Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
720–25K
4425–50K
11650–75K
11275–100K
92100–150K
25150K+
461 reports with mileage · 80 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Fuel/propulsion System. Review the 215 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 74 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Air Bags. Review the 70 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
17 crash reports7 fire reports11 injury reports
What owners actually said
541 reports
Mileage unknown · Jun 20, 2023
Structure
2008 HYUNDAI SANTA FE- The car goes to the dealer every 6 months for the grease and oil and then the New York State Inspection every November. That car has been up on the lifts numerous times since 2008 and I am now just being informed the undercarriage - driver side frame was rotted. I don't think the frame could have rotted ou…
Read full complaint
2008 HYUNDAI SANTA FE- The car goes to the dealer every 6 months for the grease and oil and then the New York State Inspection every November. That car has been up on the lifts numerous times since 2008 and I am now just being informed the undercarriage - driver side frame was rotted. I don't think the frame could have rotted out since my last inspection in November of 2022. I found the recall was from 2017 campaign #947.I was never notified of this recall, I feel Hyundai has put me as risk to be involved in an accident if the undercarriage falls out. If it was a warranty job back in 2017 I would have been covered as I had a 10 year warranty which would have expired November 2018. Hyundai should repair the vehicle at no cost to me as I was never notified of of the recall for service campaign 947 and I would have been covered under the 1O year warranty . This was negligence on Hyundai's behalf I might not have this problem if the service campaign #947 was performed in 2017 / 2018. If they knew the campaign was out there it should have been completed with one my New York State Inspections in November of of 2017 or 2018. This question goes to Hyundai- on the invoice it states LIFETIME OIL CHANGES - why was I charged $19.98? I asked the service advisor and his was reply was we got bought out and no more free oil changes. Not a good answer - I should be grandfathered in and refunded the $21.55.
NHTSA ODI #11527887
Mileage unknown · Jun 10, 2023
EngineUnknown Or OtherFire
i change the oil on 4/18/2023 in walmart i park the car in my house i used on 04/23/2023 on i-75 southbound the oil light came out and them smoke star on the car fallow by fire me and daugther an husband where on the suv was tereffied
NHTSA ODI #11526405
73,000 miles · May 2, 2023
Vehicle Speed Control
The contact owns a 2008 Hyundai Santa Fe. The contact stated that on several occasions while driving at undisclosed speeds, the brake pedal was depressed; however, the vehicle experienced unintended acceleration. The contact stated that he shifted into neutral(N) to stop the vehicle. The check engine warning light was illuminate…
Read full complaint
The contact owns a 2008 Hyundai Santa Fe. The contact stated that on several occasions while driving at undisclosed speeds, the brake pedal was depressed; however, the vehicle experienced unintended acceleration. The contact stated that he shifted into neutral(N) to stop the vehicle. The check engine warning light was illuminated. The vehicle was taken to a local dealer, where it was diagnosed that two unknown sensors and the fuel pump needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 73,000.
NHTSA ODI #11520065
Mileage unknown · Mar 29, 2023
SuspensionWheels
The rear and drive unit is having issues loud popping sound when driving this is a major safety concern, and seems to be a huge problem across the board as I’ve been reading about on Hyundai forums
NHTSA ODI #11514518
Mileage unknown · Feb 14, 2023
Service BrakesCrash
be guessed ABS malfunction, on 11/03/2022 on highway in bumper-to-bumper situation.speed around 40 Mph. the car front Suddenly hit braking hard, I had followed immediately hitting the braking hard but at some point became lost brake and collied at the car front, this a second time, I had another very similar situation years ag…
Read full complaint
be guessed ABS malfunction, on 11/03/2022 on highway in bumper-to-bumper situation.speed around 40 Mph. the car front Suddenly hit braking hard, I had followed immediately hitting the braking hard but at some point became lost brake and collied at the car front, this a second time, I had another very similar situation years ago but avoided collision
NHTSA ODI #11507202
Mileage unknown · Nov 11, 2022
Unknown Or OtherVisibility/wiper
The sunvisors for passenger and driver are defective. I have had the car since 2013 and have had to replace both visors at LEAST once a year, if not more frequently. The visor will suddenly break, swing down, impairing vision of the driver while the car is in motion, including highway speeds. I have been hit in the head sever…
Read full complaint
The sunvisors for passenger and driver are defective. I have had the car since 2013 and have had to replace both visors at LEAST once a year, if not more frequently. The visor will suddenly break, swing down, impairing vision of the driver while the car is in motion, including highway speeds. I have been hit in the head several times when it breaks & swings while driving -- I am going to have a wreck eventually if Huydai does not address this defect in their visors & it is clearly a defect (check YouTube for all the hacks in how to attempt to fix it).
