2025 Hyundai Tucson

The forward collision avoidance system in this generation of Hyundai tucsons is dangerously flawed. We previously had a 2020 and no issues, but this one slams the brakes at the drop of a hat and has nearly caused several accidents as there is no good reason for the intervention (ample space to leading vehicle) and it brakes so hard that cars behind typically need to veer to avoid rear end collision. This is not a one-off event or linked to particular driver/driving style - both adult owners of this vehicle have experienced this on multiple unrelated occasions. All sensitivity setting have been set to minimum and the only way to drive with peace of mind is to completely disable the system - but here is where the next massive design flaw is: the system automatically reenables at each re-ignition; there is not permanent override, which is EXTREMELY dangerous. It is not practical to manually disable the system on each drive because you need to navigate multiple system menus to adjust the setting. Google and user forums confirm this collision avoidance system is a widely experienced and complained about safety issue for Hyundai and it should be investigated. People will likely get killed due to this “safety feature”. Ideally Hyundai should push a recalibration for those who want this feature AND enable a permanent override option in the system settings for those who don’t.

The contact rented a 2025 Hyundai Tucson. The contact stated that the vehicle would stop and would restart independently while driving. The contact stated that while attempting to reverse, the vehicle failed to respond on several occasions while the gear shifter was in reverse(R). The contact stated that the failure occurred while there was a vehicle parked behind the vehicle or further away. There was no warning light illuminated. The rental company was informed of the failure. Additionally, the contact stated that upon shifting to reverse on one occasion, the vehicle responded, but unintendedly accelerated. The contact stated that upon depressing the brake pedal, the brake pedal was stiff and failed to respond, causing the vehicle to crash into an unoccupied parked vehicle. The contact stated that the distance between the two vehicles could fit two parked vehicles. The contact stated that her teenager was occupying the front passenger's side seat during the incident. The contact stated that the front passenger's side and driver's side seat belts failed to restrain the passengers as needed, causing both passengers to use their arms to protect themselves. The police officers arrived at the scene but did not file a report. Both passengers sustained arm, neck, and head pain but declined to be transported to the hospital by ambulance. The contact stated that the gear shifter was locked after the crash and required two hands to move to park(P). The rental company was informed of the failure. The contact was able to drive the vehicle back to the residence. The vehicle was driven to the Rental Company the following day. No further information was available. The dealer and the manufacturer were not notified of the failure. The failure mileage was 24,292.

The contact owns a 2025 Hyundai Tucson. The contact stated that while driving at an undisclosed speed, the instrument cluster independently turned off. In addition, the contact stated that an error code with an unknown message was displayed. The vehicle was taken to the dealer; however, the failure was not diagnosed. The contact stated that the vehicle had been taken back to the dealer three times since the vehicle was purchased. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was unknown.

During normal winter operation with the heater in use, the center console area becomes excessively hot. I have measured surface temperatures exceeding approximately 130°F using an infrared thermometer. The affected area includes interior touch surfaces, cup holders, and a factory-installed wireless phone charging pad. The heat appears to originate from HVAC ducting routed through the center console to supply the rear seat vents. Closing the rear vents does not reduce the console temperature, indicating heat transfer through the ducting rather than airflow. The condition is most severe after a warm-soak cycle (driving to operating temperature, briefly parking, then driving again). When a phone is placed in the intended storage or wireless charging area, the device overheats and triggers thermal protection warnings. The console surfaces also become hot enough to present a potential burn risk with prolonged skin contact. These temperatures exceed recommended ambient conditions for consumer electronics and lithium-ion batteries in a normal-use interior storage and charging location. The issue was reported to a Hyundai dealership. The service department stated the heat was caused by the rear HVAC duct and considered the condition “normal.” No repair, insulation review, or corrective action was offered, and no specific temperature measurements were provided in writing. Hyundai Consumer Affairs directed me to return to the same service department, despite the concern remaining unresolved. This condition occurs during normal vehicle operation and represents a potential interior thermal safety concern.

I’ve been driving this car for nearly a year, and during that time I’ve had multiple incidents where the Forward Collision-Avoidance system applied sudden hard braking when it wasn’t necessary, creating dangerous situations. I don't think I will be fortunate every time. I believe there is a serious issue with how the Hyundai's FCA system is operating and it needs to be investigated as a priority. Currently I am driving with it turned off every time I start the car. On my research I found this issue has been reported by multiple other drivers as well and I don't see any acknowledgement or reference from Hyundai on this so far.

The contact owns a 2025 Hyundai Tucson. The contact stated that while his wife was driving at various speeds, the imminent crash braking failed to function as intended. The first time that the failure occurred, the contact's wife was driving in the rain, and a beeping sound was coming from the vehicle, and the vehicle stopped independently. The vehicle returned to normal functionality after several minutes. The contact stated that on a separate occasion, while his wife was driving in slow traffic, there was an abnormal beeping sound coming from the vehicle before the vehicle independently stopped. No warning lights were illuminated. The vehicle returned to normal functionality minutes later; however, the failure persisted. The vehicle was not taken to the dealer or an independent mechanic, and the vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 1,000.

engine RPMs surged and the car accelerated forward without foot on the gas pedal concerned about possible pedestrian accident or collision with objects and prop. damage. dealer was unable to duplicate the problem and no repair was made there is no warning...I never know when it will happen and it has occurred in a number of different circumstances

Hard braking first occurred on a major highway with no prior notice that this would happen in close call accidents. The cars traffic had to veer away from me in order to avoid hitting me. Another highway (95) incident was a 18 wheel semi that had to move to the shoulder and could have easily totaled my car and me. I then researched this and found I could delay the action be setting the Forward Collision-Avoidance Assist mode to "Late". This helped in giving notice for some time, however the hard braking occurred again on a regular two lane small highway as I switched lanes, saw a car stopping suddenly and the brakes locked up. (This is the latest incident as dated below). There was no "Late" warning, the brakes just locked up. Being in fear of my and my families life I did further research and found that I could disable "brake assist" and only get warnings - which is what should be the default - BUT, this must be done each time I start the car. If my wife drives and forgets to do this each time I now fear for her life!!! This is not a simple matter. It is unconscionable and horrible this type of control over basic transportation is allowed to exist. This must be addressed and corrected! I'm all in on helping make meaningful change to this issue.