IllustrationPulled out of parking lot and into street. Several different warnings came on and the vehicle stopped on its on and became totally unresponsive in the middle of the street. Warnings included E-drive charging fault, check engine, shift error, among many others. Car push button would not allow the car to turn off.
2021 Jeep Wrangler
Owner reports · Recalls · Investigations
More warning signs than most Wrangler years
Owner complaints for the 2021 Jeep Wrangler are substantially higher than the model-year median of 265.
About this comparison →How this year compares
Owner complaints by model year
Compare all Wrangler years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 117 of 913 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 302 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 249 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 215 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
20 crash reports27 fire reports9 injury reports
What owners actually said
913 reportsThe vehicle gave a Service Hybrid Electric System error and disabled the engine at approximately 60 mph when traveling in E-Save mode, with <1% battery, and half a tank of gasoline. After navigating the vehicle to the side of the road, it came to a hard stop at about 5-8 mph. After 10 minutes, the vehicle restarted in Hybrid mod…
Read full complaint
The vehicle gave a Service Hybrid Electric System error and disabled the engine at approximately 60 mph when traveling in E-Save mode, with <1% battery, and half a tank of gasoline. After navigating the vehicle to the side of the road, it came to a hard stop at about 5-8 mph. After 10 minutes, the vehicle restarted in Hybrid mode as was able to operate without error until reaching our destination. Weather conditions were clear at 85 degrees. Issues occurred on a two-lane byway. No injuries, other damage, or police reports at this time. The vehicle will be delivered for service for recreation and diagnosis of the issue. Issue occurred with approximately 246 miles, direct from the dealership upon delivery. The vehicle has no aftermarket accessories.
The contact owns a 2021 Jeep Wrangler. The contact stated that while driving at approximately 41 mph, the hybrid mode failed to let the engine operate and the vehicle stalled without warning. The contact mentioned that the power steering also ceased. The vehicle was restarted later under E-save mode. The vehicle was taken to the…
Read full complaint
The contact owns a 2021 Jeep Wrangler. The contact stated that while driving at approximately 41 mph, the hybrid mode failed to let the engine operate and the vehicle stalled without warning. The contact mentioned that the power steering also ceased. The vehicle was restarted later under E-save mode. The vehicle was taken to the dealer however, the mechanic failed to diagnose the vehicle. The vehicle was taken to another dealer where it was partially diagnosed that the Transmission Control Module was disabled. The vehicle was not repaired. The manufacturer was notified of the failure and provided a case number. The approximate failure mileage was 940.
Driving down the road and ALL the warning lights came on at the same time. They were flashing across the dash one at a time. We got a sway bar warning, an airbag warning, check engine light came on and then all of the sudden we lost power steering. It took all my husband's strength to control the vehicle when the power steeri…
Read full complaint
Driving down the road and ALL the warning lights came on at the same time. They were flashing across the dash one at a time. We got a sway bar warning, an airbag warning, check engine light came on and then all of the sudden we lost power steering. It took all my husband's strength to control the vehicle when the power steering went out. We had to maneuver to the side of the road. If I had been driving, I fear what would have happened. We had the vehicle taken to our local dealer. Darcars Chrysler Plymouth and Jeep in Waldorf MD. The service technician there said he had no idea what was wrong and it would take several days to get it looked at. We took to the internet to research our issue. We found over and over people with a Jeep Wrangler Rubicon from model years 2019-2021 having the same issues. The issue turns out to be a problem with the "wiring harness". The Jeep forums online have documented instances of this problem by many, many people. Jeep should be forced to recall these wiring harnesses since they won't do a voluntary recall. This is a dangerous defect. Our vehicle has 6,000 miles on it. Our vehicle is available to inspect at the dealer. Someone is going to die if this defect isn't addressed.