NHTSA ODI #11493225
136,397 miles · Nov 7, 2022
EngineCrash
Head on impact rear ending a truck. Engine locked melted head gaskets and destroyed radiator
NHTSA ODI #11492637
Mileage unknown · Nov 7, 2022
Fuel/propulsion System
The fuel tank level sensor failed and yes can be inspected. Check engine light goes on and fuel says empty with little yellow light .My mechanic checked my car and told me it was the fuel tank level sensor. Check engine light goes on and the fuel needle goes up and down to empty. When I fill the tank, the check engine light goe…
Read full complaint
The fuel tank level sensor failed and yes can be inspected. Check engine light goes on and fuel says empty with little yellow light .My mechanic checked my car and told me it was the fuel tank level sensor. Check engine light goes on and the fuel needle goes up and down to empty. When I fill the tank, the check engine light goes off and the needle rises to full. When the gas reaches a certain level the check engine light goes on and fuel needle drops to empty . It will go up and down. This first occurred October 2022.
NHTSA ODI #11492623
140,000 miles · Sep 13, 2022
Air BagsExterior LightingService Brakes, Hydraulic
The contact owns a 2008 Hyundai Santa Fe. The contact stated that the vehicle was taken to the dealer after receiving notification of NHTSA Campaign Number: 21V936000 (Service Brakes, Hydraulic) and 12V354000 (Air Bags). The dealer diagnosed the vehicle that the brake lamp switch needed to be replaced. The vehicle was repaired; …
Read full complaint
The contact owns a 2008 Hyundai Santa Fe. The contact stated that the vehicle was taken to the dealer after receiving notification of NHTSA Campaign Number: 21V936000 (Service Brakes, Hydraulic) and 12V354000 (Air Bags). The dealer diagnosed the vehicle that the brake lamp switch needed to be replaced. The vehicle was repaired; however, the contact stated that while driving, the TPMS, passenger seat belt, and the ESC warning lights were illuminated. The vehicle was taken to an independent mechanic where it was diagnosed that the valve cover gasket and alternator needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was provided a case number. The failure mileage was approximately 140,000.
NHTSA ODI #11484286
Mileage unknown · May 25, 2022
Structure
I noticed a Crack in the lower part of the windshield on the driver's side. I was told by Safelite there was rust around the windshield and they would not replace the windshield unless the rust was repaired.
Hyundai Motor Company (Hyundai) is recalling certain model year 2006-2009 Accent, model year 2007-2011 Azera, Sonata and Sante Fe,2006-2011 Tucson, 2009-2011 Elantra Touring, 2007-2010 Elantra, 2008-2011 Veracruz, 2009-2011 Genesis, 2010-2011 Genesis Coupe, 2007-2008 Entourage, and 2006-2008 Tiburon vehicles. Originally, in April 2013, Hyundai recalled 1,059,824 model year 2007-2009 Accent and Tucson, model year 2007-2010 Elantra, model year 2007-2011 Santa Fe, model year 2008-2009 Veracruz, model year 2010-2011 Genesis Coupe, and model year 2011 Sonata vehicles. In September 2013, Hyundai informed the agency that it was adding more vehicles to this campaign, representing an additional 652,512 units. The total number of vehicles being recalled is now 1,712,336. In the affected vehicles, the stop lamp switch may malfunction. A malfunctioning stop lamp switch may cause the brake lights to not illuminate when the brake pedal is depressed or may cause an inability to deactivate the cruise control by depressing the brake pedal. Additionally, a malfunctioning stop lamp switch may also result in intermittent operation of the push-button start feature, affect the operation of the brake transmission shift interlock feature, preventing the shifter from being moved out of the PARK position and cause the Electronic Stability Control (ESC) malfunction light to illuminate.
Consequence & remedy
Consequence: Failure to illuminate the stop lamps during braking or inability to disengage the cruise control could increase the risk of a crash. Additionally, when the ignition is in the 'ON' position, the transmission shifter may be able to be moved out of Park without first applying the brake. This may lead to unintentional movement of the car which may increase the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will replace the stop lamp switch, free of charge. The safety recall began on April 22, 2013. Owners may contact Hyundai at 1-800-633-5151. Hyundai's recall campaign number is 110.
Hyundai is recalling certain model year 2007 through 2009 Santa Fe vehicles manufactured from April 19, 2006, through July 7, 2008. The occupant classification system (OCS) may need recalibration to accurately detect small statured adults.
Consequence & remedy
Consequence: Improper classification or detection may cause the front passenger airbag not to deploy in the event of a crash, increasing the risk of injury to the front passenger.
Remedy: Hyundai will notify owners, and dealers will update the classification software free of charge. The safety recall began on September 7, 2012. Owners may contact Hyundai at 1-800-633-5151.
HYUNDAI IS RECALLING CERTAIN MODEL YEAR 2007-2008 HYUNDAI VERACRUZ VEHICLES MANUFACTURED FROM DECEMBER 26, 2006, THROUGH MARCH 21, 2008, AND MODEL YEAR 2007-2008 HYUNDAI SANTA FE VEHICLES MANUFACTURED FROM APRIL 19, 2006 THROUGH MARCH 20, 2008. THE CLOCK SPRING CONTACT ASSEMBLY FOR THE DRIVER'S AIR BAG SUPPLEMENTAL RESTRAINT SYSTEM (SRS) MAY BECOME DAMAGED THROUGH USAGE OVER TIME. THE DRIVER'S AIR BAG ELECTRICAL CIRCUIT WILL EXPERIENCE A HIGH RESISTANCE CONDITION, POTENTIALLY CAUSING THE DRIVER'S AIR BAG TO NOT DEPLOY.
