2024 Hyundai Santa Fe

On November 18, 2025, at 24,370 miles, the vehicle suffered a catastrophic powertrain failure, triggering a dashboard warning: "Transmission system error! Check transmission oil immediately." The vehicle suffered a loss of reliable motive power. This sudden failure is a severe safety hazard that presents a high risk of stalling or stranding in active traffic, which is especially dangerous as this vehicle is used for a 40-mile round-trip school commute four days a week on local highways. The dealership replaced the transmission, keeping the vehicle out of service for 27 days. However, the exact same critical failure occurred a second time on December 24, 2025, at 24,878 miles. The vehicle was once again completely incapacitated and required a second transmission replacement as well as a new TCU, resulting in an additional 50 days out of service. Two catastrophic transmission failures within a 500-mile span on a brand new vehicle demonstrate a highly dangerous defect that puts the driver, passengers, and other motorists at unreasonable risk of a crash due to sudden loss of power.

One of the original OEM tires (Pirelli Scorpion MS KS NCS XL - 245/45R21) had the acoustic dampening foam on the inside of the tire fall apart. Dealership indicated that there was 'no impact damage or modifications found with the tire during inspection; meaning this was likely a manufacturing defect due to adhesion issue. Despite the problem and the fact that this tire has less than 12K miles on it at the time of the incident, the local Hyundai dealership, Hyundai corporate and Pirelli all refused to cover the cost to replace the tire. Hyundai dealer said to file a complaint with Hyundai corporate, Hyundai Corporate said that this was a Pirelli tire warranty issue (no paperwork provided about Pirelli tire warranty at time of purchase) and Pirelli indicated that only the local dealer or an authorized dealer of their tires can submit warranty claims, and that it is contingent upon a Pirelli inspection and prorated based on the remaining tread of the tire. This leaves the consumer in a difficult position having to bear the burden of the tire replacement cost upfront, and little chances of recourse as these 3 parties skirt responsibility of the OEM tire. When the acoustic foam fails, the car shakes violently at high speeds, for us this stats at ~50mph. There is no warning light that appears for this, dealer originally thought this was related to ice build up which did not rectify the problem causing us to have to go to the dealer twice for diagnostics. Online forums seem to point that this acoustic foam adhesion issue is especially common in colder climates. Symptoms of problem first appeared in early January, with full diagnosis confirmed early Feb.

-I had just exited from the highway and was driving into my town. While doing so, I had both hands on the steering wheel and suddenly the car started beeping and flashing warnings/ alerts indicating that my hands were not on the steering wheel, which they were. Within seconds the car began to deaccelerate and pull me off the road to my right hand side. I initially had no control over the vehicle. Then again- without explanation it began to register hands on the steering wheel and I was able to resume control of the vehicle. I believe the lane assist feature was on at the time. It all happened very quickly. Had I still been on the highway as I was moments before, there was enough traffic that I would have been pulled into another vehicle or caused an accident if people saw me suddenly rapidly deaccelerating/braking in front of them because they would have no warning and a very tiny amount of time to react. Then, in an other instance that followed shortly thereafter, my boyfriend was driving with one of the lane assist on. While driving, the weather changed and it began snowing and freezing rain that was freezing when it hit the windshield. The lane assist began to have trouble seeing the lines on the road since the snow and ice were obscuring them somewhat. It began to beep and gently correct the car- which was not appropriate in this case (we understand that the road conditions were beyond its abilities to safely discern things accurately). My boyfriend who had two hands on the wheel trying to carefully navigate this sudden burst of weather so at not to slide. He tried turning it off, but it wasn't turning off, and couldn't troubleshoot it without taking his hands off the wheel. He instructed me to turn it off through the settings menu in the infotainment system, which seemed to disable it. Prior to these dangerous problems, I had experienced some seemingly sensor- related malfunctions with the tire pressure monitoring system. I'm out of room to write more.

when using lane following the system repeatedly warns you to pay attention, usually when in heavy traffic and after repeated warning shuts of the cruise and lane following system. when using the cruise control system the system will suggest you take a break. both problems appear to be associated with an in cabin camera. i have driven my vehicle almost 25,000 miles and taken two cross country trips. the warning system has almost never warned me of a real problem. 99 percent of the time it is a false reading by the camera and occurs under challenging driving conditions when the last thing you need it to be told to pay attention when you truly are. during this winter i have driven more at night and the vehicle is basically un drivable because of false notifications. this has repeatedly happened in the 14 months i have owned the vehicle - the date below is just for when it happened today. i am more than willing to share details and would welcome a call