The actual malfunctioning issue is UNKNOWN. However, my best explanation is as follows: While driving my new 2021 Jeep Wrangler Rubicon (which only has 1400 miles), on the highway at roughly 70 miles per hour and going up a hill, the vehicle felt as if it were trying to up-shift a gear but then immediately down-shift a gear. Thi…
Read full complaint
The actual malfunctioning issue is UNKNOWN. However, my best explanation is as follows: While driving my new 2021 Jeep Wrangler Rubicon (which only has 1400 miles), on the highway at roughly 70 miles per hour and going up a hill, the vehicle felt as if it were trying to up-shift a gear but then immediately down-shift a gear. This up-shift and down-shift feeling continued in quick repetition over and over in a violent shaking manner that thrust the entire vehicle forwards and backwards as long as I continued the acceleration up the hill. Letting off the accelerator seemed to end the violent shaking. I pulled over on to the side of the highway to stop, and turned off the Jeep since the check engine light came on. I waited about five minutes and started up the Jeep again. The check engine light was still on, though. Any acceleration at any speed now causes the Jeep to violently thrust forwards and backwards like I experienced on the highway. I tried to get Jeep Roadside to tow the Jeep to a dealership, but learned how worthless this Jeep Roadside program truly was. Several days after this incident, and I still do not have my Jeep at a dealership for repairs, nor do I have a rental. Jeep Roadside refuses to tow my Jeep to a dealership that has a rental, and I cannot afford to pay the towing fee's to get to a dealership with a rental. The nearest dealerships tell me they are six to eight weeks out on loaner vehicles. I'm too worried to try and driving my Jeep the distance to reach a dealership with a rental, cause it is way too unsafe to operate this Jeep with the violent shaking. I'm curious if anyone else is having this same issue, or knows more.
VEHICLE WANDERS AT HIGHWAY SPEEDS AS WELL AS LOW SPEEDS. REQUIRES CONSTANT "ARMS/HANDS" PRESSURE TO KEEP VEHICLE TRACKING STRAIGHT. TRAVELLING ON A CURVY ROAD REGULARY THE VEHICLE ENDS UP CROSSING OVER THE YELLOW LINES ON OCCASION CAUSING A PANIC FOR ME AND ANY APPROACHING VEHICLE - SO FAR NO ACCIDENT. THE DEALER INSTALLED A PAR…
Read full complaint
VEHICLE WANDERS AT HIGHWAY SPEEDS AS WELL AS LOW SPEEDS. REQUIRES CONSTANT "ARMS/HANDS" PRESSURE TO KEEP VEHICLE TRACKING STRAIGHT. TRAVELLING ON A CURVY ROAD REGULARY THE VEHICLE ENDS UP CROSSING OVER THE YELLOW LINES ON OCCASION CAUSING A PANIC FOR ME AND ANY APPROACHING VEHICLE - SO FAR NO ACCIDENT. THE DEALER INSTALLED A PART RECOMMENDED BY JEEP BUT DID NOT FIX ISSUE.
2021 Jeep Wrangler JL, build date 05/2021, apprx 1,000 miles, has the newer steering gear (black) that was supposed to fix the steering issue that Jeep has had since 2019. The Jeep is wandering within lane and requires constant wheel correction to stay within lane. This happens at slower speeds and highway speeds. Steering is ov…
Read full complaint
2021 Jeep Wrangler JL, build date 05/2021, apprx 1,000 miles, has the newer steering gear (black) that was supposed to fix the steering issue that Jeep has had since 2019. The Jeep is wandering within lane and requires constant wheel correction to stay within lane. This happens at slower speeds and highway speeds. Steering is overly sensitive. Lane changing requires overcorrection due to the wandering. Difficult to hold straight line. Dealer says nothing is wrong and that's how it is and nothing they can do to fix. Dealer states they cannot duplicate. This is a known issue from FCA on previous years and has continued into some 2021 models. Not being able to drive within the lanes poses a hazard to driver, passengers, and other vehicles on the road. Overcorrection due to extreme sensitivity will create a roll over hazard.
It's over heating while drive at has 12000 miles on it and getting over 250 degrees derating and dash lights came on flashing red saying over heating to hot air shut off going 60 miles an hour. Had to pull off road because it had no gas pedal with cars behind me almost getting hit.
The backup camera turns off completely and the line marks for the parking spot disappears. According to the dealership this is a manufacturer defect that the manufacturer is aware of but haven't taken any actions. It is a dangerous situation as the backup camera is standard feature in all cars and people rely on the camera when …
Read full complaint
The backup camera turns off completely and the line marks for the parking spot disappears. According to the dealership this is a manufacturer defect that the manufacturer is aware of but haven't taken any actions. It is a dangerous situation as the backup camera is standard feature in all cars and people rely on the camera when backing up the vehicle.
