IllustrationI HAVE OWNED CAR FOR 8 MONTHS (PURCHASED USED FROM DEALERSHIP) ENGINE KNOCKING. ENGINE SEIZED UP YESTERDAY. NO ENGINE WARNING LIGHT. ENGINE IS COMPLETELY DONE. WAS DRIVING DOWN THE ROAD YESTERDAY HEARD LOUD KNOCKING AND CAR DIED. HAD TO HAVE TOWED.
2012 Hyundai Veloster
Owner reports · Recalls · Investigations
More warning signs than most Veloster years
Owner complaints for the 2012 Hyundai Veloster are substantially higher than the model-year median of 85.
About this comparison →How this year compares
Owner complaints by model year
Compare all Veloster years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
760–25K
3125–50K
3650–75K
4675–100K
32100–150K
9150K+
230 reports with mileage · 66 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine. Review the 61 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 55 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 42 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
15 crash reports8 fire reports25 injury reports
What owners actually said
296 reportsTL* THE CONTACT OWNS A 2012 HYUNDAI VELOSTER. WHILE THE VEHICLE WAS PARKED AND OPENING THE SUN ROOF, A PIECE OF THE PLASTIC HOUSING FRACTURED AND JAMMED THE SUN ROOF. AS A RESULT, THE SUN ROOF COULD NOT CLOSE. THE CONTACT WAS ABLE TO REMOVE THE PIECE OF FRACTURED HOUSING AND CLOSE THE SUN ROOF. THE VEHICLE WAS NOT TAKEN TO AN IN…
Read full complaint
TL* THE CONTACT OWNS A 2012 HYUNDAI VELOSTER. WHILE THE VEHICLE WAS PARKED AND OPENING THE SUN ROOF, A PIECE OF THE PLASTIC HOUSING FRACTURED AND JAMMED THE SUN ROOF. AS A RESULT, THE SUN ROOF COULD NOT CLOSE. THE CONTACT WAS ABLE TO REMOVE THE PIECE OF FRACTURED HOUSING AND CLOSE THE SUN ROOF. THE VEHICLE WAS NOT TAKEN TO AN INDEPENDENT MECHANIC OR DEALER FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS CONTACTED AND CONFIRMED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBERS: 13V051000 (VISIBILITY) AND 12V568000 (VISIBILITY). THE FAILURE MILEAGE WAS APPROXIMATELY 102,000.
ON 7/2/2017 I WAS DRIVING ON A LOCAL ROAD AT APPROXIMATELY 35 MPH. WHEN WE HEARD A POP SOUND AND PORTIONS OF MY SUMROOF CAME CASCADING ON TO THE PASSANGER IN THE BACK SEAT. I IMMEDIATELY PULLED OVER TO INSPECT THE CAR. I HAVE ATTACHED PICTURES
I PURCHASED THIS CAR 3/2012 DEC 2013 MY CAR HAD TO BE TAKEN IN FOR THE REAR BRAKE CALIPERS , SUNROOF AND THE CHECK ENGINE LIGHT WAS ON, TOOK IT IN TO KENDALL HYUNDAI, CAR WAS OK BUT HAD LOW POWER. FEB 2016 CAR HAD TO GO BACK IN MY TRUNK LOCK WOULD NOT RELEASE. OCT 2016, ENGINE HAD A LOUD KNOCKING SOUND AFTER OIL CHANGE & SERVIC…
Read full complaint
I PURCHASED THIS CAR 3/2012 DEC 2013 MY CAR HAD TO BE TAKEN IN FOR THE REAR BRAKE CALIPERS , SUNROOF AND THE CHECK ENGINE LIGHT WAS ON, TOOK IT IN TO KENDALL HYUNDAI, CAR WAS OK BUT HAD LOW POWER. FEB 2016 CAR HAD TO GO BACK IN MY TRUNK LOCK WOULD NOT RELEASE. OCT 2016, ENGINE HAD A LOUD KNOCKING SOUND AFTER OIL CHANGE & SERVICE AT THE SAME DEALERSHIP, I HAD TO HAVE AN ENGINE CHANGE, CHECK ENGINE LIGHT NEVER GOES OFF. AS RECENT AS MAY 26, 2017 MY CAR FAILED , OIL LIGHT FLICKERING, CHECK ENGINE LIGHT ON. I RECEIVED THE CAR BACK ON JUN 22, 2017 AFTER ANOTHER ENGINE CHANGE. THE CAR'S CHECK ENGINE LIGHT IS STILL ON CALLED THE DEALERSHIP BACK AND WILL TAKE THE CAR . THE DEALERSHIP HAS SCHEDULED THIS TUESDAY & THAT THEY WILL KEEP THE CAR AGAIN FOR ANOTHER COUPLE OF DAYS. IT IS VERY DISTURBING BECAUSE MY CAR HAS NOW HAD 2 ENGINE CHANGE AND THE CHECK ENGINE LIGHT IS STILL ON. I HAVE LOST THE VALUE IN THE CAR AND IT IS & WAS LEMON CAR. HYUNDAI SHOULD BE SHUT DOWN FOR SELLING FAULTY CARS. I WAS DRIVING THE CAR ON THE HIGHWAY AT EACH ENGINE FAILURE. I HAVE ALL MY RECORDS ON HAND.