I have had the driver’s side wiper blade stop working properly twice since purchase. The first instance involved ice within the vicinity of the wiper arm mount on the driver’s side. There was compacted snow and ice next to the arm motor mount location. When the wiper was activated, the wiper could not extend fully vertical due to the snow and ice in the corner and this caused the wiper arm to become loose. The driver’s wiper arm then failed to properly operate and frequently overlapped the passenger wiper arm/blade which still functioned. The arm was replaced under warranty at a dealership. The second time this happened, I was driving during a snowstorm and the wiper was turned on with minimal snow and ice accumulation from roughly one hour of driving and occasional wiper use. The snow buildup between the driver’s wiper blade and the A pillar prevented the blade from completing a full sweep of the windshield and the driver’s side wiper came loose and failed to function properly. It frequently became entangled with the passenger wiper blade, causing visibility issues while driving. I have an appointment for this. The wiper arm itself has splines that match up with the wiper motors located between the hood and windshield. If an obstruction of snow or ice either holds the wiper blade down or prevents a full range of motion, the wiper motor easily strips these splines from the wiper arm, resulting in wiper arm failure, damage/bending of the arm(s) and cosmetic damage to the plastic A pillar trim (from wiper over extending past A pillar. The design of the vehicle wiper recess location prevents lifting the wiper arms if there is any snow or ice accumulation on the vehicle and the wipers are in the normal down position. Combine this with the lack of any melting capability from the windshield defroster or a dedicated wiper defroster, there is no way to ensure the wipers will function properly when needed during a snow or rain storm and freezing conditions.

While driving my 2024 Hyundai Santa Fe, the vehicle experienced a complete dashboard and system blackout, as if the vehicle shut off and rebooted. This has occurred on two separate occasions. On one occasion, while stopped at a traffic light, the dashboard went completely black and restarted. After the system rebooted, the vehicle would not accelerate or move when the accelerator was pressed. I had to turn the vehicle off, restart it, and wait before it would drive again. The suspected malfunction involves the vehicle’s electrical/infotainment and related vehicle control systems. The vehicle is available for inspection upon request. My safety and the safety of others were put at risk because the vehicle lost critical dashboard information and temporarily lost the ability to accelerate while in traffic, creating the risk of being struck by other vehicles. The vehicle was inspected by an authorized Hyundai dealership (World Hyundai of Matteson). On December 23, 2025, I was informed by the dealer that a system/infotainment “glitch” had been identified and that a replacement part would be ordered. However, the part was never replaced. The dealer later stated that because the issue could not be duplicated during test drives (approximately 85 miles driven), the repair was not authorized. The dealer acknowledged the issue could not be reproduced on demand. The manufacturer (Hyundai) has not yet physically inspected the vehicle beyond dealership involvement. No police or insurance inspections occurred, as there was no crash. There were no warning lamps or messages prior to the failure. The failure occurred suddenly with a complete dashboard blackout and system restart. The first occurrence happened prior to December 23, 2025; the second occurred afterward. The issue is intermittent and unresolved. I am concerned that the defect must reoccur while driving in order to be repaired, posing an ongoing safety risk.

The In-Cabin Camera system is having non stop issues. I have had this car since 2024 and have never experienced issues with this system like I have for the past month or so. I don't know if this is because of the latest update that was done on 11-26-25 or not.The system constantly goes off telling me to keep my eyes on the road when I am staring at the car in front of my while I am driving. It dings and displays the message on the dash which is a major distraction while driving. On the 8th of January I decided to count how many times it goes off. On all these drives I was only driving for 20-25 minutes at a time. On the 8th the system went off 26 times, on the 9th it went off 18 times and on the 12th it went off 27 times. That is excessive and very dangerous as if I turn the system off in the car it will disable the safety features on the car because it can’t detect my eyes at that time even though I am staring at the car in front of me. It does it in any type of weather, any time of day, and if I’m wearing my prescription glasses, sunglasses or anything. I took it to the dealer and they couldn’t duplicate the issue so they weren’t able to fix it as per Hyundai they have to duplicate the issue for them to fix it.

Hyundai - DAW - Driver Attention Warning / Forward Attention Warning System This issue warrants immediate consideration for a recall. Despite wearing glasses, sunglasses, or no glasses, the problem persists. I occasionally remove my glasses while driving, and the warning continues to sound. This occurs regardless of the time of day, weather conditions, or whether I am sitting upright or reclining. The warning randomly activates and deactivates, sometimes without any intervention. Occasionally, I simply allow the warning to sound without taking any action, and it remains active for a few seconds or until it triggers a warning that the system will be turned off, at which point it deactivates. I have attempted various troubleshooting methods, such as keeping my eyes open, adjusting my seating position, wearing and removing my glasses, and tilting them to minimize glare. None of these methods have proven effective in preventing the warning from activating or in making it deactivate. This is a persistent problem. Hyundai dealerships initially informed me that the warning might be an annoyance and their response was to simply refrain from using it. However, if a basic feature like cruise control in a 2024 & 2025 model is rendered unusable due to a design flaw (which this certainly is), it constitutes a clear violation of safety standards and should be addressed through a recall. The incessant alerts are highly disruptive and can be quite frustrating. For instance, driving with an arm in the 12 o’clock position triggers a warning, while wearing polarized sunglasses also results in an alert. The presence of a setting to disable the warning is a welcome feature, but the system’s persistent alerts can be overwhelming. The alerts continue even after taking a break. It is distracting and a safety hazard. Drivers should be able to adjust the sensitivity of the feature to turn off this feature. Currently, there is no way to disable or temporarily disable this feature.