IllustrationVEHICLE HAS BEEN REPAIRED 4 TIMES FOR RECALL 94V106000/ FUEL PUMP. DEALERS SIMPLY SAID THAT IT WAS CONSUMER'S PROBLEM TO REPAIR IT. SEAL IS LEAKING & THEY HAVE NO IDEA WHY IT KEEPS HAPPENING.*AK
1992 Jeep Wrangler
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1992 Jeep Wrangler do not stand out strongly from the model-year median of 265.
About this comparison →How this year compares
Owner complaints by model year
Compare all Wrangler years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 11 of 77 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel System, Gasoline. Review the 22 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 11 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Seat Belts. Review the 9 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
5 crash reports2 fire reports2 injury reports
Fuel System, Gasoline complaints
22 reportsFUEL TANK IS PLASTIC WHICH HAS COLLAPSED INWARD, IMPACTING FUEL SENDING UNIT AND FUEL PUMP. THIS MODLE VEHICLE HAS A RECALL ITEM # 624 FOR FUEL TANK GASKET DUE TO FUEL LEAKS, BUT DOES NOT RESOLVE TANK FAILURE. WITH TANK FAILING (COLLAPSING INWARD) POTENTIAL EXISTS FOR MAJOR FAILURE, FUEL SPILLAGE, FIRE, ETC.
1. TRANSMISSION FAILURES: 2 TRANSMISSION REPLACEMENTS (1997, 1999):: 2. FUEL TANK SENDING UNIT RECALL REPLACEMENT FAILURE :: 3. FUEL LINE LEAKS AT A REAR COUPLING.
CONSUMER COMPLAINED THAT MANUFACTURER'S RECALL REPAIR CONCERNING FUEL PUMP IN WHICH THE FUEL TANK SENDING UNIT GASKET CAN CRACK , CAUSING FUEL AND FUEL VAPOR TO LEAK. FUEL AND FUEL VAPOR LEAKS FROM THE FUEL TANK CAN RESULT IN A FIRE WHEN EXPOSED TO A SOURCE OF IGNITION. DEALER/MANUFACTURER NOTIFIED, AND REFUSED TO REPAIR UNLE…
Read full complaint
CONSUMER COMPLAINED THAT MANUFACTURER'S RECALL REPAIR CONCERNING FUEL PUMP IN WHICH THE FUEL TANK SENDING UNIT GASKET CAN CRACK , CAUSING FUEL AND FUEL VAPOR TO LEAK. FUEL AND FUEL VAPOR LEAKS FROM THE FUEL TANK CAN RESULT IN A FIRE WHEN EXPOSED TO A SOURCE OF IGNITION. DEALER/MANUFACTURER NOTIFIED, AND REFUSED TO REPAIR UNLESS COST GOES TO CONSUMER. *AK
RECALL # 94V10600, CONTACTED DEALER ON NOVEMBER 26, 1996. CONTACTED MANUFACTURER IN JANUARY. CONSUMER IS STILL WAITING FOR PART TO FIX FUEL TANK. *AK
CONSUMERS RECALL REPAIR FOR THE FUEL TANK SENDING UNIT WAS NOT PERFORMED IN A TIMELY MANNER.
AFTER HAVING THE RECALL REPAIR WORK DONE FOR THE FUEL PUMP, CONSUMER IS STILL HAVING PROBLEMS WITH FUEL LEAKING OUT THE FUEL TANK RECALL#94V106000. PLEASE DESCRIBE.*AK
RECALL FOR FUEL TANK SENDING UNIT AND CATALYTIC CONVERTOR ARE NOT BEING SERVICED @ TOLD BY CITY CHRYSLER. WHEN APPOINTMENT ARRIVED PARTS AREN'T AVAILABLE. PLEASE DESCRIBE DETAILS*AK
MFG 624/625 FUEL PUMP; SMITHAVEN DODGE IN NY FAILED TO REPLACE PARTS FOR RECALL, VERIFIED BY A PRIVATE MECHANIC. OWNER HAS OLD PARTS 94V106000. *AK
RECALL 624/625: FUEL TANK SENDING UNIT GASKET ON TOP OF TANK FAILED AFTER REPLACEMENT. PLEASE DESCRIBE DETAILS. TT
Official recalls
402V041000 · Parking Brake:conventional
Feb 7, 2002
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH MANUAL TRANSMISSIONS, THE PARKING BRAKE CAN SELF-RELEASE WITHOUT WARNING.
Consequence & remedy
Consequence: THIS COULD ALLOW THE VEHICLE TO ROLL AWAY, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL A PARKING BRAKE ASSEMBLY WITH A STRONGER PAWL RETURN SPRING. OWNER NOTIFICATON BEGAN SEPTEMBER 30, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
94V106000 · Fuel System, Gasoline:delivery:fuel Pump
Jun 9, 1994
VEHICLE DESCRIPTION: MULTIPURPOSE PASSENGER VEHICLES EQUIPPED WITH PLASTIC FUEL TANKS. THE FUEL TANK SENDING UNIT GASKET CAN CRACK CAUSING FUEL AND FUEL VAPOR LEAKS.
Consequence & remedy
Consequence: FUEL AND FUEL VAPOR LEAKED FROM THE FUEL TANK CAN RESULT IN FIRE WHEN EXPOSED TO A SOURCE OF IGNITION.
Remedy: REPLACE THE FUEL TANK SENDING UNIT GASKET.