TL* THE CONTACT OWNS A 2012 HYUNDAI VELOSTER. THE CONTACT STATED THAT WHILE LOADING THE GROCERIES INTO THE VEHICLE, THE HATCH-BACK FELL ON THE CONTACT'S BACK. THE CONTACT SUSTAINED AN INJURY THAT DID NOT REQUIRE MEDICAL ATTENTION. THE CONTACT CALLED THE DEALER AT: THE HYUNDAI OF WESTLEY CHAPEL, WESTLEY CHAPEL, FL, WHERE IT WAS S…
Read full complaint
TL* THE CONTACT OWNS A 2012 HYUNDAI VELOSTER. THE CONTACT STATED THAT WHILE LOADING THE GROCERIES INTO THE VEHICLE, THE HATCH-BACK FELL ON THE CONTACT'S BACK. THE CONTACT SUSTAINED AN INJURY THAT DID NOT REQUIRE MEDICAL ATTENTION. THE CONTACT CALLED THE DEALER AT: THE HYUNDAI OF WESTLEY CHAPEL, WESTLEY CHAPEL, FL, WHERE IT WAS STATED THAT THERE WAS NO RECALL. THE MANUFACTURER WAS CALLED AND THE CONTACT WAS PUT ON HOLD BUT A REPRESENTATIVE DID NOT RETURN TO THE LINE. THE FAILURE MILEAGE WAS ABOUT 55,000.
TL* THE CONTACT OWNS A 2012 HYUNDAI VELOSTER. THE CONTACT STATED THAT THE HEADLIGHT BULBS BURNED OUT OFTEN. ALSO, WHILE IDLING AT A STOP, THE VEHICLE JERKED, LOST POWER, AND SHUT OFF WITHOUT WARNING. THE VEHICLE WAS ABLE TO BE RESTARTED. THE CONTACT ALSO STATED THAT THE VEHICLE ACCELERATED AUTOMATICALLY IN INTERVALS AND THE ENGI…
Read full complaint
TL* THE CONTACT OWNS A 2012 HYUNDAI VELOSTER. THE CONTACT STATED THAT THE HEADLIGHT BULBS BURNED OUT OFTEN. ALSO, WHILE IDLING AT A STOP, THE VEHICLE JERKED, LOST POWER, AND SHUT OFF WITHOUT WARNING. THE VEHICLE WAS ABLE TO BE RESTARTED. THE CONTACT ALSO STATED THAT THE VEHICLE ACCELERATED AUTOMATICALLY IN INTERVALS AND THE ENGINE MADE A KNOCKING SOUND. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE VEHICLE OPERATED AS DESIGNED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES AND REFERRED THE CONTACT TO THE DEALER. THE FAILURES WERE NOT REMEDIED. THE FAILURE MILEAGE WAS APPROXIMATELY 50,000.
AS I WAS DRIVING, MOON/SUN ROOF SPONTANEOUSLY IMPLODED ALL OVER ME AND THE INTERIOR OF THE CAR
I WAS DRIVING DOWN THE INTERSTATE WHEN I HEARD A BANG AND SAW THAT THE BACK PART OF MY SUNROOF HAD SHATTERED. THERE WERE NO PROJECTILES FOUND.
