2021 Hyundai Tucson

My car is burning oil. I have returned multiple times to have it serviced and checked for leaks, but no leaks have been found. Before reaching the recommended 3,000-mile oil change interval, the oil level drops below the minimum mark on the dipstick. In addition, my engine has started making a knocking noise, which is very concerning.

Vehicle stalled approximately 15 times between April 17 and May 4, 2026, including once on Interstate XXX at approximately 50mph with minor children ages [XXX] and [XXX] in the vehicle. The oil and battery lights illuminated simultaneously at each stall. Diagnosed as ABS module failure first, then left front wheel speed sensor failure on the 2nd occasion, both confirmed by a Hyundai dealership. Multiple warning lights illuminated, including check blind spot and anti lock brake system messages on the dashboard BUT no error codes following the 2nd repair. The vehicle has been inspected and repaired twice by the manufacturer’s dealership with a 3rd repair currently pending as of May 11, 2026. An open case has been filed with Hyundai Motor America regarding this issue. Issue remains unresolved and the vehicle is still at the dealership. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My 2021 Hyundai Tucson has experienced repeated engine-related failures associated with a knock sensor (P1326) fault that causes the vehicle to enter limp mode and lose power while driving. This issue has occurred multiple times at approximately 15,000, 17,000, 41,000, and 90,000 miles and has resulted in four separate incidents requiring towing. During these events, the vehicle suddenly loses power and cannot maintain normal driving speed, creating a hazardous condition while in traffic. The vehicle has undergone multiple repair attempts, including an ECM update and three knock sensor replacements. Despite these repairs, the issue continues to recur and no root cause has been identified. Hyundai has not provided a permanent fix and has advised continued operation of the vehicle unless the issue occurs again. This ongoing condition presents a safety concern due to the risk of sudden loss of power while driving.

In October 2025, while the vehicle was still under Hyundai’s 5-year warranty, an authorized Hyundai dealership diagnosed a significant electrical failure affecting the ABS/ESC system on my 2021 Hyundai Tucson. The vehicle was experiencing multiple dashboard warning lights, intermittent key fob malfunction, alarm system failure, and progressive electrical instability affecting safe operation. Dealer diagnostic trouble codes included C120001, C167581, and C164202, with technician notes stating “ABS sensor wiring harness fault found.” The dealership recommended replacement of the wiring harness, estimated at approximately $12,000, but no warranty repair was performed. Since the initial diagnosis, the condition has continued to worsen with additional warning lights and ongoing ABS/electrical system instability. The issue remains unresolved and continues to affect vehicle safety.

The contact owns a 2021 Hyundai Tucson. The contact stated that while driving at various speeds, the check engine warning light was frequently illuminated on the instrument panel. The contact had taken the vehicle to various independent mechanics and was informed that the engine was consuming an excessive amount of engine oil. The contact had taken the vehicle to a dealer for service, and upon inspection, the contact was informed that the engine needed to be replaced. The contact was provided with an estimate for the engine replacement. The manufacturer was notified of the failure but offered no assistance. The contact was initially informed that the vehicle was covered under warranty; however, the contact was later informed that there was no warranty on the vehicle. The vehicle was not yet repaired. The failure mileage was approximately 89,000.

While driving on the freeway, my 2021 Hyundai Tucson SE (72,021 miles) suddenly and without warning lost power and entered limp mode. I was able to safely maneuver to the shoulder and exit the freeway. The check engine light came on and is currently flashing. I took the vehicle to AutoZone where code P1326 was retrieved. I then took it to Pep Boys for a full diagnostic where P1326 was the only code present. The Pep Boys report states the vehicle requires immediate attention. The vehicle remains in limp mode and the check engine light is flashing. The vehicle is not being driven as it cannot safely reach freeway speeds. I contacted Hyundai Customer Care and was assigned Case # XXX. I also contacted a Hyundai dealership who attempted to charge a $225 diagnostic fee despite P1326 being a known Hyundai defect covered under recall/service campaign. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The vehicle experienced a catalytic converter efficiency failure that was confirmed by an authorized dealership in January 2025. The dealer indicated the catalytic converter required replacement; however, the replacement was not performed, and the vehicle was returned to service with an unresolved emissions defect. Less than one year later, the vehicle developed recurring emissions system failure, loss of power, drivability issues, and repeated warning indicators. The vehicle is currently out of service while additional components, including oxygen sensors and spark plugs, are reported to be affected. The manufacturer is declining to replace the catalytic converter and is attributing the condition to oil consumption despite the prior unresolved emissions failure. The issue has been confirmed by dealership diagnostics and has resulted in prolonged loss of use of the vehicle. This appears to be a continuing engine and exhaust/emissions system defect that was not properly remedied when first identified and may affect safe operation of the vehicle.