IllustrationHigh pressure fuel injectors went out.
2022 Hyundai Tucson
Owner reports · Recalls · Investigations
More warning signs than most Tucson years
Owner complaints for the 2022 Hyundai Tucson are substantially higher than the model-year median of 180.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Tucson years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 43 of 381 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel/propulsion System. Review the 131 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 115 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 63 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
25 crash reports4 fire reports10 injury reports
Fuel/propulsion System complaints
131 reportsBought the 2022 Hyundai Tucson. It was driving perfect no issues then I hit 52,000 miles and the check engine light illuminated. The vehicle started sputtering and idling hard like it wasn’t getting fuel when the gas was pressed. I was on the interstate and the vehicle wouldn’t go over 35mph. Now the check engine light illumina…
Read full complaint
Bought the 2022 Hyundai Tucson. It was driving perfect no issues then I hit 52,000 miles and the check engine light illuminated. The vehicle started sputtering and idling hard like it wasn’t getting fuel when the gas was pressed. I was on the interstate and the vehicle wouldn’t go over 35mph. Now the check engine light illuminates off and on when it feels like it.
This vehicle has a considerate amount of oil dilution problems. I have had this vehicle taken in for service several times due to gasoline mixed into the engine oil. Again on March 6 2026 for the 4th time now the vehicle has a check engine light extreme hesitation with an almost stopping jerking motion due to dilution problems. …
Read full complaint
This vehicle has a considerate amount of oil dilution problems. I have had this vehicle taken in for service several times due to gasoline mixed into the engine oil. Again on March 6 2026 for the 4th time now the vehicle has a check engine light extreme hesitation with an almost stopping jerking motion due to dilution problems. Multiple dealerships claim there is nothing wrong with the car.. there is a distinct gasoline smell in the engine oil. The vehicle at times is almost unsafe to drive due to the hesitation and halting it does on its own. Every time a dealership is contacted my problem is dismissed. There is a burning smell due to the oil gas dilution issue. The car reaches higher temperatures than it should. And now the Hyundai dealership is making me wait almost a month again to have the problem looked at again which then puts me as the driver in an unsafe situation to drive a vehicle with such hesitation and fire risk. If they dismiss this oil and gas mix again and do not repair the car it could seize my engine or maybe possibly even cause fire damage.
engine light #2 GDI injector at 60,900 miles been repaired but not under warranty out at 60,000 miles
We brought our 2022 Hyundai Tucson into our local Hyundai dealership under warranty for Technical Service Bulletin MISFIRE DTC (P030X) – INTERNAL GDI INJECTOR LEAK REPAIR. We were surprised to learn the dealership did not have the parts in stock considering this is a widely known issue and we incurred significant expenses while…
Read full complaint
We brought our 2022 Hyundai Tucson into our local Hyundai dealership under warranty for Technical Service Bulletin MISFIRE DTC (P030X) – INTERNAL GDI INJECTOR LEAK REPAIR. We were surprised to learn the dealership did not have the parts in stock considering this is a widely known issue and we incurred significant expenses while waiting for the vehicle to be repaired. Expenses incurred: $211.47 for Enterprise car rental (2026 Hyundai Sonata) from 1/19/26 to 1/23/26 $140.00 to have the vehicle towed to the dealership since it could not be driven $18.14 for Uber to local rental car agency Total out-of-pocket expenses: $369.61 All documentation was presented to Hyundai corporate, but we have been waiting 3 weeks and the company has not reimbursed or provided any update. On a related note, to avoid the inconvenience of having to bring our vehicle in again for another known issue, we asked if the current recall on our vehicle could be completed while our car was in the shop for the week, but we were advised that our vehicle did not have any recalls. However, according to NHTSA.gov, there is an existing safety recall that was issued more than 2 months ago on December 19, 2025 (NHTSA Safety Issue ID #25V893000 / Hyundai recall #290). The fact that we were told there were no recalls on our vehicle is unsettling and this experience has us seriously reconsidering if we will be purchasing another Hyundai again.
When getting onto the highway on November 30, 2025, the engine on my 2022 Hyundai Tucson made an odd sound, acceleration was compromised and the check engine light came on. My husband was driving and he safely navigated us off the highway and back to our home via city streets. We were very concerned we were going to break down o…
Read full complaint
When getting onto the highway on November 30, 2025, the engine on my 2022 Hyundai Tucson made an odd sound, acceleration was compromised and the check engine light came on. My husband was driving and he safely navigated us off the highway and back to our home via city streets. We were very concerned we were going to break down on the highway or city street during a cold time of year. The next day we had the vehicle towed to a local auto service center and they diagnosed the problem as a failed fuel injector. They stated this was a known issue by Hyundai. The auto service center ordered the fuel injector kit to make the repair, but they were only allowed to repair the failed fuel injector, not all of them. I'm concerned another fuel injector will fail. If Hyundai knows about the fuel injector issue why haven't they issued a recall?