A charging system error caused engine to shut down. I was driving down the road at about 30-40 mph and the vehicle just shut down. I was stopped in the right lane of traffic. A red plug appeared on the instrument panel. The vehicle started back up after several attempts to restart it. The red plug disappeared. I was able to driv…
Read full complaint
A charging system error caused engine to shut down. I was driving down the road at about 30-40 mph and the vehicle just shut down. I was stopped in the right lane of traffic. A red plug appeared on the instrument panel. The vehicle started back up after several attempts to restart it. The red plug disappeared. I was able to drive the rest of the way home with no issues (about 1 mile). When the vehicle stopped it was in electric mode, had about 50% battery left, and had slightly less than a quarter tank of gas. I called dealer and made a service appointment for today. The vehicle was at the service department for about 3 weeks previously for the service light being on. We picked up the vehicle 2 weeks ago and the issue was not resolved. We had been texting with the service advisor about it while it was there and as soon as we picked it up and noticed the service light was still on he quit responding to us and would not get back with us.
Official recalls
1526V363000 · Steering:hydraulic Power Assist:pump
Jun 4, 2026
Chrysler (FCA US, LLC) is recalling certain 2021-2025 Jeep Wrangler, Wrangler 4XE, and Jeep Gladiator vehicles. The electric hydraulic power steering pump wiring may overheat and cause a vehicle fire, even when the vehicle is parked with the ignition in the "Off" position.
Consequence & remedy
Consequence: A vehicle fire increases the risk of injury.
Remedy: Owners are advised to park outside and away from structures, until their vehicle is repaired. Dealers will inspect and replace the wiring and electric hydraulic power steering pump, as necessary, free of charge. Owner notification letters are expected to be mailed July 9, 2026. Owners may contact FCA US LLC customer service at 1-800-853-1403. FCA US LLC's number for this recall is 21D. The Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov on June 11, 2026.
25V741000 · Electrical System:propulsion System:traction Battery
Oct 30, 2025
Chrysler (FCA US, LLC) is recalling certain 2020-2025 Jeep Wrangler 4Xe and 2022-2026 Grand Cherokee 4Xe vehicles. The high voltage battery may fail internally and lead to a vehicle fire while parked or driving.
Consequence & remedy
Consequence: A vehicle fire can increase the risk of injury.
Remedy: Owners are advised to park outside and away from structures and not to charge their vehicles until the remedy is completed. Dealers will update the high voltage battery software, and replace the high voltage battery, as necessary, free of charge. Some owner notification letters were mailed beginning December 17, 2025. The remaining owner notification letters will be mailed at a later date. Owners may contact Chrysler customer service at 800-853-1403. Chrysler's number for this recall is 68C. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning November 6, 2025. Vehicles that were previously recalled for the same issue under NHTSA Recalls 24V720 and 23V787 will need to have the new remedy performed.
24V676000 · Back Over Prevention: Sensing System: Camera; Exterior Lighting:brake Lights
Sep 12, 2024
Chrysler (FCA US, LLC) is recalling certain 2018-2024 Jeep Wrangler vehicles. The wiring harness for the rearview camera and the center brake light may short circuit, which can disable the rearview camera image and center brake light. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 111, "Rear Visibility" and 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: A rearview camera image that does not display decreases the driver's visibility, increasing the risk of a crash. Additionally, a center brake light that fails to illuminate can fail to indicate to other drivers that the vehicle is slowing down, increasing the risk of a crash.
Remedy: Dealers replaced the harness for the center brake light and rearview camera and/or the spare tire carrier/harness assembly, as necessary, free of charge. All vehicles were repaired by January 15, 2024. Owner notification letters were mailed September 26, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 77B.
Additional source detail variants (2)
Back Over Prevention: Sensing System: Camera
Chrysler (FCA US, LLC) is recalling certain 2018-2024 Jeep Wrangler vehicles. The wiring harness for the rearview camera and the center brake light may short circuit, which can disable the rearview camera image and center brake light. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 111, "Rear Visibility" and 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence: A rearview camera image that does not display decreases the driver's visibility, increasing the risk of a crash. Additionally, a center brake light that fails to illuminate can fail to indicate to other drivers that the vehicle is slowing down, increasing the risk of a crash.