93V083000 · Electrical System:ignition:switch
May 11, 1993
SALT CORROSION PRODUCTS BETWEEN THE STARTER SOLENOID WIRE AND THE ADJACENT BATTERY FEED IN THE BULKHEAD CONNECTOR MAY SHORT THESE CONNECTIONS, CAUSING THE CIRCUIT TO BYPASS THE IGNITION KEY CONTROL OF THE STARTER MOTOR SOLENOID. THE CAR CAN START WITHOUT THE STARTER SEQUENCE BEING INITIATED BY THE IGNITION KEY IN THE IGNITION LOCK.
Consequence & remedy
Consequence: THE UNINTENDED START OF A VEHICLE WITH A MANUALTRANSMISSION LEFT IN A DRIVE GEAR CAN RESULT IN A RUNAWAY VEHICLE.
Remedy: THE STARTER SOLENOID WIRING WILL BE SEPARATED FROM THE BATTERY FEED WIRE BY RELOCATING IT WITHIN THE BULKHEAD CONNECTOR ON AFFECTED VEHICLES.
92V148000 · Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
Oct 14, 1992
ON 1987 THROUGH EARLY 1990 MODELS, BOTH FRONT BRAKE HOSES CAN WEAR DUE TO DIRECT CONTACT WITH THE WHEEL OPENING SPLASH SHIELDS. ON THE LATE 1990 THROUGH 1992 MODELS, PERIODIC RUBBING CONTACT OF THE LEFT FRONT BRAKE HOSE CAN OCCUR DUE TO MOVEMENT OF THE SPLASH SHIELD IN CERTAIN VEHICLE OPERATING CONDITIONS.
Consequence & remedy
Consequence: EITHER CONDITION CAN CAUSE LOSS OF FRONT BRAKE SYSTEMFUNCTIONS, RESULTING IN INCREASED STOPPING DISTANCES AND AN INCREASED RISK OFVEHICLE ACCIDENT.
Remedy: THE 1987 TO 1990 MODEL VEHICLES WILL HAVE BOTH SPLASH SHIELDS REPLACED AND BOTH FRONT BRAKE HOSES REPLACED AS NECESSARY. ALL AFFECTED LATE 1990 THROUGH 1992 MODEL YEAR VEHICLES WILL HAVE ADDITIONAL FASTENERS INSTALLED TO FURTHER SECURE THE LEFT SIDE SPLASH SHIELD. ALSO, THE LEFT FRONT BRAKE HOSE WILL BE INSPECTED AND REPLACED AS NECESSARY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6EA99014 · Brake Roter Disc/hud Separation
Opened Jun 28, 1999 · Closed Mar 28, 2000
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
Additional source detail variants (2)
Service Brakes, Hydraulic
There is no summary currently available
Service Brakes, Hydraulic
There is no summary currently available
RQ97016 · Fuel Leakage
Opened Oct 27, 1997 · Closed Jun 30, 1998
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump
ODI HAS RECEIVED 6 REPORTS ON FUEL LEAKAGE AND 3 REPORTS ON ALLEGED REMEDY FAILURE REPORTS
PE95049 · Rear Axle Shaft Separation
Opened Aug 17, 1995 · Closed Jan 26, 1996
Status: closed (inferred from source dates) · Suspension
THIS INVESTIGATION WAS OPENED TO EXAMINE THE FAILURE MODE AND THE RISK TO MOTOR VEHICLE SAFETY POSED BY ALLEGATIONS OF REAR AXLE SEPARATIONS.THE REAR AXLE SHAFT AND HOUSING DESIGN IS TYPICAL OF THOSE IN WHICH THE WEIGHT OF THE VEHICLE IS CARRIED ON THE AXLE HOUSING.THE LEFT AND RIGHT AXLE SHAFTS, SUPPORTED BY ROLLER BEARINGS, ARE SITUATED INSIDE THE AXLE HOUSING.THE INBOARD SPLINED END OF THE AXLE SHAFT RECEIVES POWER TRANSMITTED FROM THE DIFFERENTIAL ASSEMBLY, PROVIDING TORQUE TO THE REAR WHEELS.THE ALLEGATIONS ARE THAT THE AXLE SHAFT FAILS, RESULTING IN THE SEPARATION OF A WHEEL AND AXLE HUB ASSEMBLY OR THE ENTIRE AXLE SHAFT AND WHEEL ASSEMBLY, DEPENDING ON THE LOCATION OF THE AXLE SHAFT FAILURE.AS IDENTIFIED BY CHRYSLER, THE SUBJECT REAR AXLES ARE DANA 35C AND 35CM MODELS, WHICH HAVE BEEN USED ON THE SUBJECT VEHICLES SINCE THE 1990 MODEL YEAR.A SAFETY DEFECT TREND WITH RESPECT TO THE SUBJECT AXLE SHAFTS HAS NOT BEEN IDENTIFIED.SEE HARD COPY RESUME FOR FULL TEXT OF SUMMARY.
EA93031 · Sending Unit Gasket Fails
Opened Dec 15, 1993 · Closed Jun 17, 1994
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA93025 · Driveshaft/univ.joint Fail
Opened Oct 29, 1993 · Closed Nov 25, 1994
Status: closed (inferred from source dates) · Power Train
There is no summary currently available
PE93051 · Fuel Line Leakage
Opened May 18, 1993 · Closed Aug 19, 1993
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available