2001 Jeep Wrangler

There is a known problem with the electrical wiring to the climate control panel including the blower motor fan switch. The wiring attached to the assembly gets too hot and melts the blower motor fan switch. When this happens, you are unable to turn on any heat/ac/air speeds. You are not able to select any speed to turn on the air which means you can’t use it to defrost the windshield. This can lead to a poor visibility situation. I am the original owner of my 2001 TJ and I’ve had to have this problem fixed multiple times. There are several videos & discussions about this problem in Jeep forums. Chrysler should’ve recalled it years ago..

MY JEEP WAS MAKING GRINDING SOUNDS WHEN I SHIFTED GEARS. AT FIRST IT WAS JUST A QUICK GRIND (METAL AGAINST METAL). THEN IT GOT PROGRESSIVELY WORSE AS THIS LAST WEEK WENT BY. IT BECAME ALMOST IMPOSSIBLE TO SHIFT INTO REVERSE AND IT WOULD POP OUT OF GEAR UNEXPECTEDLY WHILE GOING DOWN THE ROAD.LUCKILY I DIDN'T DRIVE IT MUCH. I TOOK IT TO MY MECHANIC AND HE SAID I WAS LUCKY- MY TRANSMISSION(?) WAS TILTED AND SITTING ON SOMETHING AND THAT WAS CAUSING THE NOISE (THE LUCK WAS THAT THE TRANSMISSION DIDN'T FALL ALL THE WAY DOWN). THE DESCRIPTION OF THE PROBLEM FROM PRESTIGE HI-TECH IS "CHECK FOR NOISE/ GRINDING IN DRIVETRAIN. FRAME BADLY RUSTED OUT, CROSS MEMBER UNDER TRANSFER CASE, BOLTS PULLED OUT OF RUSTED FRAME." I WAS THEN TOLD IT WAS UNSAFE TO DRIVE. VISUALLY IT IS IN GREAT CONDITION WITHOUT RUST ON THE BODY. PRESTIGE SAID BOTH SIDES OF THE FRAME ARE RUSTED THROUGH BECAUSE OF POOR DESIGN. THERE WERE NO HOLES FOR TRAPPED WATER TO ESCAPE THROUGH.

TL* THE CONTACT OWNS A 2001 JEEP WRANGLER. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEED, THE AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO JACKSONVILLE CHRYSLER DODGE JEEP RAM ARLINGTON (9600 ATLANTIC BLVD, JACKSONVILLE, FL 32225) WHERE IT WAS DIAGNOSED THAT THE PASSENGER AIR BAG NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED HOWEVER, YEARS LATER THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 56,468.

FRAME BEGAN ROTTING OUT AT ROUGHLY 100,000 MILES. I DISCOVERED THIS WHILE DRIVING DOWN THE HIGHWAY ON MY COMMUTE HOME FROM WORK. WHILE ACCELERATING I FELT A SUDDEN POWER LOSS. THIS WENT ON FOR ANOTHER ROUNDTRIP THE FOLLOWING DAY. UPON RETURNING HOME THE FOLLOWING DAY I SAW SOMETHING HANGING FROM UNDERNEATH THE VEHICLE. IT WAS THE SKID PLATE, HANGING BY THE PASSENGER'S SIDE BOLTS, SUPPORTING THE ENTIRE WEIGHT OF THE DRIVETRAIN. THE DRIVESHAFT BEING AT THAT UNNATURAL ANGLE IS WHAT CAUSED THE LOSS OF POWER. TO THINK THAT I HAD DRIVEN 100 MILES THAT WAY WAS SLIGHTLY UNSETTLING. SINCE THEN I HAVE HAD THE FRAME WELDED, WHICH RAN $1,200. I HAVE SINCE HAD THE REAR RAILS (BEHIND REAR WHEELS) REPAIRED FOR AN ADDITIONAL $400. MY FRONT BODY MOUNT HAS ALSO ROTTED OUT, WHICH I FIXED MYSELF FOR $10, BUT SHOULD PROBABLY BE WELDED BY A PROFESSIONAL. BOTH MECHANIC AND WELDER SUGGESTED THAT FRAME ROT OCCURRED DUE TO LACK OF HOLES FOR WATER TO DRAIN OUT AND THAT THE SITTING WATER AND SALT JUST ATE AWAY AT EVERYTHING. THE CAR NOW HAS 215,000 MILES ON IT. I AM OTHERWISE HAPPY WITH THE CAR, BUT IT UPSETS ME THAT I COULD HAVE HAD A MAJOR ACCIDENT DUE TO THE POOR DESIGN OF THE FRAME. SEEMS STRANGE THAT THERE HAS NOT BEEN A FIX FOR THE ISSUE, NOR A RESPONSE FROM CHRYSLER TO ADDRESS THE FACT THAT PEOPLE CAN DIE AS A RESULT OF THE FRAME ROTTING OUT. MAYBE THAT'S WHAT HAS TO HAPPEN FOR A FIX?!? AT 200,000+ MILES YOU WOULD THINK I WOULD GO STRAIGHT BACK TO A WRANGLER ONCE THIS ONE BITES IT, BUT I WILL NEVER BUY A JEEP AGAIN BASED ON THIS ISSUE. I BOUGHT THIS AS A 25 YEAR OLD WITHOUT KIDS. WITH A 2 AND 4 YEAR OLD AT HOME, I WOULD NOT TRUST A JEEP TO TRANSPORT THEM (TOO BAD, AS MY SON LOVES MY JEEP DESPITE NEVER BEING IN IT). I LIVE IN THE NORTHEAST, SO RUST/ROT EXPECTED TO AN EXTENT. MY BROTHER OWNS A FORD F-250 USED FOR PLOWING..SAME YEAR, SAME MILAGE...NO ROT!

TL* THE CONTACT OWNS A 2001 JEEP WRANGLER. UPON INSPECTING THE VEHICLE, THE CONTACT NOTICED THAT THE FRAME OF THE VEHICLE WAS COMPLETELY RUSTED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO CONFIRMED THAT THE VEHICLE'S FRAME WAS RUSTED. THE DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER INFORMED THE CONTACT THAT THE FRAME WAS NO LONGER BEING MANUFACTURED. THE FAILURE MILEAGE WAS 107,000.

MY JEEP FRAME RUSTED OUT, FORCING US TO PURCHASE A NEW VEHICLE IN 2015. I AM THE ORIGINAL OWNER, FEMALE, NEVER WENT OFF-ROAD WITH IT AND IT WAS GARAGE KEPT. LESS THAN 90,000 MILES ON IT TODAY. UPSET THAT I CANNOT DRIVE IT BECAUSE OF THE FRAME AND CANNOT FIND FRAME TO REPLACE IT. I STILL OWN IT AND STILL WAITING TO FIND A FRAME FOR IT. NOW SITTING IN MY DRIVEWAY. EXCELLENT CONDITION, EXCEPT FOR THE FRAME! SEE PHOTO AS PROOF.