2021 Jeep Wrangler

The high-pressure fuel pump (HPFP) failed internally while I was driving at night, causing the vehicle to suddenly stall and shut off completely while my children were in the vehicle. This resulted in an immediate loss of power and created a dangerous situation in traffic. The failure caused metal debris to spread throughout the entire fuel system, and the dealership confirmed that the system requires full replacement. I was quoted approximately $15,000 for repairs. This vehicle previously had a manufacturer recall related to the fuel pump that was completed in 2022 and is now listed as closed. Despite the recall repair, the same failure occurred again. This demonstrates that the recall remedy did not correct the defect. The sudden engine shutdown without warning presents a serious safety hazard, especially at night and with passengers in the vehicle. Its been at the dealer ship for a month.

The contact owns a 2021 Jeep Wrangler. The contact received notification of NHTSA Campaign Number: 25V741000 (Electrical System); however, the part to do the recall repair was not yet available. The contact stated that the vehicle was taken to a local dealer, where an engine oil replacement was performed, and the High-Voltage Battery was replaced. Upon further inspection, the local dealer diagnosed the High-Voltage Battery replacement as a failure. In addition, the contact stated that the vehicle remained at the local dealer for several months; however, the parts were not available for the recall repair. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 45,000.

While driving on roads I would characterize as good, Our 2021 Jeep Wrangle has exhibited what is widely know as the "death wobble". 1st time was when vehicle has approximately 10,000 miles and it was noted as being severe, dangerous and very scary. 2nd and 3rd time time and with the same road conditions, it occurred. Mileage was 20,000 and 21,000. On March 13th, and with 23,702 miles, we serviced the vehicle to address a known issue with water pump coolant leak and I explained the front wheel steering "wobble issue". They reviewed, test drove and found no issues with it. 3 miles after picking up vehicle, and at approximate 50 MPH, the unit went into a major wobble condition. I immediately returned to the dealership. Technician recommended steering stabilizer and I was told 9/10 times this fixes the "shake". Service team also explained this is a fairly widespread concern with Jeep Wrangler. I consider this a major risk to me, my family and other drivers around me/vehicle. Only my wife and I have experienced the condition. Dealer was unable to duplicate. No other warning lights or fail conditions are available. On YouTUBE, search Jeep Death Wobble and you will be able to see and witness the condition. Its spot-on. Links below. [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My 2021 Jeep Wrangler Rubicon (3.6L eTorque, automatic transmission) has had recurring drivetrain instability since about 2,000 miles while under factory warranty. It intermittently has high RPM flare during acceleration, delayed shifting, shuddering under load, and abrupt engagement. At low speeds (about 10–5 mph), it harshly downshifts, grabs suddenly, RPMs jump up and down, and it can feel like it will stall; it has stalled intermittently. Braking feels inconsistent, and at times it feels like the vehicle resists braking or surges before slowing. The forward collision warning/automatic emergency braking has activated with no obstacle present, and the power steering assist has been lost intermittently. There is also an engine tick and a high-pitched whining noise from the engine/drivetrain area. In January 2026, the transmission catastrophically failed and required replacement of the transmission, torque converter, cooler, and control module. The vehicle was out of service for over 24 days. After installation of a new Mopar remanufactured transmission and torque converter, the same symptoms returned. AAMCO has now found that the new torque converter failed, with metal shavings throughout the transmission, in the fluid, and at the bottom of the pan. I was advised that the vehicle should be sent to a Jeep dealership because no codes are currently present. I was also advised that the dealership may replace only the torque converter rather than the entire transmission, despite recurring failure and metal contamination. This presents a safety concern due to loss of acceleration, unpredictable torque engagement, stalling, unintended braking activation, power steering loss, engine/drivetrain noise, and repeated drivetrain failure. I have all the records if requested, file is too large to send in the upload area.

My vehicle is experiencing EV system failures, stalling, and system shutdown warnings that make the vehicle unsafe to operate. These symptoms began after a recall repair that was performed by the dealership. The dealership initially stated the recall was repaired, but the same symptoms have continued and have now worsened. The vehicle will display EV system warnings and will stall or shut down systems while driving. The air conditioning and other systems also shut down as the vehicle attempts to protect the electrical system. I have brought the vehicle back to the dealership multiple times regarding this issue. Despite the vehicle showing the same symptoms associated with the recall, I am now being told I may have to pay for additional teardown work unrelated to the EV system. This vehicle has become unsafe to drive, and I have requested assistance and escalation from dealership management but have not received a resolution. I am filing this complaint due to the safety risk posed by the vehicle stalling and shutting down systems while in operation.