MY SON WAS DRIVING WITH THE PANORAMIC SUNROOF OPEN AND GETTING UP TO SPEED ON A 55MPH ROAD. HE WAS GOING APPRX. 35-45 MPH WHEN THE SUNROOF SHATTERED. HE WAS CONFUSED AND ALL VEHICLE PASSENGERS WERE OK, THEY PULLED OVER. NOBODY WAS HURT. WE LOOKED UP AND THERE WAS A PREVIOUS RECALL FOR THIS SORT OF THING HAPPENING. THEY SPE…
Read full complaint
MY SON WAS DRIVING WITH THE PANORAMIC SUNROOF OPEN AND GETTING UP TO SPEED ON A 55MPH ROAD. HE WAS GOING APPRX. 35-45 MPH WHEN THE SUNROOF SHATTERED. HE WAS CONFUSED AND ALL VEHICLE PASSENGERS WERE OK, THEY PULLED OVER. NOBODY WAS HURT. WE LOOKED UP AND THERE WAS A PREVIOUS RECALL FOR THIS SORT OF THING HAPPENING. THEY SPENT THE NEXT FEW HOURS PICKING ALL THE GLASS OUT OF THE VEHICLE AND THEIR CLOTHING. WE CAN NOT CLOSE THE SUNROOF ATTACHMENT AND HAVE TAKEN OUR VEHICLE TO HYUNDAI TO BE TOLD IT IS NOT INCLUDED IN THE RECALL.
THE HYUNDAI VELOSTER 2012 HAD A RECALL A FEW YEARS AGO CONCERNING THE SUDDEN EXPLOSION OF THE PANORAMIC SUNROOF. I TOOK IN MY VEHICLE IMMEDIATELY TO BE CHECKED OUT AND WAS TOLD THE SUNROOF WAS FINE. WHILE DRIVING THE VEHICLE AT ABOUT 65/70 MILES PER HOUR ON THE HIGHWAY DURING RUSH HOUR, AN EXTREMELY LOUD BANG OCCURRED. I IMMEDIA…
Read full complaint
THE HYUNDAI VELOSTER 2012 HAD A RECALL A FEW YEARS AGO CONCERNING THE SUDDEN EXPLOSION OF THE PANORAMIC SUNROOF. I TOOK IN MY VEHICLE IMMEDIATELY TO BE CHECKED OUT AND WAS TOLD THE SUNROOF WAS FINE. WHILE DRIVING THE VEHICLE AT ABOUT 65/70 MILES PER HOUR ON THE HIGHWAY DURING RUSH HOUR, AN EXTREMELY LOUD BANG OCCURRED. I IMMEDIATELY ASSOCIATED THE LOUD BANG AS A GUN SHOT. GLASS FROM THE CEILING FELL INTO THE VEHICLE AND ON MY BODY AS THE SUNROOF COVER RIPPED OPEN. I WAS SO STARTLED, THAT I DUCKED TRYING TO PROTECT MYSELF AS GLASS WAS FALLING ONTO ME WHILE DRIVING. I WAS ABLE TO TURN ON MY HAZARDS AND PULL OVER ON THE SIDE OF THE ROAD. ALTHOUGH, I DID NOT SPEAK TO ANY WITNESSES, I AM CERTAIN THE SEMI-TRUCK DRIVING BESIDE ME SAW WHAT OCCURRED AS HE TURNED ON HIS HAZARDS AND SLOWED DOWN TO LET ME OVER. I WAS LITERALLY SHAKING FROM BEING SO SCARED AND CAUGHT OFF GUARD. I GOT OUT OF THE CAR TO SEE WHAT HAD OCCURRED AND MY SUNROOF HAD EXPLODED. THE ENTIRE GLASS PORTION OF THE SUNROOF WAS GONE EXCEPT FOR THE EDGES, WHICH WERE LEFT CRACKED. I ATTEMPTED TO TAKE A PICTURE, BUT IT WAS DARK AND I WAS ON THE HIGHWAY, WHICH WAS NOT SAFE. MY VEHICLE HAS BEEN AT THE HYUNDAI DEALERSHIP SINCE 12/21/16. I COULD NOT REACH ANYONE AT THE SERVICE DEPARTMENT, EVEN THOUGH I CALLED DURING HOURS OF OPERATION. I WAS THEN INSTRUCTED TO LEAVE THE VEHICLE OVER NIGHT. AS OF 5:48 PM ON 12/22/16, I WAS TOLD THE SERVICE DEPARTMENT IS WAITING ON INSTRUCTION FROM HYUNDAI'S CORPORATE OFFICE AND HAVE NOT BEEN PROVIDED A VEHICLE. ALTHOUGH, I DID NOT SUFFER ANY SERIOUS INJURIES, I AM VERY WORRIED ABOUT THE SAFETY OF OTHERS DRIVING THIS VEHICLE. NOT ONLY IS THE GLASS ITSELF DANGEROUS, BUT THE SOUND WAS SO STARTLING IT COULD CAUSE SOMEONE TO VEER OFF INTO OTHER VEHICLES CAUSING GREAT BODILY INJURIES. I HAD NOT OPENED THE SUNROOF FOR DAYS, PERHAPS EVEN WEEKS AS IT HAS BEEN VERY COLD. *TR
Official recalls
623V651000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
Sep 22, 2023