Remedy: Dealers replaced the harness for the center brake light and rearview camera and/or the spare tire carrier/harness assembly, as necessary, free of charge. All vehicles were repaired by January 15, 2024. Owner notification letters were mailed September 26, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 77B.
Exterior Lighting:brake Lights
Chrysler (FCA US, LLC) is recalling certain 2018-2024 Jeep Wrangler vehicles. The wiring harness for the rearview camera and the center brake light may short circuit, which can disable the rearview camera image and center brake light. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 111, "Rear Visibility" and 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence: A rearview camera image that does not display decreases the driver's visibility, increasing the risk of a crash. Additionally, a center brake light that fails to illuminate can fail to indicate to other drivers that the vehicle is slowing down, increasing the risk of a crash.
Remedy: Dealers replaced the harness for the center brake light and rearview camera and/or the spare tire carrier/harness assembly, as necessary, free of charge. All vehicles were repaired by January 15, 2024. Owner notification letters were mailed September 26, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 77B.
24V652000 · Electrical System: Instrument Cluster/panel
Sep 5, 2024
Chrysler (FCA US, LLC) is recalling certain 2020-2024 Jeep Gladiator and 2018-2024 Jeep Wrangler vehicles. The instrument panel cluster may experience an internal short circuit and fail. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 101, "Controls and Displays."
Consequence & remedy
Consequence: An instrument panel that fails to display critical safety information, such as the speedometer or warning lights, can increase the risk of a crash.
Remedy: Dealers will replace the instrument panel cluster, free of charge. Owner notification letters were mailed between October 3, 2024, and January 23, 2025. Owners may contact FCA customer service at 1-800-853-1403. FCA's number for this recall is 30B.
24V572000 · Power Train:manual Transmission:control Module:software
Aug 1, 2024
Chrysler (FCA US, LLC) is recalling certain 2021 Jeep Wrangler and Jeep Gladiator vehicles that were previously remedied under NHTSA recall number 23V-116. The software for the powertrain control module may cause an engine stall, which can result in a loss of drive power.
Consequence & remedy
Consequence: A loss of drive power increases the risk of a crash.
Remedy: Dealers will update the powertrain control module software, free of charge. Owner notification letters were mailed August 15, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US LLC's number for this recall is 92B. Vehicles previously repaired under recall 23V-116 will need to have the new remedy completed.
24V111000 · Visibility:defroster/defogger/hvac System
Feb 15, 2024
Chrysler (FCA US, LLC) is recalling certain 2021-2024 Jeep Wrangler and 2022-2024 Jeep Grand Cherokee vehicles. A hybrid control processor (HCP) software error may cause the defrosting and defogging system to be inoperative. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 103, "Windshield Defrosting and Defogging Systems."
Consequence & remedy
Consequence: An inoperative windshield defrosting and defogging system may decrease the driver's visibility, increasing the risk of a crash.
Remedy: Dealers will update the HCP software, free of charge. Owner notification letters were mailed February 29, 2024. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is 04B.
23V787000 · Electrical System:propulsion System:traction Battery
Nov 22, 2023
Chrysler (FCA US, LLC) is recalling certain 2021-2023 Jeep Wrangler Plug-In Hybrid Electric (PHEV) vehicles. The high voltage battery may fail internally and lead to a vehicle fire while parked or driving.
Consequence & remedy
Consequence: A vehicle fire while parked or driving can increase the risk of injury.
Remedy: Owners are advised not to recharge their vehicles, and to park outside and away from structures, until they are repaired. Dealers will update the high voltage battery pack software and replace the battery pack assembly if necessary, free of charge. Owner notification letters were mailed March 7, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 89A. This recall is superseded by NHTSA Recall 24V-720.
23V263000 · Fuel System, Diesel:delivery:fuel Pump
Apr 13, 2023
Chrysler (FCA US, LLC) is recalling certain 2021-2023 Jeep Wrangler, Gladiator, and 2022-2023 Ram 1500 vehicles equipped with a 3.0L diesel engine. The high pressure fuel pump (HPFP) may fail.
Consequence & remedy
Consequence: Fuel pump failure can result in an engine stall, increasing the risk of a crash.
