IllustrationAC LINE RUBBING AGAINST FENDER. IT FINALLY BROKE DOWN THE LINE CAUSING IT TO LEAK WITH EXTREME PRESSURE. REPLACE LINE AND MADE A BRACKET TO HOLD LINE AWAY FROM FENDER. *JB
1993 Jeep Wrangler
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1993 Jeep Wrangler do not stand out strongly from the model-year median of 265.
About this comparison →How this year compares
Owner complaints by model year
Compare all Wrangler years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 12 of 108 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel System, Gasoline. Review the 23 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 18 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Parking Brake. Review the 13 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
8 crash reports4 fire reports1 injury reports
Engine And Engine Cooling complaints
18 reportsTHE CATALYTIC CONVERTER WAS REPLACED ON A NHTSA RECALL. HOWEVER, PROBLEM RECURRED, PER THE DEALER. MANUFACTURED WAS CONTACTED, AND CONSUMER HAS BEEN INFORMED THAT RECALLS WERE A ONE TIME REPAIR AT NO COST. NO RECALLS FOR THE PART MENTIONED. *AK
CATALYTIC CONVERTER FAILED AND HAD TO BE REPLACED AT 41,000 MILES. *NLM
THE HEAD GASKET FAILED ON THE VEHICLE. *JB
WHILE DRIVING 65 MPH THE VEHICLE WAS ENGULFED IN FLAMES. THE VEHICLE WAS TOTALLED. PLEASE PROVIDE ADDITIONAL INFORMATION.*JB
FUEL VAPOR LINE BECAME DETACHED CAUSING FUEL LEAK IN CLOSE PROXIMITY TO EXHAUST PIPE WHICH CREATED A POTENTIAL FIRE HAZARD. I REPAIRED THIS DEFECT BY USING A CLAMP TO SECURE THE LINE BACK TO FUEL TANK. THERE ARE TWO OF THESE VAPOR LINES THAT ARE ON EACH END OF THE TANK AND THEY ARE NOT SECURED WITH CLAMPS FROM THE FACTORY. WI…
Read full complaint
FUEL VAPOR LINE BECAME DETACHED CAUSING FUEL LEAK IN CLOSE PROXIMITY TO EXHAUST PIPE WHICH CREATED A POTENTIAL FIRE HAZARD. I REPAIRED THIS DEFECT BY USING A CLAMP TO SECURE THE LINE BACK TO FUEL TANK. THERE ARE TWO OF THESE VAPOR LINES THAT ARE ON EACH END OF THE TANK AND THEY ARE NOT SECURED WITH CLAMPS FROM THE FACTORY. WITH THE AGING OF THE RUBBER VAPOR LINE IT CAN BECOME LOSE AND WHEN PRESSURE IN THE FUEL TANK INCREASES IT CAN CAUSE THE ONE OF THE LINES TO POP OFF. THIS RESULTS IN FUEL LEAKING AND CREATES A HAZARDOUS FIRE CONDITION SINCE THE EXHAUST PIPE RUNS NEXT TO THE TANK IN THE REAR OF THE VEHICLE.*AK
CATALYTIC CONVERTER WAS REPLACED IN 01/98 THE EXHAUST SYSTEM BEGAN GETTING NOISY AGAIN IN 99 EVENTUALLY THE MANIFOLD CRACK APPEARED.
ENGINE STARTED TO SOUND LOUDER THAN NORMAL WHEN STARTING UP FROM A COLD START. NOTICED ENGINE WAS COVERED IN OIL. WHEN I TOOK IT TO BE REPAIRED, THE MECHANIC TOLD ME THAT THE MANIFOLD EXHAUST BOLT HAD FAILED AND THAT CAUSED MY PROBLEM. HAD IT REPAIRED FOR $300.00. THEN I FOUND OUT ABOUT THE "TECHNICAL SERVICE BULLETIN" FROM A …
Read full complaint
ENGINE STARTED TO SOUND LOUDER THAN NORMAL WHEN STARTING UP FROM A COLD START. NOTICED ENGINE WAS COVERED IN OIL. WHEN I TOOK IT TO BE REPAIRED, THE MECHANIC TOLD ME THAT THE MANIFOLD EXHAUST BOLT HAD FAILED AND THAT CAUSED MY PROBLEM. HAD IT REPAIRED FOR $300.00. THEN I FOUND OUT ABOUT THE "TECHNICAL SERVICE BULLETIN" FROM A JEEP WEBSITE ABOUT THIS PROBLEM.
WITHIN IN THE LAST 2 YEARS, THE COOLING SYSTEM HAS A HAD AN OFF-AND-ON ANTIFREEZE LEAK. PARTS REPLACED INCLUDE THE RADIATOR, BOTH THE UPPER AND LOWER RADIATOR HOSES, THE WATER PUMP, THE THERMOSTAT, AND THE FREEZE PLUG. A LEAK STILL EXISTS, CAUSING ME TO BELIEVE THERE IS A DEFECT SOMEWHERE NOT YET DETERMINED.