Hyundai Motor America (Hyundai) is recalling certain 2011-2015 Elantra, Genesis Coupe, Sonata Hybrid, 2012-2015 Accent, Azera, Veloster, 2013-2015 Elantra Coupe, Santa Fe, 2014-2015 Equus, 2010-2012 Veracruz, 2010-2013 Tucson, 2015 Tucson Fuel Cell, and 2013 Santa Fe Sport vehicles. The Anti-Lock Brake System (ABS) module may leak brake fluid internally and cause an electrical short, which can result in an engine compartment fire while parked or driving.
Consequence & remedy
Consequence: An engine compartment fire while parked or driving can increase the risk of injury.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the ABS fuse, free of charge. Owner notification letters were mailed April 10, 2024 through October 11, 2024. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 251.
23V132000 · Electrical System
Feb 28, 2023
Hyundai Motor America (Hyundai) is recalling certain 2012-2014 Veloster vehicles. High conductive liquid may leak into the Reverse Park Aid Sensor (RPAS), which can result in an electrical short circuit.
Consequence & remedy
Consequence: An electrical short circuit increases the risk of a fire.
Remedy: Dealers will inspect and replace the RPAS fuse and sensor, as necessary, free of charge. Owner notification letters were mailed July 28, 2023. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 242.
20V393000 · Equipment:electrical
Jul 2, 2020
Hyundai Motor America (Hyundai) is recalling certain 2011-2012 Hyundai Elantra and Sonata Hybrid, 2012 Accent and Veloster vehicles. The 12V accessory socket outlet may have been over-tightened during installation, possibly disabling the thermal fuse and allowing the outlet to overheat with prolonged use, such as by using the Tire Mobility Kit air compressor to inflate a tire.
Consequence & remedy
Consequence: An overheated accessory outlet increases the risk of fire.
Remedy: Hyundai will notify owners, and dealers will replace the Tire Mobility Kit accessory outlet plug with a direct-to-battery connection wire harness kit, free of charge. The recall began September 28, 2020. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 193.
13V051000 · Visibility:sun/moon Roof Assembly
Feb 19, 2013
Hyundai is recalling certain model year 2012 Veloster vehicles manufactured from July 4, 2011, through October 31, 2011 and equipped with panoramic sunroofs. The panoramic sunroof assembly may have been weakened during installation at the factory.
Consequence & remedy
Consequence: If the assembly was weakend at the factory, the panoramic glass panel may break while the vehicle is in motion leading to personal injury or a vehicle crash.
Remedy: Hyundai will notify owners, and dealers will inspect the sunroof's integrity and replace the sunroof glass assembly, as necessary, free of charge. The safety recall began during March 2013. Owners may contact Hyundai at 1-800-633-5151.
12V567000 · Parking Brake:conventional:mechanical:linkage And Cable
Dec 7, 2012
Hyundai is recalling certain model year 2012 Veloster vehicles manufactured from July 2, 2011, through February 27, 2012 and equipped with manual transmissions. Moisture and road grime may cause the parking brake components to bind.