Remedy: Dealers will replace the HPFP and replace additional fuel system components, as necessary, free of charge. Owner notification letters were mailed October 17, 2023. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 01A.
23V191000 · Structure:frame And Members
Mar 23, 2023
Chrysler (FCA US, LLC) is recalling certain 2020-2022 Jeep Wrangler vehicles. A stud on the frame assembly may puncture the fuel tank in a crash, which can result in a fuel leak.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Dealers will inspect and, if necessary, remove the frame stud and apply paint, free of charge. Owner notification letters were mailed April 6, 2023. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 28A.
23V116000 · Power Train:clutch Assembly
Feb 23, 2023
Chrysler (FCA US, LLC) is recalling certain 2018-2023 Jeep Wrangler, and 2020-2023 Jeep Gladiator vehicles equipped with manual transmissions. The clutch pressure plate may overheat and fracture.
Consequence & remedy
Consequence: Overheated clutch components may increase the risk of a fire. Additionally, damage to other nearby components can result in debris falling onto the road or a loss of drive, increasing the risk of a crash.
Remedy: Dealers will replace the clutch assembly and update the software, free of charge. Owner notification letters were mailed from November 16, 2023 through July 25, 2024. Owners may contact (FCA US, LLC) customer service at 1-800-853-1403. FCA US LLC's number for this recall is 19A. This recall expands and replaces previous recall 21V-028. Vehicles previously repaired under recall 21V-028 will need to have the new remedy completed.
22V865000 · Engine
Nov 23, 2022
Chrysler (FCA US, LLC) is recalling certain 2021-2023 Jeep Wrangler 4xe vehicles equipped with 2.0L Plug-In Hybrid Electric Vehicle engines. A loss of communication may cause an engine shutdown.
Consequence & remedy
Consequence: An engine shutdown can cause a loss of drive power, increasing the risk of a crash.
Remedy: There is more than one involved component and calibration software. Updating the calibration software in the Transmission Control Module, Hybrid Control Processor and Auxiliary Hybrid Control Processor that changes fail safe from shut down to limp home. Dealers will update the transmission control module software, Hybrid Control Processor and Auxiliary Hybrid Control Processor, free of charge. Owner notification letters were mailed December 22, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall ZB7.
22V766000 · Seat Belts:pretensioner
Oct 13, 2022
Chrysler (FCA US, LLC) is recalling certain 2022 Ram 1500, Jeep Gladiator, and 2021 Jeep Wrangler vehicles. The front seat belt retractors may have an improperly welded micro gas generator, which can result in seat belt pretensioner failure.
Consequence & remedy
Consequence: A seat belt with pretensioner failure may not properly restrain an occupant during a crash, increasing the risk of injury.
Remedy: Dealers will replace the front seat belt retractors. free of charge. Owner notification letters were mailed December 8, 2022. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is Z95.
22V767000 · Engine; Fuel System, Gasoline:delivery:fuel Pump
Oct 13, 2022
Chrysler (FCA US, LLC) is recalling certain 2020-2022 Jeep Wrangler, Ram 1500, and 2021-2022 Jeep Gladiator vehicles equipped with 3.0L diesel engines. The high pressure fuel pump (HPFP) may fail, causing an engine stall.
Consequence & remedy
Consequence: An engine stall can increase the risk of a crash.
Remedy: Dealers will replace the HPFP and inspect and replace additional fuel system components, as necessary, free of charge. Owner notification letters were mailed October 17, 2023. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is Z96.
Additional source detail variants (2)
Engine
Chrysler (FCA US, LLC) is recalling certain 2020-2022 Jeep Wrangler, Ram 1500, and 2021-2022 Jeep Gladiator vehicles equipped with 3.0L diesel engines. The high pressure fuel pump (HPFP) may fail, causing an engine stall.
Consequence: An engine stall can increase the risk of a crash.
Remedy: Dealers will replace the HPFP and inspect and replace additional fuel system components, as necessary, free of charge. Owner notification letters were mailed October 17, 2023. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is Z96.
Fuel System, Gasoline:delivery:fuel Pump
Chrysler (FCA US, LLC) is recalling certain 2020-2022 Jeep Wrangler, Ram 1500, and 2021-2022 Jeep Gladiator vehicles equipped with 3.0L diesel engines. The high pressure fuel pump (HPFP) may fail, causing an engine stall.
