SAFETY, DAY OR NIGHT.KENWORTH HAS UPGRADED THE TIB REPAIR TO A SAFETY RECALL.KENWORTH DEALERS WILL INSTALL A REINFORCEMENT BRACKET BETWEEN THE BACK OF THE QCS II MOLDED BOOT AND THE FRAME BRACKET, THUS PROVIDING ABETTER CABLE CONNECTION. THE DEFECT NOTIFICATION WAS SUBMITTED ON 4/25/08 (COPY ATTACHED).TRAILERS BUILT BETWEEN MAY 24 AND NOVEMBER 21, 2006 (MODEL YEAR 2007 TRAILERS) WILL BE REMEDIED.THE POPULATION TO BE REMEDIED IS 3,573 IN THE UNITED STATES.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Electrical System
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS PRELIMINARY EVALUATION OF KENWORTH PRODUCTS BASED ON THEIR FIELD COMMUNICATION TIB # 34-31.KENWORTH INTRODUCED THE QCS II STA-DRY TRAILER CABLE IN MAY 2006.THE TECHNICAL INFORMATION BULLETIN STEMMED FROM FIELD FEEDBACK THAT INDICATED A FLEXIBILITY PROBLEM WITH THE QCS II CABLE CONNECTION, WHICH COULD RESULT IN A LOSS OF LIGHTING TO THE TRAILER.ODI BELIEVES A LOSS OF LIGHTING WOULD ADVERSELY AFFECT THE TRAILER'S VISIBILITY. FURTHER, THE RESULTING LOSS OF BRAKE LIGHTS IS INHERENTLY CRITICAL TO HIGHWAY SAFETY, DAY OR NIGHT.KENWORTH HAS UPGRADED THE TIB REPAIR TO A SAFETY RECALL.KENWORTH DEALERS WILL INSTALL A REINFORCEMENT BRACKET BETWEEN THE BACK OF THE QCS II MOLDED BOOT AND THE FRAME BRACKET, THUS PROVIDING ABETTER CABLE CONNECTION. THE DEFECT NOTIFICATION WAS SUBMITTED ON 4/25/08 (COPY ATTACHED).TRAILERS BUILT BETWEEN MAY 24 AND NOVEMBER 21, 2006 (MODEL YEAR 2007 TRAILERS) WILL BE REMEDIED.THE POPULATION TO BE REMEDIED IS 3,573 IN THE UNITED STATES.THIS INVESTIGATION IS CLOSED.
Exterior Lighting
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS PRELIMINARY EVALUATION OF KENWORTH PRODUCTS BASED ON THEIR FIELD COMMUNICATION TIB # 34-31.KENWORTH INTRODUCED THE QCS II STA-DRY TRAILER CABLE IN MAY 2006.THE TECHNICAL INFORMATION BULLETIN STEMMED FROM FIELD FEEDBACK THAT INDICATED A FLEXIBILITY PROBLEM WITH THE QCS II CABLE CONNECTION, WHICH COULD RESULT IN A LOSS OF LIGHTING TO THE TRAILER.ODI BELIEVES A LOSS OF LIGHTING WOULD ADVERSELY AFFECT THE TRAILER'S VISIBILITY. FURTHER, THE RESULTING LOSS OF BRAKE LIGHTS IS INHERENTLY CRITICAL TO HIGHWAY SAFETY, DAY OR NIGHT.KENWORTH HAS UPGRADED THE TIB REPAIR TO A SAFETY RECALL.KENWORTH DEALERS WILL INSTALL A REINFORCEMENT BRACKET BETWEEN THE BACK OF THE QCS II MOLDED BOOT AND THE FRAME BRACKET, THUS PROVIDING ABETTER CABLE CONNECTION. THE DEFECT NOTIFICATION WAS SUBMITTED ON 4/25/08 (COPY ATTACHED).TRAILERS BUILT BETWEEN MAY 24 AND NOVEMBER 21, 2006 (MODEL YEAR 2007 TRAILERS) WILL BE REMEDIED.THE POPULATION TO BE REMEDIED IS 3,573 IN THE UNITED STATES.THIS INVESTIGATION IS CLOSED.
2006 Kenworth T300 Problems, Complaints & Recalls | Skip That Year
Illustration