I have had numerous issues with fuel Injectors failing. The first incident was about 30,000 miles. This was fixed by the manufacturer not even 10,000 miles later, I once again had to return the vehicle, to be inspected by the dealership. Instead of replacing all of the fuel injectors at the same time they chose to only replace o…
Read full complaint
I have had numerous issues with fuel Injectors failing. The first incident was about 30,000 miles. This was fixed by the manufacturer not even 10,000 miles later, I once again had to return the vehicle, to be inspected by the dealership. Instead of replacing all of the fuel injectors at the same time they chose to only replace one. As soon as my car went over the 80,000 mile warranty limit, my fuel injectors went out once more. My mechanic son, has also changed several as well. I had to tow it, 100 miles to the Hyundai dealership, as I live in a rural area. I was told by a young lady, at the dealership, that it was be covered under the engine warranty, which is 100,000 miles. They weren’t even able to look at the car for a week charged me $250 for a diagnosis… After a week 1/2 dealership finally told me it would be over $3000 to repair.. NO! I had to pay to tow it back. I’ve been without a vehicle for five months. When the fuel injectors went out, it also damaged the high-pressure fuel rail, the high pressure fuel pump, and various sensors. This is dangerous, I live in a very rural area. It stopped operating out of the blue. It chugged/bumped a few times, and it was dead. This is inconvenient, and It’s dangerous, especially during the winter time where temperatures reach -20 regularly and no cell phone signals. I believe Hyundai is well aware, of the problem. In fact the service manager had mentioned that the parts were on backorder because apparently they are in quite high demand. No fuel injector should be going out in 15,000 or 20,000 miles, causing systemic failure. Hundai has made no effort to redesign failed parts. It’s quite disheartening, to replace/repair with a new defective part. That is going to go bad, in just a few thousand miles!! Im retired, on a fixed income. I bought new, so I wouldn’t have issues. Paying new prices, to drive junk. I’d just drop it off @ dealers, and walk away.. But the loan, is so upside down that isn’t even possible.
The fuel door would not open, preventing me from refueling the vehicle. I had to purchase a new fuel door actuator and have the vehicle towed to a repair shop, which caused a significant inconvenience.
The fuell door will not open on the vehicle, and I am not able to put gas in the vehicle. Have taken it to a mechanic and he is unsure of what is going on. For a 2022 Vehicle this seems very odd.
The fuel injectors in the car keep misfiring causing the car to shake while driving, be loud and idle hard. In the past I have already replaced two different fuel injectors and now this is a third one that needs replaced.
Official recalls
325V893000 · Trailer Hitches
Dec 18, 2025
Hyundai Motor America (Hyundai) is recalling certain 2022-2024 Tucson vehicles equipped with an optional Mobis tow hitch wiring harness. The wiring harness may have been installed incorrectly, allowing water into the control module. Moisture accumulation may cause the trailer lighting to fail or an electrical short circuit.
Consequence & remedy
Consequence: Nonfunctioning trailer lights can increase the risk of a crash. A short circuit can increase the risk of a fire.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will remove the trailer wiring harness and install a dust cap over the wiring receptacle, free of charge. Owner notification letters were mailed May 11, 2026. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 290. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on December 20, 2025.
23V038000 · Structure:body:roof And Pillars; Structure:critical Fasteners
Jan 31, 2023
Hyundai Motor America (Hyundai) is recalling certain 2022 Tucson and 2022-2023 Santa Cruz vehicles. The roof moldings may detach.
Consequence & remedy
Consequence: A detached roof molding could become a road hazard, increasing the risk of a crash.
Remedy: Dealers will inspect and replace, or secure the roof moldings, as necessary, free of charge. Owner notification letters were mailed March 30, 2023. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 241.
Additional source detail variants (2)
Structure:critical Fasteners
Hyundai Motor America (Hyundai) is recalling certain 2022 Tucson and 2022-2023 Santa Cruz vehicles. The roof moldings may detach.
Consequence: A detached roof molding could become a road hazard, increasing the risk of a crash.
Remedy: Dealers will inspect and replace, or secure the roof moldings, as necessary, free of charge. Owner notification letters were mailed March 30, 2023. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 241.
Structure:body:roof And Pillars
Hyundai Motor America (Hyundai) is recalling certain 2022 Tucson and 2022-2023 Santa Cruz vehicles. The roof moldings may detach.
Consequence: A detached roof molding could become a road hazard, increasing the risk of a crash.
Remedy: Dealers will inspect and replace, or secure the roof moldings, as necessary, free of charge. Owner notification letters were mailed March 30, 2023. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 241.
21V938000 · Electrical System:software; Exterior Lighting
Dec 2, 2021
Hyundai Motor America (Hyundai) is recalling certain 2022 Tucson vehicles. The software installed in the Integrated Central Control Unit (ICU) may be incompatible with the vehicle, which could result in inoperative headlights and/or taillights.
Consequence & remedy
Consequence: Inoperative headlights or taillights can decrease visibility for both the driver and surrounding traffic, increasing the risk of a crash.
Remedy: Dealers updated the ICU software, free of charge. All affected vehicles have been repaired and therefore no owner notification letters will be mailed. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 214.
Additional source detail variants (2)
Electrical System:software
Hyundai Motor America (Hyundai) is recalling certain 2022 Tucson vehicles. The software installed in the Integrated Central Control Unit (ICU) may be incompatible with the vehicle, which could result in inoperative headlights and/or taillights.
Consequence: Inoperative headlights or taillights can decrease visibility for both the driver and surrounding traffic, increasing the risk of a crash.
Remedy: Dealers updated the ICU software, free of charge. All affected vehicles have been repaired and therefore no owner notification letters will be mailed. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 214.
Exterior Lighting
Hyundai Motor America (Hyundai) is recalling certain 2022 Tucson vehicles. The software installed in the Integrated Central Control Unit (ICU) may be incompatible with the vehicle, which could result in inoperative headlights and/or taillights.
Consequence: Inoperative headlights or taillights can decrease visibility for both the driver and surrounding traffic, increasing the risk of a crash.
Remedy: Dealers updated the ICU software, free of charge. All affected vehicles have been repaired and therefore no owner notification letters will be mailed. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 214.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP22003 · Loss Of Motive Power
Opened Sep 12, 2022 · Closed Dec 12, 2023
Status: closed (inferred from source dates) · Engine
The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at NHTSA.gov under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitioners’ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODI’s evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to NHTSA which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing. There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in NHTSA's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, NHTSA does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA’s reasons for denial of the petition will be published. The reference numbers for the complaints to NHTSA cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.