PER EMISSIONS RECALL # 556 THE OYGEN SENSOR WAS REPLACE ON 02-08-95. THE REST OF THE RECALL COMPONENTS WERE EXAMINED AND DEAMED FINE. IT IS NOW THAT THE EXHAUST MANIFOLD NUTS AND BOLTS ARE FAILING AND CHRYSLER DOES NOT THINK THAT THEY/CHRYSLER SHOULD NEED TO REPLACE THEM. I AM TRYING TO GET ANSWERS IN TERMS OF IF ALL THESE CO…
Read full complaint
PER EMISSIONS RECALL # 556 THE OYGEN SENSOR WAS REPLACE ON 02-08-95. THE REST OF THE RECALL COMPONENTS WERE EXAMINED AND DEAMED FINE. IT IS NOW THAT THE EXHAUST MANIFOLD NUTS AND BOLTS ARE FAILING AND CHRYSLER DOES NOT THINK THAT THEY/CHRYSLER SHOULD NEED TO REPLACE THEM. I AM TRYING TO GET ANSWERS IN TERMS OF IF ALL THESE COMPONENTS WERE STATED IN THE RECALL BECAUSE THEY FAIL, WHY WERE THEY NOT ALL REPLACED AT THE TIME OF ORIGINAL SERVICE AND NOW THAT THEY ARE FAILING NOW, SHOULDN'T IT STILL BE COVERED UNDER THE RECALL? THE REPLACEMENT OF THE OXYGEN SENSOR HAS NOTHING TO DO WITH THE FAULTY THE NUTS AND BOLTS THAT HOLD THE SECURE FIT OF THE MANIFOLD TO THE ENGINE TO PREVENT EMISSION LEAKAGE.
VEHICLE DESCRIPTION: MULTIPURPOSE PASSENGER VEHICLES EQUIPPED WITH PLASTIC FUEL TANKS. THE FUEL TANK SENDING UNIT GASKET CAN CRACK CAUSING FUEL AND FUEL VAPOR LEAKS.
Consequence & remedy
Consequence: FUEL AND FUEL VAPOR LEAKED FROM THE FUEL TANK CAN RESULT IN FIRE WHEN EXPOSED TO A SOURCE OF IGNITION.
Remedy: REPLACE THE FUEL TANK SENDING UNIT GASKET.
WINDSHIELD FRAME METAL MAY CRACK AT THE WIPER ARM PIVOT MOUNTINGS DUE TO METAL STRESS DURING WIPER OPERATION.
Consequence & remedy
Consequence: THIS CAN CAUSE DISLOCATION AND BINDING OF THE WIPERSYSTEM LINKAGE WHICH, IN INCLEMENT WEATHER, COULD AFFECT DRIVER VISIBILITY ANDRESULT IN AN ACCIDENT.
Remedy: RETROFIT WITH A WINDSHIELD FRAME REINFORCEMENT AT THE WIPER PIVOT LOCATIONS AND INSTALL NEW REDESIGNED LINKAGE COMPONENTS TO REDUCE STRESS AT THE PIVOT MOUNTINGS.
ON 1987 THROUGH EARLY 1990 MODELS, BOTH FRONT BRAKE HOSES CAN WEAR DUE TO DIRECT CONTACT WITH THE WHEEL OPENING SPLASH SHIELDS. ON THE LATE 1990 THROUGH 1992 MODELS, PERIODIC RUBBING CONTACT OF THE LEFT FRONT BRAKE HOSE CAN OCCUR DUE TO MOVEMENT OF THE SPLASH SHIELD IN CERTAIN VEHICLE OPERATING CONDITIONS.
Consequence & remedy
Consequence: EITHER CONDITION CAN CAUSE LOSS OF FRONT BRAKE SYSTEMFUNCTIONS, RESULTING IN INCREASED STOPPING DISTANCES AND AN INCREASED RISK OFVEHICLE ACCIDENT.
Remedy: THE 1987 TO 1990 MODEL VEHICLES WILL HAVE BOTH SPLASH SHIELDS REPLACED AND BOTH FRONT BRAKE HOSES REPLACED AS NECESSARY. ALL AFFECTED LATE 1990 THROUGH 1992 MODEL YEAR VEHICLES WILL HAVE ADDITIONAL FASTENERS INSTALLED TO FURTHER SECURE THE LEFT SIDE SPLASH SHIELD. ALSO, THE LEFT FRONT BRAKE HOSE WILL BE INSPECTED AND REPLACED AS NECESSARY.
Illustration