2020 Hyundai Sonata

On 2/19/2026 while driving, my 2020 Hyundai Sonata Limited 1.6T began making several loud explosive / popping sounds. At the same time, the fuel gauge on the display screen appeared to rapidly drop, as if the vehicle was losing gas. Immediately following this, the vehicle began to hesitate and lose power while accelerating. The hesitation felt like the engine was misfiring or struggling to maintain consistent performance. There were multiple explosive sounds before and during the hesitation. This created a major safety concern while driving and the vehicle underwent an inspection at Hyundai in Deland, FL. The service department was brief and stated they needed to keep the vehicle for repair for an unknown amount of time as the fuel tank expanded. No further information was provided at that time.

The contact owns a 2020 Hyundai Sonata. The contact received notification of NHTSA Campaign Number: 25V796000 (FUEL SYSTEM, GASOLINE); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

The contact owns a 2020 Hyundai Sonata. The contact stated that while attempting to start the vehicle, the vehicle failed to start. The battery and the key warning lights were illuminated. The contact stated that after several attempts, the vehicle started. The vehicle was driven to the end of the driveway and turned off. The contact was afraid of driving the vehicle due to the failure. The independent mechanic was made aware of the failure. The contact was informed of an open recall. The dealer was made aware of the failure and confirmed the open recall information. In addition, the contact was advised that the failure might be because of the unrepaired recall. The contact was advised to bring the vehicle in for diagnostic testing. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact received notification of NHTSA Campaign Number: 25V796000 (Fuel System, Gasoline); however, parts for the recall repair were not yet available. The failure mileage was approximately 42,947.

My vehicle was at a manufacturer‑authorized dealership for a federally mandated recall repair. While the vehicle was in the dealership’s exclusive care, custody, and control, it was struck by a third‑party cleaning vendor operating on dealership property and was declared a total loss. I did not hire or authorize this vendor. After the incident, the manufacturer informed me in writing that the dealership would repair the damage at their own expense, separate from the recall work. The manufacturer also stated they were covering the recall‑related repairs and were coordinating with the dealership. They provided weekly updates, monitored the recall repair, and escalated a backordered recall part. Later, after the dealership confirmed the vehicle was a total loss, the manufacturer reversed its position and stated it was “not involved.” The dealership has refused to identify the cleaning company responsible for the loss, their insurer, or any claim information, preventing any direct follow‑up. The manufacturer continues to direct me to “work with the parties involved,” even though the responsible vendor has not been disclosed. This raises concerns about the safety and oversight of the recall repair process, the handling of vehicles during recall service, and the manufacturer’s response when a vehicle is destroyed during a recall procedure.

I have taken my vehicle to a certified Hyundai dealership multiple times due to intermittent starting issues. The car will unlock remotely, and the lights and electrical components will turn on, but the engine will not start. When this happens, I press the ignition button to turn the vehicle off and then try again. Sometimes it eventually starts, but there have been several occasions when it would not start at all, forcing me to call for a tow or have the battery jumped. This issue occurs most often in cool or cold weather. I had a brand new battery installed at the dealership in July 2025, yet the problem has continued. I have been dealing with this for over a year and have even been stranded out of state in below-freezing temperatures. Each time I bring the vehicle in, the dealership states they are unable to replicate the issue while it is in their service department.

While stopping at a major highway intersection on [XXX] for a red light vehicle stalls and will not start back up while everyone else continues at a 55 mph mile an hour passing me on each side! This happened more than 6 times . While you’re stuck in intersection,you have to keep trying to start the car eventually it will start . Apparently it is EGR valve and is a very common problem. IT IS NOTED IN THE common problem for this year making model and the repair cost is in the range of $1600 even the dealership said it is a very common problem. They have been experiencing it. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I own a 2020 Hyundai Sonata with factory-applied paint. The vehicle developed paint peeling/clear-coat failure on the driver-side rear quarter panel without any prior damage, accident, or repainting. The paint began separating from the body, exposing the underlying surface. I brought the vehicle to an authorized Hyundai dealer. The dealer acknowledged a paint adhesion failure and submitted the issue to Hyundai. Hyundai declined to fully cover the repair, stating the model year was not included in their paint warranty extension, even though similar peeling paint defects have been acknowledged and covered by Hyundai on earlier Sonata model years. The dealer ultimately repainted both rear panels due to the nature of the failure, but Hyundai required me to pay approximately 20% of the repair cost as a goodwill arrangement. I was not offered a full repaint or full reimbursement. I have also observed early signs of potential paint adhesion issues around the rear window frame, raising concern that the defect may progress to other areas of the vehicle. This appears to be a manufacturing paint adhesion defect rather than normal wear, and similar issues have been widely reported on Hyundai vehicles. I am reporting this issue to document a recurring paint adhesion defect on the 2020 Hyundai Sonata and to assist in identifying a potential pattern affecting additional vehicles.

My 202 Hyundai Sonata is involved in the current hyundai fuel system recall. on 10/26/25 the fuel tank expanded and caused three explosive "boom" sounds inside the vehicle while I was driving with passengers. The backseat began heating and rising upward due to fuel tank swelling. The tank became pressurized, hissing, bubbling, and would not accept fuel. The vehicle became inoperable. The car has now been at hyundai of camelback since 10/27/25 (30 days). Hyndai Corporate has repeatedly delayed providing a remedy and keeps telling me they "need another week". I have received no repair plan, and no decision. This violates the requirement for a timely recall remedy. The defect caused structural damage and created a serious safety hazard. "