Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
140–25K
1325–50K
1850–75K
1775–100K
26100–150K
15150K+
103 reports with mileage · 67 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Structure. Review the 38 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 37 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 23 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
17 crash reports16 fire reports16 injury reports
What owners actually said
170 reports
181,000 miles · May 3, 2018
Electronic Stability Control (esc)SteeringInjury
DEFINITELY HAD A BAD EXPERIENCE WITH THE DEATH WOBBLE IN MY JEEP ALMOST CAUSING ME TO BE IN A CAR ACCIDENT. I FEEL THE PAIN IN BACK AND NECK. WILL HAVE TO GO TO DOCTORS TO GET THAT CHECKED. I WAS DRIVING ON INTERSTATE 83 WHEN I HIT A BUMP ON THE ROAD NEAR CONSTRUCTION AREA WHEN JEEP BEGAN TO WOBBLE OUT OF CONTROL. LUCKILY ANOTH…
Read full complaint
DEFINITELY HAD A BAD EXPERIENCE WITH THE DEATH WOBBLE IN MY JEEP ALMOST CAUSING ME TO BE IN A CAR ACCIDENT. I FEEL THE PAIN IN BACK AND NECK. WILL HAVE TO GO TO DOCTORS TO GET THAT CHECKED. I WAS DRIVING ON INTERSTATE 83 WHEN I HIT A BUMP ON THE ROAD NEAR CONSTRUCTION AREA WHEN JEEP BEGAN TO WOBBLE OUT OF CONTROL. LUCKILY ANOTHER JEEP ON THE ROAD SAW WHAT WAS GOING ON AND MADE SPACE FOR ME TO EXIT THE HIGHWAY. I CALLED THE TOW TRUCK AND HAD IT TOWED. *DSY
NHTSA ODI #11091605
5 miles · Apr 26, 2018
Structure
ENTIRE FRAME IS RUSTED CAUSING THE TRANSMISSION TO FALL OUT. ALMOST MADE MY SON CRASH INTO A TREE AFTER LOSING CONTROL OF THE VEHICLE.
NHTSA ODI #11090323
174,000 miles · Apr 15, 2018
Unknown Or Other
FRAME ROTTING FROM INSIDE OUT.THIS IS A SEVERE SAFETY CONCERN.THIS IS A PROBLEM RELATED TO CERTAIN YEARS OF WRANGLERS. THE SEVERITY OF THE PROBLEM SHOULD RESULT IN A RECALL AS HAS BEEN WITH OTHER MANUFACTURERS WITH SAME PROBLEM TO RESOLVE THIS VERY UNSAFE CONDITION.
NHTSA ODI #11085152
139,000 miles · Dec 20, 2017
Air BagsElectrical System
TL-CONTACT OWNS A 2001 JEEP WRANGLER--- SPOKE WITH CHRYSLER --- CHRSYLER STATED NO RECALLS ON VEHICLE---HORN IN VEHICLE DOES NOT WORK AT ALL AND AIRBAG LIGHT IS ON... CONTACT WAS GIVEN NUMBER TO JEEP REGARDING AIR BAG LIGHT....0 RECALLS ASSOCIATED WITH THIS VIN
NHTSA ODI #11055688
Mileage unknown · Dec 19, 2017
SuspensionCrash
FRAME RUSTING FROM INSIDE REAR CONTROL ARM FELL OFF CAUSING WRECK
NHTSA ODI #11055526
90,000 miles · Nov 17, 2017
Structure
FRAME IS COMPLETELY RUSTED ONLY 90K MILES. THE TRANSMISSION DROPPED BECAUSE THE STRUCTURE HOLDING IT UP WAS BOLTED TO THE FRAME AND BECAUSE THE ENTIRE FRAME IS COMPLETELY RUSTED IT CANT BE FIXED. ITS SO BAD A NO BODY SHOP WILL FIX IT, RUST KIT IS NO HELP WITH HOW BAD THIS FRAME IS RUSTED. THIS IS COMPLETELY RIDICULES THAT A FRAM…
Read full complaint
FRAME IS COMPLETELY RUSTED ONLY 90K MILES. THE TRANSMISSION DROPPED BECAUSE THE STRUCTURE HOLDING IT UP WAS BOLTED TO THE FRAME AND BECAUSE THE ENTIRE FRAME IS COMPLETELY RUSTED IT CANT BE FIXED. ITS SO BAD A NO BODY SHOP WILL FIX IT, RUST KIT IS NO HELP WITH HOW BAD THIS FRAME IS RUSTED. THIS IS COMPLETELY RIDICULES THAT A FRAME IS THIS BADLY RUSTED AT 90K MILES.
