2009 Hyundai Santa Fe

2 unrepaired recalls. Frame rusted and unsafe to lift to repair the other recall which is an oil leak onto the alternator. Car won't run now. Corporate asked if I had a lawyer. They have declared my car not fixable or drivable. Neither corporate nor dealer will return my calls. No info from them at all. No offer of a buyback. No anything.

I am writing to document a troubling interaction at one of the Hyundai service locations regarding a known recall on my 2009 Hyundai Santa Fe (166,000 miles). This vehicle is affected by Recall Campaign Number 103 (valve cover gasket may leak and cause alternator failure and electrical fire risk). The issue is publicly documented by NHTSA and Hyundai, and my vehicle has experienced exactly the problems outlined — two alternator failures and two batteries killed. When my vehicle was brought to Hyundai of Metairie, located at 5969 Veterans Memorial Boulevard, Metairie, Louisiana, the service receptionist stated before even inspecting the car that it “may not be covered” because the alternator is aftermarket. This was said immediately upon drop-off, which I believe is inappropriate and concerning. We dropped it off Friday evening before the Saturday, May 31, 2025 morning scheduled inspection. As you are aware, federal law requires manufacturers to complete recall repairs at no cost, regardless of vehicle ownership history or whether a part has been replaced with an aftermarket component — especially when the replacement occurred due to a known safety defect. The alternator was not modified; it was replaced after multiple failures that align precisely with the recall’s described risk. I respectfully request that: The vehicle be inspected promptly and fairly. The recall be honored and completed at no charge, as required. Hyundai ensure that dealership employees are not preemptively discouraging customers from rightful recall services with misinformation or dismissive attitudes. I have already filed a complaint with Hyundai Corporate office this morning and intend to follow up with a phone call when offices resume usual business hours. Thank you in advance for your time. Sincerely, [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My 2009 Santa Fe's paint is peeling in large portions. It started on the driver's side door right below the window and has continued to crack and bubble all the way down the door. There has been no safety issues as of yet, but it will be a safety issue if I am driving and pieces or chunks of the paint fly off. If pieces or chunks fly off and land on my or another driver's windshield and blocks the ability of our vision it could be very dangerous and potentially cause an accident. I am not talking about little chips of paint here and there, I am talking about large size chunks. I know that I am not the only person who is having this issue, there are hundreds of people having this same issue and why there has not been a recall for this yet is blowing my mind. What is Hyundai waiting for a accident, a fatality? This is something that they need to make right, we work hard and when we purchase a vehicle for a lot of money and we take care of it so it will last us a long time and then the paint starts peeling all over the place and makes it look horrible not to mention it will begin to rust, how does Hyundai not feel obligated to fix it and make it right?

2009 Hyundai Sante Fe Mileage as of 9/16/2023 145608 I took the vehicle there on Saturday, 9/16/2023 to have the oil changed. I always bring my own oil and filter, so I only have to pay for the labor. Each time, I do this, the mechanic always over fill the oil. The manual book indicates that it should be 5 ½ quarts, and they use the entire 6 quarts, which overfills the oil. Also normal, the dealership checks the vehicle out for possible issues. This time I had a note indicating that “Inspection is due in the end of November, the frame is rusted and will not pass inspection most like not repairable.“ They provided two (2) pictures as well that I will attach to this document. In 2017, there was a recall where they sprayed the undercarriage for rust. However, the car had been rusting almost immediately since I purchased it. I feel that the metal that was used on the frame is inferior, and can not stand the climate in the United States? [XXX] , the service advisor advised me that normal moisture, mother nature would make the car rust. I can understand this to a certain point, but not to the point that the car is not repairable any longer. I still have 7 years, or 54000 miles left on the warranty from Colonial Hyundai. Bottom line the car has been rusting for some time, and several mechanics around here have advised me that Hyundai vehicles overall are known to rust. I have had to replace the front arms and a few other things on the vehicle. I don’t drive the car that much especially in bad weather because I work from home since 2020. In addition, I get my car washed every week, and more often if there is bad weather and there is lots of salt on the road. However, in PA, there has not been many bad winters over the last few years. The frame is rusty – then the entire car is not safe to drive, hence not passing inspection, and most likely it is not repairable, which concerns me. How many other people are in this same boat? Car is available to look INFORMATION REDACTED PURSUANT TO THE FREEDOM OF