Consequence & remedy
Consequence: If the parking brake components bind, the parking brake may not operate properly, and the parking brake may drag while driving or may not fully engage when the vehicle is parked. If the parking brake is not fully engaged when parked, a manual transmission may move unintentionally, increasing the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will replace the rear brake caliper assemblies free of charge. The safety recall began January 22, 2013. Owners may contact Hyundai at 1-800-633-5151.
12V568000 · Visibility:sun/moon Roof Assembly
Dec 7, 2012
Hyundai is recalling certain model year 2012 Veloster vehicles manufactured from November 1, 2011, through April 17, 2012 and equipped with panoramic sunroofs. The panoramic sunroof assembly may been weakened during installation at the factory.
Consequence & remedy
Consequence: If the assembly was weakend at the factory, the panoramic glass panel may break while the vehicle is in motion leading to personal injury or a vehicle crash.
Remedy: Hyundai will notify owners, and dealers will inspect the sunroof's integrity and replace the sunroof glass assembly, as necessary, free of charge. The safety recall began January 22, 2013. Owners may contact Hyundai at 1-800-633-5151.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2AQ23002 · Hyundai And Kia Abs Module Fires
Opened Nov 17, 2023 · No close date supplied
Status: open (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
The Office of Defects Investigation (ODI) has received eight Hyundai Motor America (Hyundai) and eight Kia America, Inc. (Kia) Part 573 Recall Reports between 2016 and 2023. The combined 16 safety recalls all involve the antilock braking system (ABS) modules or Hydraulic Electronic Control Units (HECU) manufactured by the equipment supplier Mando. The Part 573 Recall Reports contain varying defect descriptions and differing remedy descriptions for the same or similar equipment supplied by Mando. Safety recalls included in this Audit Query (AQ) review include: Hyundai recalls 20V-520, 20V-543, 21V-161, 21V-160, 21V-303, 22V-056, 22V-810, and 23V-651. Kia recalls 16V-815, 20V-518, 20V-519, 21V-137, 21V-331, 22V-051, 22V-800, and 23V-652 The purpose of this AQ is to evaluate the timeliness and scoping of Hyundai and Kia’s defect decision making and adherence with reporting requirements; and understand the varying defect descriptions and remedies between these recalls.
PE12027 · Panoramic Sunroof Breakage
Opened Oct 2, 2012 · Closed Feb 21, 2013
Status: closed (inferred from source dates) · Visibility; Visibility:sun/moon Roof Assembly
The Office of Defects Investigation (ODI) opened PE12-027 on October 2, 2012 to investigate allegations of spontaneous sunroof shatter on model year (MY) 2012 Hyundai Veloster vehicles. The MY2012 platform was the first to introduce the panoramic sunroof option. ODI received 26 consumer complaints of sunroof shatter, 15 occurring while the vehicle was being driven. The injury incidents noted were due to complainants who alleged minor cuts or abrasions from fallen glass. Sunroof glass shattering while operating the vehicle poses a risk of personal injury or a vehicle crash.In response to ODI's information request (IR), Hyundai provided 23 consumer complaints related to the alleged problem and 46 warranty claims for sunroof shatter and/or replacement.On December 6, 2012 Hyundai notified ODI that it would conduct a safety recall on model year 2012 Veloster vehicles equipped with panoramic sunroofs manufactured from November 1, 2011 through April 17, 2012. The panoramic sunroof assembly may have weakened during installation at the factory. An intermittent malfunction of a limit switch for the panoramic sunroof assembly's unloading station robot may have occurred, allowing forced contact between the mechanism and the sunroof glass. This contact could have caused damage to the sunroof glass, and lead to subsequent shattering of the glass in the field. The loading station robot was repaired in April 2012. The initial point in time for the malfunction of the station robot was not clearly defined through technical reasoning, therefore ODI challenged the proposed production scope for the safety recall. On February 14, 2013 Hyundai responded that they will conduct safety recall 13V-051 which expands the covered vehicles to those produced from the start of MY2012 production (July 4, 2011) through April 17, 2012. This investigation is closed on the basis of Hyundai's announcement of safety recalls 12V-568 and 13V-051.The reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers: 10462857, 10463570, 10465757, 10468816, 10468854, 10469144, 10471972, 10472742, 10473062, 10473640, 10477212, 10478075, 10478735, 10479487, 10479931, 10482027, 10482056, 10482561, 10482760, 10482933, 10483765, 10483770, 10484048, 10485802, 10487399, 10490171
