2021 Hyundai Tucson

My family’s safety is at serious risk with my 2021 Hyundai Tucson, which I’ve owned only 55 days. This vehicle has stalled three times while driving, putting me and my two young children in immediate danger. Each time, the car operated normally until a flashing engine light appeared, RPMs spiked, and the vehicle suddenly lost all power—entering “limp mode” and unable to exceed 3,000 RPM or 50 MPH. The first failure occurred 9/14/25 while merging onto the interstate, forcing me to lose power mid-acceleration as surrounding vehicles slammed their brakes to avoid collision. 13 days later, it happened again in stop-and-go traffic, leaving me stranded on the shoulder. Both incidents occurred without warning or prior check-engine lights. The third—and most terrifying—incident was on October 17, 2025, when the engine completely died 300 miles from home on a busy highway. My children, ages 4 and 6, were terrified as cars sped by. We were extremely fortunate not to have been hit. I am urgently requesting assistance for the immediate replacement of this vehicle’s engine. It is covered by Hyundai’s 15-year/150,000-mile extended warranty, clear evidence the company was aware of these issues. Service records from the previous owner-that I was told about by Hyundai show ongoing engine problems and recalls since 2022 further proof this vehicle should have been retired from service As a parent, I’m very alarmed that Hyundai refuses to act until “catastrophic damage” occurs. This policy is irresponsible and endangers entire families. There’s at least 50 NHTSA complaints describing identical issues; stalling, power loss, and bearing failure linked to defective connecting rod bearings. Yet, Hyundai has denied a replacement, insisting on waiting for further damage and failures in operation. I beg you to intervene and prioritize my family’s safety before tragedy inevitably strikes. My children should not be put at risk due to corporate negligence, greed and absence of accountability.

I was trying to defrost my windows and my air was on so I clicked the air off so the heat could come on and I started smelling a matalicky smell. I drove to a stop light and when I stopped the back windshield popped and then shattered. I then went to drive again to take the car home and I started to see smoke. Once the light changed I continued to drive to get the car home I happened to look through the rear view mirror and saw fire in the trunk , once I saw the fire I pulled over on a street and stopped the car and then all the sirens in the car started going off so I turned the car off got out and called 911.

While driving on the freeway my sunroof suddenly imploded sending glass everywhere. No warning whatsoever it was like a bomb went off out of nowhere. Nothing hit the car and temps were not high and it just imploded This is a serious matter and extremely dangerous. The pain and ringing in my ears is awful, glass went all over this is serious issue that can cause death and injury

On [XXX], the vehicle was involved in a complex multi-impact accident. It was struck by a vehicle on the passenger (right) side and, simultaneously, by another vehicle on the driver's (left) side. (Police Report). During this sequence of collisions, and despite the magnitude of the impact, I must express my extreme concern that the left side airbag (driver's side) did not deploy. This failure caused Mr. [XXX] , the undersigned, to suffer a neck injury as a direct consequence of the incident. Even more seriously, the right-side passenger, Ms. [XXX] , sufferedsevere internal injuries, including three small intestine perforations, according to medical reports. These injuries resulted from improper pressure or malfunction of the seatbelt for that seat. These combined failures, the non-deployment of an essential airbag in impact, and the serious internal injuries caused by the seatbelt represent unacceptable deficiencies in the vehicle's safety systems. We believe that these injuries could have been avoided or mitigated if the safety components had functioned properly, as expected in an accident situation of this magnitude. Therefore, I am at a loss to understand: 1. Why the left side airbag did not deploy during the impact. 2. Why the right passenger seatbelt caused such serious internal injuries, including the three diagnosed intestinal perforations. We also require that concrete and immediate action be taken to address and compensate for the serious injuries suffered by the vehicle's occupants, as this has caused psychological and work- related harm. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2021 Hyundai Tucson. The contact stated that while driving 35-45 MPH, the vehicle shut off unexpectedly. There was an abnormal rattling sound coming from the vehicle. Additionally, the contact stated that the vehicle failed to accelerate while driving. There were no warning lights illuminated. The vehicle was taken to the local dealer where it was diagnosed that the rod bearing and the engine needed to be replaced. The vehicle was repaired; however, the failure recurred. The vehicle was taken to another local dealer, Hyundai of Orange Park (7600 Blanding Blvd, Jacksonville, FL 32244); who determined that the coils needed to be replaced. The vehicle was not repaired. The vehicle was taken to an independent mechanic who replaced the coils and determined the failure was due to the engine. The vehicle was repaired, but the failure reoccurred. The manufacturer was contacted, but no additional assistance was provided. The failure mileage was approximately 124,500.

When sitting at a stop and then accelerating to leave the stop position, the car will go and then all of a sudden it will stall out and I'm pressing the gas pedal, pressing the gas pedal quite a few times before the car even decides to move. This happens when I'm changing lanes on the highway... merging onto the highway... when I'm leaving from a stop sign or a stoplight it happens continuously. It is very dangerous and it can cause a very bad accident....this has been an issue since I had bought the car 3 years ago...it seems to be happening more frequent