Consequence: An engine stall can increase the risk of a crash.
Remedy: Dealers will replace the HPFP and inspect and replace additional fuel system components, as necessary, free of charge. Owner notification letters were mailed October 17, 2023. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is Z96.
22V638000 · Back Over Prevention:display Function
Aug 25, 2022
Chrysler (FCA US, LLC) is recalling certain 2020-2021 Jeep Wrangler, RAM 1500 and 2021 Jeep Gladiator vehicles. A radio software error may prevent the rearview image from displaying. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: A rearview camera that does not display an image reduces the driver's rear view, increasing the risk of a crash.
Remedy: Dealers will update the radio software, free of charge. Owner notification letters were mailed October 6, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA, LLC's number for this recall is Z86.
21V028000 · Power Train:clutch Assembly
Jan 28, 2021
Chrysler (FCA US, LLC) is recalling certain 2018-2021 Jeep Wrangler and 2020-2021 Jeep Gladiator vehicles equipped with manual transmissions. The clutch pressure plate may overheat and fracture.
Consequence & remedy
Consequence: Overheated clutch components may increase the risk of a fire. Additionally, damage to other nearby components can result in debris falling onto the road or a loss of drive, increasing the risk of a crash.
Remedy: FCA US LLC will notify owners, and dealers will add software to reduce engine torque capability when clutch assembly temperatures rise to a level that may damage the inner pressure plate, free of charge." FCA has ordered a stop sale for the affected vehicles as of February 25, 2021. Owner notification letters were mailed on March 4, 2021.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE24024 · Underhood Fires
Opened Sep 6, 2024 · No close date supplied
Status: open (inferred from source dates) · Steering:hydraulic Power Assist:pump
The Office of Defects Investigation (ODI) has received 9 Vehicle Owner's Questionnaire (VOQ) reports, 1 Death and Injury report, and multiple field reports alleging incidents of engine compartment fires in model year (MY) 2021-2023 Jeep Wrangler and Gladiator vehicles. The majority of the reports describe a fire occurring while the ignition in the vehicle was in an ‘OFF’ state with a suspected origin at the passenger front side of the engine compartment. An ignition ‘OFF’ vehicle fire can result in an increased risk of occupant injury, injury to persons outside the vehicle, and property damage, with little to no warning. ODI has contacted the vehicle manufacturer, Fiat Chrysler Automobiles (FCA), and learned of several thermal events originating at the power steering pump electrical connector in recent model year Jeep Wrangler and Gladiator vehicles. The location of the pump connector is located at the passenger front side of the engine compartment, coinciding with the majority of fire reports known to ODI. ODI is opening this Preliminary Evaluation (PE) to assess the cause, scope, and frequency of the alleged defect. To review the ODI reports cited in the Opening Resume ODI Report Identification Numbers document, go to NHTSA.gov.
RQ24012 · Loss Of Motive Power
Opened Jul 5, 2024 · No close date supplied
Status: open (inferred from source dates) · Electrical System; Engine
The Office of Defects Investigation (ODI) has identified 68 Vehicle Owner Questionnaire (VOQ) reports for model years (MY) 2021 through 2024 Jeep Wrangler 4xe vehicles alleging a loss of motive power. Recall 22V-865 was issued by the manufacturer to address an engine shutdown condition in certain MY 2021-2023 Wrangler 4xe vehicles. The complaints noted here contain both post recall remedy failures and failures in vehicles not included within the scope of 22V-865. An analysis comparing complaints received before the issuance of recall 22V-865 and complaints outside the scope of the recall has been conducted. The results show the current complaint rate is higher in the out of scope vehicles than it was for vehicles that were later covered by the recall. ODI is opening this Recall Query (RQ) to assess the severity of the alleged defect in vehicles not included in recall 22V-865.ODI will also assess the scope and remedy effectiveness of the recall. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Electrical System