Additional source detail variants (4)
Visibility
The Office of Defects Investigation (ODI) opened PE12-027 on October 2, 2012 to investigate allegations of spontaneous sunroof shatter on model year (MY) 2012 Hyundai Veloster vehicles. The MY2012 platform was the first to introduce the panoramic sunroof option. ODI received 26 consumer complaints of sunroof shatter, 15 occurring while the vehicle was being driven. The injury incidents noted were due to complainants who alleged minor cuts or abrasions from fallen glass. Sunroof glass shattering while operating the vehicle poses a risk of personal injury or a vehicle crash.In response to ODI's information request (IR), Hyundai provided 23 consumer complaints related to the alleged problem and 46 warranty claims for sunroof shatter and/or replacement.On December 6, 2012 Hyundai notified ODI that it would conduct a safety recall on model year 2012 Veloster vehicles equipped with panoramic sunroofs manufactured from November 1, 2011 through April 17, 2012. The panoramic sunroof assembly may have weakened during installation at the factory. An intermittent malfunction of a limit switch for the panoramic sunroof assembly's unloading station robot may have occurred, allowing forced contact between the mechanism and the sunroof glass. This contact could have caused damage to the sunroof glass, and lead to subsequent shattering of the glass in the field. The loading station robot was repaired in April 2012. The initial point in time for the malfunction of the station robot was not clearly defined through technical reasoning, therefore ODI challenged the proposed production scope for the safety recall. On February 14, 2013 Hyundai responded that they will conduct safety recall 13V-051 which expands the covered vehicles to those produced from the start of MY2012 production (July 4, 2011) through April 17, 2012. This investigation is closed on the basis of Hyundai's announcement of safety recalls 12V-568 and 13V-051.The reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers: 10462857, 10463570, 10465757, 10468816, 10468854, 10469144, 10471972, 10472742, 10473062, 10473640, 10477212, 10478075, 10478735, 10479487, 10479931, 10482027, 10482056, 10482561, 10482760, 10482933, 10483765, 10483770, 10484048, 10485802, 10487399, 10490171
Visibility
The Office of Defects Investigation (ODI) opened PE12-027 on October 2, 2012 to investigate allegations of spontaneous sunroof shatter on model year (MY) 2012 Hyundai Veloster vehicles. The MY2012 platform was the first to introduce the panoramic sunroof option. ODI received 26 consumer complaints of sunroof shatter, 15 occurring while the vehicle was being driven. The injury incidents noted were due to complainants who alleged minor cuts or abrasions from fallen glass. Sunroof glass shattering while operating the vehicle poses a risk of personal injury or a vehicle crash.In response to ODI's information request (IR), Hyundai provided 23 consumer complaints related to the alleged problem and 46 warranty claims for sunroof shatter and/or replacement.On December 6, 2012 Hyundai notified ODI that it would conduct a safety recall on model year 2012 Veloster vehicles equipped with panoramic sunroofs manufactured from November 1, 2011 through April 17, 2012. The panoramic sunroof assembly may have weakened during installation at the factory. An intermittent malfunction of a limit switch for the panoramic sunroof assembly's unloading station robot may have occurred, allowing forced contact between the mechanism and the sunroof glass. This contact could have caused damage to the sunroof glass, and lead to subsequent shattering of the glass in the field. The loading station robot was repaired in April 2012. The initial point in time for the malfunction of the station robot was not clearly defined through technical reasoning, therefore ODI challenged the proposed production scope for the safety recall. On February 14, 2013 Hyundai responded that they will conduct safety recall 13V-051 which expands the covered vehicles to those produced from the start of MY2012 production (July 4, 2011) through April 17, 2012. This investigation is closed on the basis of Hyundai's announcement of safety recalls 12V-568 and 13V-051.The reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers: 10462857, 10463570, 10465757, 10468816, 10468854, 10469144, 10471972, 10472742, 10473062, 10473640, 10477212, 10478075, 10478735, 10479487, 10479931, 10482027, 10482056, 10482561, 10482760, 10482933, 10483765, 10483770, 10484048, 10485802, 10487399, 10490171