NHTSA ODI #11046953
117,803 miles · Aug 24, 2017
Electrical SystemFire
I WAS DRIVING WITH THE AIR CONDITIONER ON WHEN I SMELLED BURNING PLASTIC, THEN SMOKE CAME OUT OF THE AIR VENTS. I PULLED OVER AND TURNED OFF THE AIR CONDITIONER AND GOT OUT OF THE VEHICLE. AFTER ABOUT 15 MIN THE SMELL DISSIPATED AND I CONTINUED ON WITHOUT THE AIR CONDITIONING. LATER I REMOVED THE COVERS AND FOUND THAT THERE…
Read full complaint
I WAS DRIVING WITH THE AIR CONDITIONER ON WHEN I SMELLED BURNING PLASTIC, THEN SMOKE CAME OUT OF THE AIR VENTS. I PULLED OVER AND TURNED OFF THE AIR CONDITIONER AND GOT OUT OF THE VEHICLE. AFTER ABOUT 15 MIN THE SMELL DISSIPATED AND I CONTINUED ON WITHOUT THE AIR CONDITIONING. LATER I REMOVED THE COVERS AND FOUND THAT THERE HAD BEEN A FIRE IN THE PLUG THAT GOES TO THE BLOWER MOTOR RESISTOR
NHTSA ODI #11019377
123,406 miles · Apr 26, 2017
Fuel/propulsion System
FUEL LEAKS FROM UNDER TANK AFTER FILLING UP WITH GAS AT GAS STATION
NHTSA ODI #10980979
116,000 miles · Apr 21, 2017
StructureUnknown Or Other
THIS 2001 JEEP WRANGLER TJ FAILED NY STATE SAFETY INSPECTION DUE TO FRAME RUST. PURCHASED NEW ON 06/01/2001 FROM A JEEP DEALERSHIP IN LINDENHURST, NY AND ONLY HAS 116,097 MILES ON A 4.0 ENGINE. THIS TUBULAR FRAME RUST IS PREMATURE DUE TO LACK OF "WEEP HOLES" THAT ALLOWS WATER TO EXIT THE FRAME, THEREBY PROMOTING RUST FROM THE IN…
Read full complaint
THIS 2001 JEEP WRANGLER TJ FAILED NY STATE SAFETY INSPECTION DUE TO FRAME RUST. PURCHASED NEW ON 06/01/2001 FROM A JEEP DEALERSHIP IN LINDENHURST, NY AND ONLY HAS 116,097 MILES ON A 4.0 ENGINE. THIS TUBULAR FRAME RUST IS PREMATURE DUE TO LACK OF "WEEP HOLES" THAT ALLOWS WATER TO EXIT THE FRAME, THEREBY PROMOTING RUST FROM THE INSIDE, OUT AND IS COSTLY TO REPAIR (SEE ATTACHMENT). NOTE... TOYOTA HAS HAD SIMILAR "RUSTY FRAME" ISSUES, BUT TOYOTA HAS DONE THE "RIGHT THING". SEE WRITE-UP AND VIDEO HERE: HTTP://AUTOWEEK.COM/ARTICLE/RECALLS/TOYOTA-FRAME-SETTLEMENT-COULD-COST-COMPANY-34-BILLION ... I LOVE MY WRANGLER, BUT IF JEEP REFUSES TO HELP WITH THIS (WIDE SPREAD) RUSTY FRAME ISSUE, I MAY VERY WELL MAKE A TOYOTA MY NEXT PURCHASE! THIS IS NOT JUST A CUSTOMER SERVICE ISSUE, THIS IS A BIG SAFETY ISSUE!!!
NHTSA ODI #10979803
175,000 miles · Apr 19, 2017
StructureSuspension
COMPLETE CORROSION THROUGH THE FRAME JUST BEHIND THE REAR UPPER AND LOWER TRAILING ARMS MOUNT LOCATIONS. TWO LARGE HOLES APPROXIMATELY 1" IN DIAMETER. STRESS CONCENTRATIONS DUE TO CORRODED METAL AND CYCLICAL FATIGUE HAS CAUSED CRACK PROPAGATION AND CONNECTION OF THE TWO HOLES WITH ONE ANOTHER.
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH A 4.0L ENGINE ONLY, THE DESIGN OF THE INTAKE AND EXHAUST MANIFOLDS COULD ALLOW DEBRIS TO ACCUMULATE AT THE #3 CYLINDER LOCATION.
Consequence & remedy
Consequence: THIS COULD RESULT IN A VEHICLE FIRE.
Remedy: DEALERS WILL INSTALL A MANIFOLD SHIELD TO MODIFY THE AIR FLOW CHARACTERISTICS AND TO PREVENT THE ACCUMULATION OF DEBRIS IN THE AREA OF THE #3 CYLINDER. OWNER NOTIFICATION BEGAN MAY 13, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
ON CERTAIN SPORT UTILITY VEHICLES, WATER AND IMPURITIES CAN ENTER INTO THE IGNITION SWITCH, CAUSING A SHORT CIRCUIT.
Consequence & remedy
Consequence: THIS COULD RESULT IN A VEHICLE FIRE.
Remedy: DEALERS WILL REPLACE THE IGNITION SWITCH WITH A REDESIGNED SWITCH. OWNER NOTIFICATION BEGAN APRIL 8, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES, PICKUP TRUCKS AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." SOME OF THE OWNER'S MANUALS FOR THESE VEHICLES ARE MISSING INSTRUCTIONS THAT PROVIDE A STEP-BY-STEP PROCEDURE, INCLUDING DIAGRAMS, FOR PROPERLY ATTACHING A CHILD RESTRAINT SYSTEM'S TETHER STRAP TO THE TETHER ANCHORAGE.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE CHILD SEAT MAY NOT BE PROPERLY ATTACHED INCREASING THE RISK OF INJURY TO THE CHILD.
Remedy: OWNERS WILL BE PROVIDED WITH AN ADDENDUM TO THE OWNER'S MANUALS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration