2022 Hyundai Santa Fe

1. Component/System: 2022 Hyundai Santa Fe 8-speed dual-clutch transmission (DCT), specifically the transmission oil pump or hydraulic pressure system. Inspection availability: The vehicle is currently at McGrath City Hyundai in Chicago and can be made available for inspection upon request. 2. The transmission exhibited slipping gears, delayed gear engagement, loud mechanical noise, and a transmission warning light. These conditions create the risk of sudden loss of drive power, unexpected stalling, or inability to control the vehicle, which could cause accidents, collisions, or injury to the driver, passengers, or others on the road. 3. A technician at McGrath City Hyundai initially informed us that the transmission oil pump had failed, which aligns with the symptoms. Later, another dealership representative claimed there was no issue, and the fluid was simply low. No written diagnostic confirmation or independent verification has been provided to date. 4. Hyundai corporate has been contacted and opened a case, but they refused to provide documentation or details of any inspection or repair, and did not assign a supervisor to provide clarification. No police, insurance, or third-party inspections have been performed. 5. Symptoms first appeared on March 9, 2026, including: Transmission warning light; Delayed gear engagement; Slipping gears; Loud mechanical noise from the transmission

While driving at normal roadway speeds, the vehicle experienced a sudden and unexpected loss of power during acceleration. The engine remained running, but the vehicle failed to respond appropriately to throttle input, resulting in a significant reduction in forward movement. This created a dangerous situation, particularly in traffic conditions where consistent acceleration is required. The issue appears to be related to the transmission or powertrain system, though the exact component failure is UNKNOWN at this time. This condition poses a serious safety risk, as loss of power while driving can increase the likelihood of rear-end collisions or inability to safely merge or clear intersections. The vehicle has been inspected by an authorized dealership; however, they were unable to reproduce the issue during testing and therefore did not perform a repair. Despite this, video evidence of the incident exists and clearly shows the loss of power event. There were no warning lights or messages prior to or during the incident. The failure occurred unexpectedly during normal operation. The problem has not been resolved and may occur intermittently, making it difficult to reproduce under standard inspection conditions. The vehicle remains in service and available for inspection upon request.

1. The transmission warning symptoms first appeared on March 9, including a transmission warning light, delayed gear engagement, slipping gears, and loud mechanical noise. 2.5-liter turbo engine use an 8-speed dual-clutch transmission (DCT). It has been in McGrath City Hyundai since March 10 for inspecton. 2. We were not harmed, but were very concerned about the safety of the car. 3. We only tried and waiting for this dealer for a ddiagnosis, but they verbally gave 2 conflicting diagnoses today. No written diagnosis report, no repair report. 4. This morning (9am), a staff informed us by phone that the vehicle has a failed transmission oil pump and that the dealership was waiting for approval for the replacement part. However, during a later call (1pm) today, another staff member stated that there is no issue for the transmission oil pump, and that the transmission fluid was simply lower than normal, with no leaks. We were told to pick up the vehicle today. We refused and waiting for them to email us a diagnosis report and a repair report. 5. The transmission warning symptoms first appeared on March 9, including a transmission warning light, delayed gear engagement, slipping gears, and loud mechanical noise. This conflicting information is extremely concerning, especially given the transmission symptoms described above. Hyundai issued Safety Recall #236 specifically for 2021–2022 Santa Fe vehicles due to the high-pressure electric oil pump in the 8-speed Dual-Clutch Transmission (DCT) potentially malfunctioning, causing a complete loss of drive power. And there is an active class action about it too.

The panoramic sunroof of a 2022 Hyundai Santa Fe Hybrid Limited spontaneously shattered while in transit on the highway. A resoundingly explosive “bang” preceded large shards of falling glass — leaving a massive hole in the sunroof’s front panel. The incident seemingly occurred without direct contact of any kind…no flying debris, no overpass roads, no inclement weather.

In November 2025, my 2022 Hyundai Santa Fe began to hesitate when accelerating and would almost "jerk" when I pressed the gas pedal. Soon after my check engine light came on and I made an appt to take it for the closest Hyundai dealership (as it's still under warranty 33k miles) Upon running a check the dealership notified me that Fuel Injector 1 has misfired and will be replaced. I receive my vehicle back and not even 100 miles later my check engine light in on again and the same issues are arising. Back to the dealership to see now Fuel Injector 3 has misfired and there is an open TSB showing all 4 Fuel Injectors need replaced. My vehicle was finally returned to me in January 2026. It is now February 16, 2026 and my check engine light in on YET AGAIN. I've been given the run around from Hyundai Corp about fixing this vehicle. Why is this acceptable treatment when a vehicle is under warranty ?

On my vehicle I’ve had to have the horn replaced at least three times. Paying about $500 for the last two instances. While there is no formal federal recall for the 2022 Hyundai Santa Fe horn specifically, it is affected by a widespread, known issue where water intrusion corrodes the horn's electrical contacts, leading to failure. Hyundai has addressed this with an extended warranty or service campaign in some regions to replace the horn. Saying this my vin # is not included in this but I can’t understand why.

The car was purchased new on June 30, 2021. On January 25, 2024 at 38,347 miles the horns failed to work and were replaced under warranty. About a week ago (c. January 24,2026) the horns again failed. The dealer was called and I was told that there was no recall on the horns and I would have to pay around $91 for the horns plus labor. The service manager told me that this is a common problem that has to do with where the horns are mounted on the vehicle. They are behind the front bumper and exposed to the elements. I feel that this is a serious design flaw and a safety issue that should be addressed by the manufacturer. There should be a recall instead of customers buying new horns every two years. Had the horns failure occurred during an emergency situation it could have resulted in an accident and possible loss of life.

Took my 22 Sante fe to the Hyundai dealership to have the blower motor checked since I have no air flow in my car. Dealership informed me that the engine harness needs replaced and that it melted the fuse box under the hood. So, I am not able to replace my blower motor at this time due to the melted fuse box. Dealership also advised that they have seen the same problem in multiple 22 Sante Fe. and that there is likely more with the same issue within the United States. I have been noticing a melting/hot smell in the car before the airflow quit and I took it to the dealership to be diagnosed.