Visibility:sun/moon Roof Assembly
The Office of Defects Investigation (ODI) opened PE12-027 on October 2, 2012 to investigate allegations of spontaneous sunroof shatter on model year (MY) 2012 Hyundai Veloster vehicles. The MY2012 platform was the first to introduce the panoramic sunroof option. ODI received 26 consumer complaints of sunroof shatter, 15 occurring while the vehicle was being driven. The injury incidents noted were due to complainants who alleged minor cuts or abrasions from fallen glass. Sunroof glass shattering while operating the vehicle poses a risk of personal injury or a vehicle crash.In response to ODI's information request (IR), Hyundai provided 23 consumer complaints related to the alleged problem and 46 warranty claims for sunroof shatter and/or replacement.On December 6, 2012 Hyundai notified ODI that it would conduct a safety recall on model year 2012 Veloster vehicles equipped with panoramic sunroofs manufactured from November 1, 2011 through April 17, 2012. The panoramic sunroof assembly may have weakened during installation at the factory. An intermittent malfunction of a limit switch for the panoramic sunroof assembly's unloading station robot may have occurred, allowing forced contact between the mechanism and the sunroof glass. This contact could have caused damage to the sunroof glass, and lead to subsequent shattering of the glass in the field. The loading station robot was repaired in April 2012. The initial point in time for the malfunction of the station robot was not clearly defined through technical reasoning, therefore ODI challenged the proposed production scope for the safety recall. On February 14, 2013 Hyundai responded that they will conduct safety recall 13V-051 which expands the covered vehicles to those produced from the start of MY2012 production (July 4, 2011) through April 17, 2012. This investigation is closed on the basis of Hyundai's announcement of safety recalls 12V-568 and 13V-051.The reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers: 10462857, 10463570, 10465757, 10468816, 10468854, 10469144, 10471972, 10472742, 10473062, 10473640, 10477212, 10478075, 10478735, 10479487, 10479931, 10482027, 10482056, 10482561, 10482760, 10482933, 10483765, 10483770, 10484048, 10485802, 10487399, 10490171
Visibility:sun/moon Roof Assembly
The Office of Defects Investigation (ODI) opened PE12-027 on October 2, 2012 to investigate allegations of spontaneous sunroof shatter on model year (MY) 2012 Hyundai Veloster vehicles. The MY2012 platform was the first to introduce the panoramic sunroof option. ODI received 26 consumer complaints of sunroof shatter, 15 occurring while the vehicle was being driven. The injury incidents noted were due to complainants who alleged minor cuts or abrasions from fallen glass. Sunroof glass shattering while operating the vehicle poses a risk of personal injury or a vehicle crash.In response to ODI's information request (IR), Hyundai provided 23 consumer complaints related to the alleged problem and 46 warranty claims for sunroof shatter and/or replacement.On December 6, 2012 Hyundai notified ODI that it would conduct a safety recall on model year 2012 Veloster vehicles equipped with panoramic sunroofs manufactured from November 1, 2011 through April 17, 2012. The panoramic sunroof assembly may have weakened during installation at the factory. An intermittent malfunction of a limit switch for the panoramic sunroof assembly's unloading station robot may have occurred, allowing forced contact between the mechanism and the sunroof glass. This contact could have caused damage to the sunroof glass, and lead to subsequent shattering of the glass in the field. The loading station robot was repaired in April 2012. The initial point in time for the malfunction of the station robot was not clearly defined through technical reasoning, therefore ODI challenged the proposed production scope for the safety recall. On February 14, 2013 Hyundai responded that they will conduct safety recall 13V-051 which expands the covered vehicles to those produced from the start of MY2012 production (July 4, 2011) through April 17, 2012. This investigation is closed on the basis of Hyundai's announcement of safety recalls 12V-568 and 13V-051.The reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers: 10462857, 10463570, 10465757, 10468816, 10468854, 10469144, 10471972, 10472742, 10473062, 10473640, 10477212, 10478075, 10478735, 10479487, 10479931, 10482027, 10482056, 10482561, 10482760, 10482933, 10483765, 10483770, 10484048, 10485802, 10487399, 10490171