2025 Hyundai Tucson

The Automatic Emergency Braking system, I think it may be called (or is a part of) the Forward Collision Avoidance system by Hyundai, triggered incorrectly while on Interstate 265. My car was travelling at about 35 MPH on the off ramp when the Automatic Emergency Braking system triggered and cause my car to rapidly decelerate to a near standstill. The vehicle following behind me had to swerve into another lane to avoid hitting my car. The problem has not been reproduced or confirmed by a dealer or service center. The component has not been inspected yet, but we will be bringing it to the dealer in the near future. There were not warnings or messages that this was about to happen other than the emergency sound and light when the Automated Emergency Braking engaged. This has happened twice before on other roads and in other situations with this car.

We have had a suspension clunk since we bought this in April 2025. Something is loose in the right rear. They have replace the right and left rear shock mount, the right rear shock and it still persists. There is a clunk or grabbing noise when the brakes are applied as it almost comes to a stop, it appears to be in the front. This has not been found, the last mechanic that looked at this said all new vehicles do this.

There was an accident involving this vehicle where another vehicle pulled out in front causing a collision. There was damage only to the front of the vehicle which caused several malfunctions. Prior to the impact the break assist did not operate which may have prevented the collision but when the impact happened the seat belts locked in place and the driver side window would not roll down nor would the driver side door open. This seems to be a safety hazard as if the vehicle were on fire how would the driver be able to get out? The problem was reported to the dealer, with no resolution. I do have photos of the damage that can be available upon request.

Vehicle dash intermittently goes out. Flickers, goes dark, or shows every warning that exists on the panel. Could be unsafe as speed, gas gage, or other warnings that provide safety are going dark. Took it to dealer in Roseville, Ca. They tried to repair it, but problem began to occur again a week later. I have a video of it, but can’t show here.

Issue Type: Intermittent Electronic System Failure / Critical Safety Hazard Description of Incident: A severe safety-related incident occurred while driving at night on 12/29/2025, at approximately 5:48 pm. Under fully dark winter conditions in MA, while the vehicle was in motion with the headlights set to AUTO, the following events occurred: Total System Blackout: All interior and exterior lighting systems suddenly failed simultaneously, including the digital instrument cluster, infotainment display, and backlighting for all illuminated buttons and controls. The complete failure of exterior lighting and interior displays resulted in an immediate loss of forward visibility and access to critical driving information. Duration: The blackout lasted approximately two seconds before the system appeared to reboot. Recurrence: Approximately ten seconds after the first incident, the same total blackout occurred again under identical conditions. Vehicle Status: The engine remained running throughout the incidents; however, the simultaneous loss of lighting and instrumentation created an extremely high-risk driving situation. This incident constitutes a critical safety failure. The vehicle had experienced repeated electrical system failures prior to this incident, and was previously presented to the dealer on 8/7/2025 for diagnosis and repair. The dealer was unable to determine the cause of the malfunction and failed to take appropriate corrective action to address these issues: 07/13/2025: The Auto Stop function became inactive, and the vehicle failed to accelerate properly after stopping at traffic lights, creating a hazardous driving condition. 07/14/2025: The phone failed to connect to the vehicle’s infotainment system. 07/17/2025: While reversing in a parking lot, the Parking Collision Warning system failed to detect a moving vehicle behind the car. No audible or visual warning was issued, rendering the safety feature ineffective in preventing a potential collision.

This vehicle has had numerous problems since I leased it. To summarize, at times the vehicle randomly shifts out of the ECO mode, usually into the SNOW mode. The engine has also raced, hesitated, bucked, rattled and vibrated when trying to change gears. Sometimes, these actions are subtle and sometimes they are borderline violent. This happens more frequently when the engine is cold. Additionally, the AEB system has activated a number of times while in stop and go traffic, even though the vehicle in front was moving forward. On at least 3 of these occasions, i barely avoided being rear-ended by the vehicle following me. The final issue that I have noticed is a problem with the odometer. It has appeared to work normally most of the time, but I have noticed times where I didn't think the odometer accurately reflected the distance I had traveled. I was able to synch the odometer with the trip odometer on a local road that I was quite familiar with. The trip odometer registered 1.8 miles while the odometer only registered 1 mile traveled. All of these issues happened multiple times and are intermittent. I have had the vehicle to Hyundai dealers on 5 occasions, and they claim to have not been able to duplicate any of the problems that I have been consistently logging in to a "diary" that represents a list of when I have noticed these issues. I have been in constant contact with Hyundai, but they promised to send out a factory rep, then reneged, instead relying on the local service techs. Said techs had the vehicle for nearly 2 weeks, but only drove it for 16 miles (until I called AFTER a determination was made and they hurriedly drove it an additional 22 miles to give the appearance of a more complete exam), using less than a quarter tank of gas. To me, this wasn't a thorough exam and appeared to be a cover-up to avoid having to buy back the vehicle. Note: these problems have occurred on multiple occasions, therefore the date below is the lease date.