2022 Hyundai Tucson Hybrid

System/Component Failed & Inspection: The vehicle suffers from recurring failures across the engine, powertrain, electronic throttle control, and exhaust gas recirculation (EGR) control systems (DTCs P0524, P0642, P2118, P022100). The vehicle is fully available for inspection upon request. Safety Risk: While driving, the vehicle suffered a complete, sudden loss of motive power on an active highway entrance ramp. The engine stalled in moving traffic with zero throttle response, creating an immediate collision hazard before requiring a tow. Confirmation by Dealer: Technicians formally confirmed these defect patterns. In May 2026, diagnostics logged major engine and emission/EGR control codes, but corporate refused goodwill repair. In August 2026, the highway stall recurred. Diagnostics confirmed active low oil pressure and throttle failure codes, which the dealer resolved by applying 4 factory ECU software updates under TSB 25-01-010H. Service personnel explicitly confirmed these engine control issues are manufacturing defects, not wear-and-tear or mileage-related. Inspections: Inspected, diagnosed, and serviced by authorized dealership service department technicians during both the May and August 2026 failure events. Warning Symptoms & History: Engine issues began at 341 miles when purchased new (settled). In May 2026, check engine lights returned with diagnostic codes for engine and EGR/emissions systems. In August 2026, total power loss occurred, preceded by check engine, forward collision camera, and radar sensor warnings.

Speed control on steering wheel not responding all the time. When car is on cruise control speed instead or decrease control not responding all the time. I was almost going to hit the vehicle on high way i decreased the speed according to front of my car but controller not responding speed didn't decreased I suddenly realized that slammed on break. Nothing was happened i already sent email to hyundai but no respond. I looks defective controller switch. Now other side of steering volume control switch also becomes loose

A week ago, I was driving my 2022 Tucson Hybrid Limited on the highway on my way to work around 7:50 a.m. It was a bright day, good weather. I was in the center lane when my car suddenly braked HARD and came to a stop on the highway! My foot was still on the gas pedal, but the Automatic Emergency Braking light was on. I panicked because I had no control over what the car was doing. Thankfully, I was not rear-ended and didn't cause an accident. I put on my hazard lights, shifted into park on the highway's center lane, then back into drive and it seemed fine. There was not really any traffic in front of me that I remember, but there were some cars on either side and behind me that had to swerve around me. I don't trust this car anymore. It is going to get me or someone else killed. I took it to the dealer 2 days ago and the initial inspection didn't show any problems or error codes. They told me I could have it back since there didn't seem to be a problem or they could give me a loaner car and keep testing my car. I have a loaner. I hope they find something wrong with the car, otherwise, I am afraid of my car getting me or someone else killed. I am especially scared after reading about all the others here who have had this same issue.

Driving at night when it snows is unsafe. The forward collision warning sensor is covered with snow within minutes and so are the headlights. They are placed in the front bumper and covered with snow because by their design they are not flush with the bumper. They are sitting deep within the bumper which creates a trap for snow and slush. I hade to stop every few minutes to clean the headlights from snow because they were covered and I couldn’t see anything in front. It’s a design flaw.

Driving interstate right lane cruise control set at 73 mph. Car in front of me proceeded to leave lane to the left in order to pass 18 wheeler in front of it. Noticed my car felt different at that time and looked at dashboard to see cruise control now set to 110 mph and speed almost 90 mph. Documented with photo. Disabled cruise with breaking. Shared this on Tucson forums Reddit and Hyundai Forums with confirmation that this has and is happening.

The contact owns a 2022 Hyundai Tucson. The contact stated that while driving at various speeds with the Collision Avoidance System (CAS) engaged, the vehicle would abruptly stop. Additionally, the vehicle also jerked to the right or to the left. Additionally, the instrument panel, gauges, and the radio unit went black. The contact stated that the wheel was firmly gripped, and the vehicle veered to the side of the road. The contact also stated that although the Collision Avoidance System (CAS) had been disabled the feature automatically reactivated. The vehicle was taken to the dealer but was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 500.