COMPLETE ENGINE FAILURE. MJS
Official recalls
302V041000 · Parking Brake:conventional
Feb 7, 2002
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH MANUAL TRANSMISSIONS, THE PARKING BRAKE CAN SELF-RELEASE WITHOUT WARNING.
Consequence & remedy
Consequence: THIS COULD ALLOW THE VEHICLE TO ROLL AWAY, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL A PARKING BRAKE ASSEMBLY WITH A STRONGER PAWL RETURN SPRING. OWNER NOTIFICATON BEGAN SEPTEMBER 30, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
94V106000 · Fuel System, Gasoline:delivery:fuel Pump
Jun 9, 1994
VEHICLE DESCRIPTION: MULTIPURPOSE PASSENGER VEHICLES EQUIPPED WITH PLASTIC FUEL TANKS. THE FUEL TANK SENDING UNIT GASKET CAN CRACK CAUSING FUEL AND FUEL VAPOR LEAKS.
Consequence & remedy
Consequence: FUEL AND FUEL VAPOR LEAKED FROM THE FUEL TANK CAN RESULT IN FIRE WHEN EXPOSED TO A SOURCE OF IGNITION.
Remedy: REPLACE THE FUEL TANK SENDING UNIT GASKET.
93V083000 · Electrical System:ignition:switch
May 11, 1993
SALT CORROSION PRODUCTS BETWEEN THE STARTER SOLENOID WIRE AND THE ADJACENT BATTERY FEED IN THE BULKHEAD CONNECTOR MAY SHORT THESE CONNECTIONS, CAUSING THE CIRCUIT TO BYPASS THE IGNITION KEY CONTROL OF THE STARTER MOTOR SOLENOID. THE CAR CAN START WITHOUT THE STARTER SEQUENCE BEING INITIATED BY THE IGNITION KEY IN THE IGNITION LOCK.
Consequence & remedy
Consequence: THE UNINTENDED START OF A VEHICLE WITH A MANUALTRANSMISSION LEFT IN A DRIVE GEAR CAN RESULT IN A RUNAWAY VEHICLE.
Remedy: THE STARTER SOLENOID WIRING WILL BE SEPARATED FROM THE BATTERY FEED WIRE BY RELOCATING IT WITHIN THE BULKHEAD CONNECTOR ON AFFECTED VEHICLES.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5EA99014 · Brake Roter Disc/hud Separation
Opened Jun 28, 1999 · Closed Mar 28, 2000
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
Additional source detail variants (2)
Service Brakes, Hydraulic
There is no summary currently available
Service Brakes, Hydraulic
There is no summary currently available
RQ97016 · Fuel Leakage
Opened Oct 27, 1997 · Closed Jun 30, 1998
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump
ODI HAS RECEIVED 6 REPORTS ON FUEL LEAKAGE AND 3 REPORTS ON ALLEGED REMEDY FAILURE REPORTS
PE95049 · Rear Axle Shaft Separation
Opened Aug 17, 1995 · Closed Jan 26, 1996
Status: closed (inferred from source dates) · Suspension
THIS INVESTIGATION WAS OPENED TO EXAMINE THE FAILURE MODE AND THE RISK TO MOTOR VEHICLE SAFETY POSED BY ALLEGATIONS OF REAR AXLE SEPARATIONS.THE REAR AXLE SHAFT AND HOUSING DESIGN IS TYPICAL OF THOSE IN WHICH THE WEIGHT OF THE VEHICLE IS CARRIED ON THE AXLE HOUSING.THE LEFT AND RIGHT AXLE SHAFTS, SUPPORTED BY ROLLER BEARINGS, ARE SITUATED INSIDE THE AXLE HOUSING.THE INBOARD SPLINED END OF THE AXLE SHAFT RECEIVES POWER TRANSMITTED FROM THE DIFFERENTIAL ASSEMBLY, PROVIDING TORQUE TO THE REAR WHEELS.THE ALLEGATIONS ARE THAT THE AXLE SHAFT FAILS, RESULTING IN THE SEPARATION OF A WHEEL AND AXLE HUB ASSEMBLY OR THE ENTIRE AXLE SHAFT AND WHEEL ASSEMBLY, DEPENDING ON THE LOCATION OF THE AXLE SHAFT FAILURE.AS IDENTIFIED BY CHRYSLER, THE SUBJECT REAR AXLES ARE DANA 35C AND 35CM MODELS, WHICH HAVE BEEN USED ON THE SUBJECT VEHICLES SINCE THE 1990 MODEL YEAR.A SAFETY DEFECT TREND WITH RESPECT TO THE SUBJECT AXLE SHAFTS HAS NOT BEEN IDENTIFIED.SEE HARD COPY RESUME FOR FULL TEXT OF SUMMARY.
EA93025 · Driveshaft/univ.joint Fail
Opened Oct 29, 1993 · Closed Nov 25, 1994
Status: closed (inferred from source dates) · Power Train
There is no summary currently available
PE93057 · Driveshaft/univ.joint Fail
Opened Jun 14, 1993 · Closed Oct 29, 1993
Status: closed (inferred from source dates) · Power Train
There is no summary currently available