The Office of Defects Investigation (ODI) has identified 68 Vehicle Owner Questionnaire (VOQ) reports for model years (MY) 2021 through 2024 Jeep Wrangler 4xe vehicles alleging a loss of motive power. Recall 22V-865 was issued by the manufacturer to address an engine shutdown condition in certain MY 2021-2023 Wrangler 4xe vehicles. The complaints noted here contain both post recall remedy failures and failures in vehicles not included within the scope of 22V-865. An analysis comparing complaints received before the issuance of recall 22V-865 and complaints outside the scope of the recall has been conducted. The results show the current complaint rate is higher in the out of scope vehicles than it was for vehicles that were later covered by the recall. ODI is opening this Recall Query (RQ) to assess the severity of the alleged defect in vehicles not included in recall 22V-865.ODI will also assess the scope and remedy effectiveness of the recall. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
The Office of Defects Investigation (ODI) has identified 68 Vehicle Owner Questionnaire (VOQ) reports for model years (MY) 2021 through 2024 Jeep Wrangler 4xe vehicles alleging a loss of motive power. Recall 22V-865 was issued by the manufacturer to address an engine shutdown condition in certain MY 2021-2023 Wrangler 4xe vehicles. The complaints noted here contain both post recall remedy failures and failures in vehicles not included within the scope of 22V-865. An analysis comparing complaints received before the issuance of recall 22V-865 and complaints outside the scope of the recall has been conducted. The results show the current complaint rate is higher in the out of scope vehicles than it was for vehicles that were later covered by the recall. ODI is opening this Recall Query (RQ) to assess the severity of the alleged defect in vehicles not included in recall 22V-865.ODI will also assess the scope and remedy effectiveness of the recall. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
EA23001 · High Pressure Fuel Pump Failure
Opened Mar 17, 2023 · No close date supplied
Status: open (inferred from source dates) · Fuel System, Diesel:delivery:fuel Pump
The Office of Defects Investigation (ODI) opened PE21-021 on October 14, 2021, to investigate incidents alleging a stall/loss of motive power as a result of high-pressure fuel pump failures in certain model year (MY) 2019-2020 Ram 2500, 3500, 4500, and 5500 heavy duty trucks equipped with 6.7L Cummins turbodiesel engines. During the investigation, ODI sought to determine if the related defect allegation was limited in scope to the recalled population. After review of information request response materials from both FCA and BMW, NHTSA determined that sufficient information to identify a comprehensive recall population could not be produced by FCA and BMW.During the investigation FCA filed recalls 22V406, 22E048, 22V767, and 22E087 which include vehicles not identified in the initial subject population by ODI. ODI also received recall 21V586, involving loss of motive power due to failed CP4 fuel pumps on certain BMW manufactured vehicles. An information request letter response received from BMW indicated that failed pumps on their vehicles were caused by an interaction between pump internal components and US market diesel fuel, leading to increased slip and eventual particle-generating wear surface. Additional work will be done to identify whether a similar root cause is associated with the FCA recalled population and if similar wear dynamics occur on pumps supplied to vehicle manufacturers other than those included in the recalled population.ODI has upgraded this investigation to an EA in order to 1) determine engineering specifications of internal pump components that are correlated with pump failure leading to loss of motive power or other safety related hazards, 2) identify vehicle populations equipped with alleged defective pump variants, 3) assess if vehicles equipped with alleged defective pump variants result in an unreasonable risk to motor vehicle safety and 4) gather and review any other relevant information related to high pressure fuel pump failure associated with the subject populations of recalls 21V586, 21V880, 21E094, 22V406, 22E048, 22V767, and 22E087.Review of the above information will allow NHTSA to confirm root cause and recall remedy viability, and identify and evaluate vehicle populations equipped with pump components that may pose an unreasonable risk to motor vehicle safety.The ODI reports cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID using the following complaint identification numbers: 11257550, 11351441, 11361603, 11361616, 11365300, 11365426, 11365858, 11366401, 11372337, 11373793, 11374797, 11376793, 11377871, 11378173, 11384377, 11386063, 11387018, 11399710, 11402550, 11415339, 11418868, 11418870, 11427075, 11434276, 11436807, 11437226, 11437249, 11437273, 11437292, 11437294, 11437394, 11437399, 11437403, 11437405, 11437423, 11437528, 11437565, 11437579, 11437580, 11437590, 11437679, 11437744, 11437781, 11437842, 11437993, 11438006, 11438008, 11438121, 11438138, 11438155, 11438392, 11438629, 11439359, 11439879, 11440397, 11443030, 11446542, 11448163, 11453556, 11458918, 11460558, 11469337