Consequence & remedy
Consequence: IF THE CLOCK SPRING DEVELOPS HIGH RESISTANCE, IN THE EVENT OF A CRASH, THE DRIVERS AIR BAG WILL NOT DEPLOY AND WILL NOT BE ABLE TO PROPERLY PROTECT THE DRIVER, INCREASING THE RISK OF INJURIES.
Remedy: HYUNDAI DEALERS WILL REPLACE THE VEHICLE'S DRIVER'S AIR BAG CLOCK SPRING CONTACT ASSEMBLY FREE OF CHARGE. THE SAFETY RECALL BEGAN IN NOVEMBER 2011. OWNERS MAY CONTACT HYUNDAI CUSTOMER CONNECT CENTER AT 1-800-633-5151.
HYUNDAI IS RECALLING 88,943 MY 2007-2008 HYUNDAI SANTA FE VEHICLES EQUIPPED WITH P235/60R18 TIRES. THESE VEHICLES FAIL TO COMPLY WITH THE LABELING REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110 "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES." THE BLACK CERTIFICATION LABEL AFFIXED TO THE DRIVER'S SIDE CENTER PILLAR, INCORRECTLY LISTS THE GROSS AXLE WEIGHT RATINGS (GAWR).
Consequence & remedy
Consequence: OVERLOADING YOUR VEHICLE MAY ADVERSELY AFFECT HANDLING AND BRAKING AND MAY CAUSE TIRE DAMAGE, RESULTING IN TIRE FAILURE AND A CRASH WITHOUT WARNING.
Remedy: HYUNDAI WILL MAIL CORRECTED CERTIFICATION LABELS ALONG WITH THE INSTRUCTIONS TO THE AFFECTED OWNERS. THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 5, 2008. OWNERS MAY CONTACT HYUNDAI AT 1-800-633-5151.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
DP21003 · Throttle Control System Vulnerabilities
Opened Nov 12, 2021 · Closed Jun 20, 2023
Status: closed (inferred from source dates) · Vehicle Speed Control:throttle
The Office of Defects Investigation (ODI) of the National Highway Traffic Safety Administration (NHTSA) received a petition letter dated October 10, 2021, requesting an investigation of possible defects in the electronic throttle control (ETC) system on certain Kia vehicles resulting in the opening of DP21-003. Accordingly, Model Year (MY) 2005-2016 Kia Optima/K5, MY 2006-2015 Kia Sorento, MY 2007-2016 Hyundai Elantra, MY 2007-2016 Hyundai Santa Fe, MY 2006-2015 Hyundai Sonatas are all part of the subject population. The petition was originally filed as a Vehicle Owner Questionnaire that can be reviewed at NHTSA.gov under reference (ODI) number 11439675.On November 12, 2021, ODI opened Defect Petition DP21-003 to evaluate the petitioner?s request. ODI performed trend analyses of the VOQs related to vehicle speed control issues for all the subject vehicles and found that none of the 52 Model/Model Year Hyundai/Kia vehicles demonstrated any actionable trend that warranted an investigation.Petitioners submitted 1119 VOQs and non-VOQ cases in which sudden uncommanded acceleration (SUA) or loss of motive power (LOMP) incidents were alleged.For the 1119 reports, 220 were incidents involving crashes, from which 69 subject Hyundai-Kia vehicles were inspected by Hyundai/Kia dealer technicians, Hyundai/Kia engineers, and/or third-party representatives.ODI found the inspections identified no vehicle defects related to the ETC system.Of the 220 crash-involved reports, 13 Event Data Recorder (EDR) records were downloaded successfully and 11 of those indicated driver error: (i.e.) pedal misapplication.A condition where the accelerator pedal is mistakenly applied instead of the brake pedal when the driver wants to stop the vehicle.In addition, ODI reviewed a scientific journal paper published in Forensic Science International in 2016 by Mr. Park et al ., as well as related test videos. ODI does not believe there is any evidence of uncontrollable SUA occurrences in any of the tests reviewed. NHTSA's Office of Vehicle Safety Compliance (OVSC) reviewed the allegations regarding the potential noncompliance with Federal Motor Vehicle Safety Standard No. 124.Based on the information provided, the Agency concludes there is insufficient information for us to determine if a possible non-compliance exists.Finally, both Hyundai and Kia informed ODI that all their vehicles manufactured after 2012 were equipped with an ETC management system, in which the engine speed will go to idle when the system sees signals from both the brake pedal and accelerator pedal at the same time; this is commonly known as the brake-throttle override system.After thoroughly assessing the material submitted by the petitioner, information already in NHTSA's possession, information submitted by Hyundai and Kia in response to an Information Request letter, and the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that a formal investigation is warranted. After full consideration of appropriate factors, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA?s reasons for denial of the petition will be published.
2008 Hyundai Santa Fe Problems, Complaints & Recalls | Skip That Year
Illustration