2025 Hyundai Santa Fe

After waiting a month (called in june car went in 7/28/26)for an appointment with my dealer for 2 recalls and a broken rear seatbelt the dealership has deemed my vehicle unsafe to drive and has impounded my vehicle for almost a week. They have to replace not only 1 rear seatbelts but ALL rear seatbelts. The original recall is for the front seatbelt.

235/60R18 103H While driving the 1year old car, the tire pressure reading in the vehicle began to go down, upon exiting the vehicle it was determined that two holes blew through in the side wall of the tire. Thankfully, this was not as dangerous of a situation as it could’ve been as the car had just come off the highway and was traveling at a lower speed a residential neighborhood. The tire is not available, it was disposed at the place it was replaced at. There were no major tire stores open as it was a Sunday so it replacement tire had to be purchased from a local tire vendor.

I am submitting a second and more urgent safety complaint regarding the Driver Monitoring and Driver Assistance systems in my vehicle. I previously reported this same core defect: the system falsely fails to recognize my face, sounds repeated warnings, and disables driving assistance while the vehicle is moving. Despite that prior complaint, the defect remains, and the seriousness of the danger has clearly not been recognized or addressed. This defect has now placed my life in immediate danger. While I was driving, the system falsely determined that it could not properly see my face. It sounded repeated warnings and then abruptly disabled driving assistance. That sudden withdrawal of assistance created a near-crash situation. I was attentive and was not experiencing a medical emergency. The danger was created by the system’s false detection and defective response. A safety system should reduce danger. This system detected a supposed problem and made the situation more dangerous by removing the assistance that was helping keep the vehicle under control. Had this occurred beside a concrete barrier, near stopped traffic, in a construction zone, on a curve, or next to a large truck, the result could have been a fatal collision. I could have been killed because of this system defect. When a driver cannot be verified, the vehicle should maintain lane control, reduce speed, activate hazard warnings, and perform a controlled safe stop. It should never abruptly withdraw assistance and create a more dangerous condition. I request that NHTSA investigate why a previously reported life-threatening defect remains unresolved and require Hyundai to correct this system logic before someone is seriously injured or killed.

First tire blowout- 6/3/26- on Ohio turnpike tire just blew. No nails / no pothole/ no reason back passengers side Second tire blowout - 7/4/26 on laurel street Pittston ( paved road, hit small bump in road. Nothing unusual) tire just blew out. Front drivers side). No nails no reason) Third tire issue -7 /16/26 large bubble noticed on back drivers side . Going to try to drive it to get ANOTHER new tire. After investing this on the internet, this is a know problem with the pitelli scorpion tire on the calligraphy model. We were never notified . Recommendation in line is to Replace all 4 tires! We just patio 1300.00 for the other 2 new ones which are apparently not safe. We no have to get a tire We were lucky that the 2 blowouts did not cause us to get in an accident or cause injury to someone. It’s only a matter of time and hundai will have a major suit in their hands I am going to file a complaint with Hyundai and the attorney general and anyone else I can think of. People need to be warned and they need to pay for new tires tie me plus the ones I already replaced Ethan now need to get rid of. If you Google you will see this had been a known problem previously reported to Hyundai

While driving on the on ramp to [XXX] the car completely stopped and all systems shut off. There were two dash lights that flashed quickly with one being the check engine light but I did not see the other long enough to identify it. The dealership could not reproduce the issue but has the car now and is doing a more thorough evaluation. What component or system failed or malfunctioned, and is it available for inspection upon request? The engine stopped. Yes it is available How was your safety or the safety of others put at risk? Extremely dangerous as it came to a stop in the middle of the road. It was late at night so at that moment no one was behind me. Has the problem been reproduced or confirmed by a dealer or independent service center? no Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? no Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? no, the warning lights flashed on as the car died but disappeared once off. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

On [XXX] after spending the day at Henson Creek Golf Course in Fort Washington, MD, I returned to my vehicle and discovered that it had completely lost all electrical power and would not start. The vehicle exhibited no warning signs prior to the failure. Believing the issue to be related to the battery, I contacted AAA for roadside assistance. AAA attempted to jump-start the vehicle, but the jump-start was unsuccessful. The vehicle was subsequently towed on May 18, 2026, to Pohanka Hyundai in Capitol Heights, MD for diagnosis and repair. After approximately nine days, the dealership advised that the battery terminals had been secured and that no additional problem could be identified. On [XXX], the exact same issue occurred again; however, this incident was significantly more dangerous because it occurred while the vehicle was being driven. While traveling during morning rush hour through a busy intersection in Northeast Washington, DC, the vehicle suddenly and completely lost power without warning while in traffic. The vehicle stalled in the middle of the intersection, creating an extremely hazardous situation. Fortunately, motorists traveling behind me were able to stop in time, and no collision occurred. However, this incident could easily have resulted in a serious crash involving injuries or fatalities. The vehicle was towed to Ourisman Hyundai in Bowie, MD, where it is currently undergoing additional diagnosis. I am extremely concerned that this vehicle has experienced two complete electrical failures within approximately one month, including one incident that occurred while driving in heavy traffic. Because the dealership was unable to identify the root cause after the first incident, I am concerned that a serious defect may exist involving the vehicle's electrical system, battery system, wiring, power distribution system, or another component affecting vehicle operation and safety. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2025 Hyundai Santa Fe. The contact received notifications of NHTSA Campaign Number: 26V218000 (Seat Belts) and 25V659000 (Electrical System); however, the parts to do the recall repairs were not yet available. The local dealer was contacted; however, the recall repairs were denied due to a lack of maintenance records with an authorized Hyundai Dealer. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

On June 24, 2026, my spouse was operating our 2025 Hyundai Santa Fe when the vehicle suffered a sudden, catastrophic, and total electrical failure while actively on the roadway. The vehicle was stopped at a traffic light when all propulsion power was instantly lost, the engine shut down, and all electronic systems—including the center infotainment screens and instrument cluster—went completely dark. Safety Hazard & Entrapment Incident: Simultaneous with the total electrical failure, the vehicle's electronic door lock system malfunctioned. The rear passenger doors and rear liftgate locked completely and could not be disengaged or opened from the inside by the passengers. Due to this total power loss and lock failure, my young daughters were trapped in the rear seats. My spouse was forced to climb over the center console from the front seat into the rear cabin to manually extract our children through the front doors. The family had to abandon the disabled vehicle in live traffic and walk down the roadway to reach a safe location. This constitutes a severe safety hazard involving both sudden loss of motive power on a public road and occupant entrapment due to safety lock/latch failure during an electrical short. The vehicle has been towed to Pohanka Hyundai of Capitol Heights for inspection.

On 6/6/2026, my husband and I were driving on I70 west bound near the Golden CO exit. Out of nowhere, we heard a very loud pop sound and then heard wind over our head. The front sunroof spontaneously shattered. What component or system failed or malfunctioned, and is it available for inspection upon request? FRONT SUNROOF How was your safety or the safety of others put at risk? YES! Has the problem been reproduced or confirmed by a dealer or independent service center? YES Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? NO Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? NO! NOT A SINGLE WARNING, NOTHING!