2025 Hyundai Tucson

The Automatic Emergency Braking and Forward Collision Warning systems activated while making a left turn after stopping for a red traffic light and locked the brakes of the vehicle in the middle of the intersection with no other car in front of me. Dash alerted that a collision was going to occur. This was the second time. The first time it happened the dealer said it can happen if there is a bug or dirt on the sensor in the bumper or dirty windshield by the camera, they even said it can happen with glare from the sun or light glare.

On two occasions, the automatic emergency braking system engaged potentially causing an accident. The first occurred at an intersection where I was attempting to turn left from a stop. The system would not allow me to proceed until the bus attempting an opposite left turn left the intersection. The weather was clear and sunny. The second occurred while on a freeway onramp. There were no vehicles in front or to my side. The AEB detected a phantom threat and immediately braked to a stop. The car behind me was barely able to avoid rear ending my vehicle. My passenger was a witness to this jarring event. The weather was clear and sunny. Both incidents occurred with an odometer reading of <3500 miles. My local Hyundai dealer has attempted to recreate the phantom breaking, but were not able to recreate the circumstances and therefore not know what system required repair/replacement. The case #42211163 was assigned. Given the uncertainty of when the system will inadvertently break and the inability to permanently turn off AEB on this vehicle, I am very concerned about driving the vehicle.

Subject: 2025 Hyundai Tucson - Persistent Phantom Braking Issue I am reporting a severe safety defect regarding the Forward Collision-Avoidance Assist (FCA) system on my 2025 Hyundai Tucson. Since purchasing the vehicle, I have experienced five separate "Phantom Braking" incidents where the Automatic Emergency Braking (AEB) engaged abruptly without any obstacles in the path. In the most recent incident, the vehicle suddenly braked from 30 mph to 20 mph] while driving on a highway. There were no cars or objects in front of me. This unpredictable behavior is extremely dangerous as it almost caused a rear-end collision with trailing vehicles. I believe this is a systemic software or sensor defect that misinterprets shadows or road signs as hazards. I request a formal investigation into this safety risk.

My wife was driving our Hyundai Tucson on the city street at about 35 mph. She signaled left to get into a turning lane. The turning lane has two lanes and is very long. She got into the turning lane and the traffic in front of her stopped. The car's collision avoidance system activated and slammed on the brakes even though the vehicle was not very close to the cars in front of her. As a result, a vehicle behind her rear ended her causing over $9,000 in damage. This car has done this before on the highway and city street. The collision sensitivity setting was on normal and had been since we got the car and until the accident. I had also been driving the car when the collision avoidance activated. The problem with this car is that it only knows to slam on the brakes and results in getting rear ended. It does not gradually apply the brakes even when the car in front is not very close and locking up the brakes is not necessary and is actually unsafe as shown when my wife was in a rear collision accident. This is a major safety problem and needs to be looked into.

The contact owns a 2025 Hyundai Tucson. The contact stated that the vehicle was stopped at a traffic light, while attempting to accelerate, the brakes engaged unexpectedly. On another occasion, while driving approximately 60 MPH, the brakes unexpectedly engaged without driver input and failed to properly respond for approximately 5 to 10 seconds. There was no warning light illuminated. The vehicle resumed normal operation afterwards. The Forward Collision Avoidance early detection sensor indicator was illuminated. The vehicle was towed to the dealer; however, the technician was unable to duplicate the failure. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 14,946.

The contact owns a 2025 Hyundai Tucson. The contact stated that the Forward Attention Warning (FAW) system had failed to detect the driver's eyes while wearing sunglasses, causing the cruise control to disengage unintendedly. Several messages advising the driver to pay attention to the road were displayed. The contact stated that the failure also occurred while wearing prescription glasses and while the driver was not wearing glasses. The vehicle was taken to the dealer, where the contact was informed that the system could not be disabled because the manufacturer considered it a safety feature. The dealer informed the contact that a software update was previously performed over-the-air to correct the issue; however, the failure persisted. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was approximately 800.

On at least three occasions, the emergency braking system has engaged when there was no risk of a collision. The vehicle ahead was moving forward and was a safe distance ahead. This has occurred even when the forward collision system is set to "Late." When the emergency braking system engaged, it stopped the vehicle with such force that it threw items in the back seat forward into the foot well and was very jarring for me, the driver. This has made me anxious when driving the vehicle and is very frustrating.

I was driving on the highway in heavy traffic going about 65 mph. An unusual symbol appeared on the dash in red that I don't know what It was or what it meant but I thought it must be something serious. Then a warning came up saying for me to take a break. Then a different warning came up saying that I should take control of the car immediately, it was about to brake. The car immediately began to brake. Fortunately I was in the right hand lane of the three-lane highway and I was able to pull into the breakdown lane. I can't even imagine what would have happened if I was in the middle or far left lane. I was not unobservant and both of my hands were on the steering wheel when this happened. Once the vehicle stopped, the symbol on the dash disappeared and the brakes released. I was able to resume driving. Although there was no accident, injury or fire, and no police report needed, this does not discount the seriousness of this event. This could have been life-threatening if I had been in a different lane or had panicked, causing a multi car pileup in the heavy traffic. Serious enough that I feel the need to get rid of this car.

Sometimes in heavy rain, using the washer fluid or bright sunlight I get an alert that the Foward Collision Avoidance sensor disabled. Usually doesn’t last long unless there is heavy rain. This system shouldn’t be triggered by things that happen frequently. This isn’t an issue in my Santa Fe. The only time that sensor is inoperable is in very heavy snow that has covered the front of the vehicle

Over the past four days, my vehicle has repeatedly applied braking unexpectedly without a valid obstacle or need to brake. This has occurred multiple times under normal driving conditions, including: Twice on the freeway in stop-and-go traffic with vehicles at a safe distance ahead Multiple times on regular city streets with vehicles ahead at approximately 15–20 feet Once while turning into my driveway as my garage door was opening In one instance on the freeway, a vehicle behind me nearly collided due to the sudden unexpected braking. The Forward Collision-Avoidance Assist (Automatic Emergency Braking) system is set to “Late,” yet the vehicle still applies braking unnecessarily. This behavior did not occur previously and has started happening repeatedly within the past four days. This creates a significant safety risk, particularly in traffic where unexpected braking can cause rear-end collisions. The vehicle has approximately 1050 miles and has not been modified. The issue is currently being evaluated by a Hyundai dealership and has been reported to Hyundai Motor America under an open case.