2008 Jeep Patriot Fwd

EACH TIME AFTER FUELING UP THE VEHICLE, IT STALLS OUT. THIS HAS HAPPENED TWICE WITHIN A WEEK OF EACH OTHER ON A CITY STREET AFTER LEAVING THE GAS STATION. THE FIRST TIME MY FOOT WAS ON THE BRAKE AND THE CAR STALLED OUT. THE NEXT TIME THE CAR WAS IN MOTION AND STALLED. THIS IS A FRIGHTENING AND COMMONLY CITED ISSUE WITH PATRIOT OWNERS.

MY 2008 JEEP PATRIOT HESITATES, SPUTTERS, AND STALLS A FEW MINUTE AFTER I FILL IT UP. IF I DON'T FILL IT ALL THE WAY, IT DOES NOT STALL (AND I NEVER TOP-OFF WHEN FILLING). I HAVE STARTED THE PRACTICE OF ONLY FILLING 3/4 OR PULLING OVER IN THE GAS STATION TO LET THE CAR STALL AT IDLE BEFORE PROCEEDING. WHEN I FIRST NOTICED THE ISSUE A FEW MONTHS AGO, IT STALLED ON ME IN TRAFFIC AFTER LEAVING THE FUELING STATION. THIS WAS VERY DANGEROUS. MY MECHANIC AT THE DEALER TOLD ME TODAY HE BELIEVES THERE IS A BAD LIQUID/VAPOR VALVE ON THE GAS TANK CAUSING GAS TO ENTER AN EXHAUST LINE LEADING TO THE CARBON CANISTER, AND THAT A FULL GAS TANK REPLACEMENT IS NEEDED TO REPLACE THIS BAD VALVE. HE ALSO OFFERED, THAT I COULD JUST CONTINUE TO ONLY FILL THE TANK 3/4 AND SHOULD BE FINE. AT $2,000 TO REPLACED THE TANK, I MAY NEED TO CONSIDER HAVING THIS WORK DONE BY A NON-CHRYSLER SHOP? I FOUND THIS DISCUSSION ONLINE TODAY, AND EVERYONE IS HAVING THE EXACT SAME PROBLEM AS ME (WITH SOME HAVING DETAILED ACCOUNTS OF MAKING CLAIMS WITH THE NHTSA). PLEASE TAKE FIVE MINUTES TO REVIEW. THIS SEEMS LIKE A HUGE SAFETY ISSUE, AND I'M NOT THE ONLY ONE HAVING IT! HTTPS://WWW.CARGURUS.COM/CARS/DISCUSSION-T29898_DS631498 I'M NOT SURE WHAT CONDITIONS ARE NEEDED TO JUSTIFY A RECALL, BUT I'D ENCOURAGE YOU ALL TO GET OUT IN FRONT OF THIS ONE. THE '07 AND '08 PATRIOTS SEEM TO BE SYSTEMICALLY HAVING THIS ISSUE AND A RECALL MAY BE NEEDED TO SAVE LIVES (JUST IMAGINE ALL THESE CARS STALLING IN TRAFFIC)? I BELIEVE I HAVE TAKE GREAT CARE OF MY JEEP, BUT NEVER ANTICIPATED THIS ISSUE, AND THERE IS NO INDICATION FROM A CHECK ENGINE LIGHT THAT THIS PROBLEM IS BEING MONITORED BY THE SYSTEM. I THINK I ALSO OBSERVED THE STEERING WHEEL LOCK WHEN THIS OCCURRED, OR AT LEAST BECAME VERY DIFFICULT TO OPERATE. MY JEEP HAS A MANUAL TRANSMISSION.

ROLLOVER VALVE - EVERY TIME I FILLED THE GAS TANK, THERE WAS SIGNIFICANT JERKING AND OCCASIONAL STALLING. THIS DIDN'T HAPPEN IF I ONLY FILLED PARTIALLY. WITHIN A MILE THERE WOULD BE JERKING, AND STALLING HAS HAPPENED WHILE IDLING AND WHILE DRIVING. NOT ONLY IS THAT A HUGE SAFETY CONCERN, BUT IN A VEHICLE ROLLOVER THE VALVE PREVENTS GAS FROM SPILLING OUT AND STARTING POSSIBLE FIRES. LUCKILY I WAS ONLY ON LOCAL STREETS AND NOT A HIGHWAY WHEN I STALLED, BUT I HAVE READ OTHER FORUMS WHERE PEOPLE'S PATRIOTS STALLED AT HIGHER SPEEDS. THE JEEP DEALERSHIP AND OTHER MECHANICS SEEM TO KNOW THIS IS A COMMON FLAW WITH JEEPS AND CHRYSLERS BUILT IN THE PAST 5-8 YEARS. THE ONLY SOLUTION TO REPLACE THE VALVE IS TO REPLACE THE ENTIRE FUEL TANK, WHICH IS EXTREMELY COSTLY. THIS SHOULD DEFINITELY BE RECALLED DUE TO SAFETY, BUT CHRYSLER SEEMS TO KNOW ABOUT THIS ISSUE AND HAS DONE NOTHING.