Frame rails have rusted through with big holes showing! I did bring it to dealer in 2017 for campaign 947 for rust issues. I brought it to dealer about 2 weeks ago to see if they could put it on the hoist to see if vehicle is safe to drive but was told they don't look for rust. I have a claim number with Hyundai but haven't heard back in over a week. I am a 1 owner on this vehicle. I have always kept good care on this vehicle. I don't think this vehicle is safe to drive. The whole car could buckle while I am driving down the road!

Paint is peeling/delaminating off the car in chunks - from the roof and the hood. Paint peeled off of the hood in a large chunk while I was driving, and got stuck on the windshield & caught up on the wipers while in use. This damaged the wipers and created a dangerous situation, as it blocked my vision while driving. The paint peels off and flies off the car in chunks and can land on another car windshield as well and block their view. I brought the car to the dealer years ago when the paint first starting peeling, and was told it was just past the warranty and there was nothing they could do. I read online that there was a class action suit on this exact issue and it has been a problem for many, many years and Hyundai continues to manufacture this paint despite being aware of the problem. I contacted Hyundai corporate to report this issue, and they said there is nothing they can do. So I have decided to report the issue to warn other drivers, as the last chunk that peeled off became a safety hazard. Note: Car was only used occasionally, has very low mileage, and is garaged for a portion of the year. The paint should not be in this condition - it is defective. I paid extra for this particular pearl white paint when I purchased the car new - it was an upgrade, presented as self-healing paint.

This has happened on more than one occasion. My car will suddenly try to stop and then it will accelerate really fast. I am not commanding it to do so with my foot. IT is very scary. then my car will just go cold.. The dash lights will all light up, blink on and off and then it leaves me stranded. I have to turn the vehicle off and sit there for a little before it will ignite again. It did this in the Publix parking lot as I was pulling into a spot to park and I almost hit a person walking by. It is like somebody has control of my vehicle and is accelerating and braking. [XXX] [XXX] Thank you for your attention to this matter INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

MY VEHICLE WAS TAKEN FOR AN OIL CHANGE AT ETD SERVICE CENTER ON SATURDAY, 9/19/2020. I THEN DROVE DOWN THE PARKWAY FOR THE WEEKEND. I RETURNED SUNDAY NIGHT AND NOTICED MY OIL LIGHT WAS BLINKING WHILE STOPPED AT A LIGHT. I RETURNED TO ETD FIRST THING MONDAY MORNING 9/21/2020 WHO ADVISED THAT "IF IT HAPPENED AGAIN, BRING IT TO THE DEALER". TODAY ON 9/23/2020, THE OIL LIGHT WAS BLINKING AGAIN WHILE STOPPED AT A LIGHT AND THE VEHICLE WAS IDLING. THERE IS NO OIL LEAKING.

WHEN I FIRST "TESTED" THE CAR I MENTIONED TO THE SALES PERSON THAT I THOUGHT IT WAS PULLING TO THE RIGHT. HE CONVINCED ME IT WASN'T. ON 7/31/19 I PURCHASED 4 NEW TIRES AND HAD A WHEEL ALIGNMENT. I TOOK IT BACK FOR ADJUSTMENTS TO THE ALIGNMENT 3 TIMES BEFORE THE COVID OUTBREAK (TWICE BEFORE JANUARY). IT IS NOW MAJORLY VEERING TO THE RIGHT AND I HAVE TO KEEP IT FROM GOING THAT WAY WHEN DRIVING. I DON'T DRIVE FAR TO WORK WHICH IS WHY IT WASN'T AS MUCH OF A PROBLEM BEFORE.