Glendale Dodge (CA) is actively using Federal Fire Risk Recall 68C to fraudulently conceal a separate, critical High-Voltage hardware failure on my 2021 Jeep Wrangler 4xe. Upon intake, my vehicle’s internal VIP diagnostic scan showed an active P0E15 code (Electric Coolant Heater Failure). Per Stellantis Technical Service Bulletins, this code indicates a severe failure requiring a physical hardware replacement to ensure the high-voltage system operates safely. To avoid performing this costly warranty repair, the dealership deliberately falsified the diagnosis on Final Invoice #31349. Under Line C (Customer States Check Engine Light is On), the dealership officially recorded the cause and correction as: 'DUE TO RECALL MODULE UPDATES AND BAD BATTERY.' This is an affirmatively false written diagnosis. A dead 12V battery and a recall software update do not cause, nor do they resolve, a P0E15 High-Voltage Electric Coolant Heater failure. The dealership lied on the legal invoice to scrub the hardware defect from the record. They then applied the 68C software patch as a smokescreen, falsified the 'Date Out' to 12/26/2025 to prematurely close the federal recall ticket, and attempted to return a vehicle that remains mechanically compromised and unsafe. This is intentional warranty fraud masking a high-voltage system failure. Stellantis and its authorized repair facility are refusing to properly remedy the vehicle. The vehicle is currently held at the dealership pending an active fraud investigation by the California Bureau of Automotive Repair (Case #6596-WS4PV6).

Vehicle stalled out. Then would not start. Daughter was stuck for 30 minutes until it finally turned over took it into dealership. Was told it’s the fuel pump. My issue is that now. These fuel pumps are back ordered indefinitely found out because all of the fuel pumps are going bad on the jeeps. Now we have a faulty part that the dealership is aware of that you cannot get replaced due to so many of them needing to be replaced, which tells me they know this part is faulty was told they’re not even sure if or when they would be able to get the part now you have all these people driving jeeps that can stall out on the road and get into a terrible accident. My daughter is [XXX] and this is not acceptable. She has a faulty car part and Jeep has no parts to replace this faulty part. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I own a 2021 Jeep Wrangler Rubicon 392 with the 6.4L engine (VIN: [XXX] ). The vehicle has a dangerous condition where the engine stalls unexpectedly when the fuel level is approximately 1/4 tank or lower and the vehicle is traveling downhill. When the vehicle is positioned on a decline or downhill slope, the engine suddenly shuts off without warning. This appears to be fuel starvation on decline when the fuel level is below approximately 1/4 tank, resulting in engine stall and loss of power steering and braking assist after stall. This has occurred multiple times and creates a significant risk of crash due to the sudden loss of engine power and reduced steering and braking assistance while the vehicle is in motion. The issue is particularly concerning when descending hills or driving on angled terrain. The vehicle was taken to an authorized dealership (Carvana Jeep San Diego) where technicians determined the likely cause is a defective fuel pump module associated with the Wrangler Rubicon 392 6.4L fuel pump module. However, the dealership informed me the replacement fuel pump module is currently on national backorder from the manufacturer (Stellantis/Jeep). They stated there is no confirmed availability date and that many vehicles may be waiting for the same component. My vehicle has been awaiting repair for approximately four months due to the unavailable fuel pump module. Because the vehicle can stall unexpectedly while traveling downhill, this defect presents an ongoing safety hazard and potential risk of crash. This complaint is being submitted so the issue can be evaluated as a potential safety defect involving fuel delivery failure, fuel pump module malfunction, and engine stall under low fuel conditions in the Jeep Wrangler Rubicon 392. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

While driving higher speeds (45 mph+) I have had my vehicle start shaking very violently which results in me having to slam on my breaks to gain control of my vehicle. When this happens I have been traveling on the highway or interstate which puts other drivers at risk due to me unexpectedly having to come to a halt to gain control of my vehicle. I have taken my vehicle to the mechanic multiple times (dealership twice and local mechanic twice) and I have had everything replaced on the front end that could cause this and it is still happening. Steering dampener has been replaced twice in a year. Mechanic seems to believe that there is a design flaw in the vehicle that is causing it at this point. There is no warning message or anything that gives me any warning. I am scared to drive my vehicle on the highway or interstate.

The contact owns a 2021 Jeep Wrangler. The contact stated that while driving approximately 55 MPH, the vehicle drove over a bump in the road, and the vehicle started to wobble and shake violently. The contact slowed down and stopped the vehicle. The contact stated there was no warning light illuminated. The vehicle was taken to a local dealer, where it was diagnosed, and determined that the steering dampener needed to be replaced. The vehicle was not repaired. The contact stated had experienced the failure several years prior. The vehicle was repaired under warranty; however, the vehicle was no longer under warranty. The manufacturer was informed of the failure. The failure mileage was approximately 51,000.