IllustrationRusted out subframe, less than 95k miles. No “salt belt” treatment offered to this vehicle. Vehicle in Ohio since bought. Took to dealer for engine recall, found $1200 subframe replacement bill. Car was garage stored all of the time.
2008 Hyundai Santa Fe
Owner reports · Recalls · Investigations
More warning signs than most Santa Fe years
Owner complaints for the 2008 Hyundai Santa Fe are substantially higher than the model-year median of 212.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Santa Fe years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
720–25K
4425–50K
11650–75K
11275–100K
92100–150K
25150K+
461 reports with mileage · 80 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel/propulsion System. Review the 215 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 74 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 70 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
17 crash reports7 fire reports11 injury reports
Suspension complaints
11 reportsThe rear and drive unit is having issues loud popping sound when driving this is a major safety concern, and seems to be a huge problem across the board as I’ve been reading about on Hyundai forums
The contact owns a 2008 Hyundai Santa Fe. The contact stated that while reversing out of his driveway at 1 MPH, the front end on the passenger’s side of the vehicle collapsed almost causing the wheel to detach. The contact stated there was no warning light illuminated. There was no injury sustained. The contact had the vehicle t…
Read full complaint
The contact owns a 2008 Hyundai Santa Fe. The contact stated that while reversing out of his driveway at 1 MPH, the front end on the passenger’s side of the vehicle collapsed almost causing the wheel to detach. The contact stated there was no warning light illuminated. There was no injury sustained. The contact had the vehicle towed to the dealer to be diagnosed. The contact was informed that the control arm and ball joint had shattered. The contact stated that the vehicle remained at the dealer awaiting the arrival of the replacement part. The manufacturer was contacted and provided the contact a case number. The approximate failure mileage was 72,000. Repaired at cost of $1666.67 at Napelton Hyundai 3703 Northlake BLVD Lake Park Florida 33403. The car had a faulty fuel gauge which could NOT be repaired after 3 attempts. Car also experienced loss of power brakes and power steering while driving on the highway.
PRIOR TO CONTACTING NHTSA WE CONTACTED HYUNDAI AND INFORMED THEM THAT THE BOTTOM OF THE VEHICLE HAS RUSTED THROUGH AND WE CAN SEE THE BOTTOM OF THE INTERIOR IN THIS VEHICLE WHEN THE CAR IS ON A LIFT (THIS WAS POINTED OUT TO US BY A THIRD PARTY REPAIR SHOP AND NOT THE DEALER). IT APPEARS THAT HYUNDAI MAY BE CONCEALING DATA FROM N…
Read full complaint
PRIOR TO CONTACTING NHTSA WE CONTACTED HYUNDAI AND INFORMED THEM THAT THE BOTTOM OF THE VEHICLE HAS RUSTED THROUGH AND WE CAN SEE THE BOTTOM OF THE INTERIOR IN THIS VEHICLE WHEN THE CAR IS ON A LIFT (THIS WAS POINTED OUT TO US BY A THIRD PARTY REPAIR SHOP AND NOT THE DEALER). IT APPEARS THAT HYUNDAI MAY BE CONCEALING DATA FROM NHTSA REGARDING CORROSION PROBLEMS ON ITS VEHICLES. WHAT IS CLEAR IS THAT HYUNDAI IS SHIRKING ITS SAFETY OBLIGATIONS AND WILL NOT COVER CORROSION, REGARDLESS OF WHETHER IT IS FUNCTIONAL OR SAFETY, IF THE WARRANTY HAS EXPIRED. BASED ON PRIOR DEALINGS WITH NHTSA I KNOW THAT RECALLS ARE NOT LIMITED TO THE WARRANTY PERIOD IF VEHICLE SAFETY IS IN QUESTION. WHEN WE CONTACTED HYUNDAI, THEIR EXCUSE FOR WHY THE VEHICLE HAD A MASSIVE HOLE IN THE UNDERCARRIAGE WAS THAT THE VEHICLE IS DRIVEN PRIMARILY IN ILLINOIS AND ILLINOIS USES SALT ON THE ROADS IN WINTER. IF I'M NOT MISTAKEN, MORE THAN HALF OF THE VEHICLES IN THE US ARE DRIVEN ON ROADS THAT ARE SALTED IN THE WINTER. THIS EXCUSE IS SIMPLY NOT ACCEPTABLE AND PERHAPS NHTSA NEEDS TO PROHIBIT HYUNDAI FROM SELLING VEHICLES IN THE NORTHERN HALF OF THE US IF THIS IS GOING TO BE HYUNDAI'S ATTITUDE. I'VE NEVER HAD THIS PROBLEM WITH ANY OTHER MANUFACTURER.
I WAS BACKING UP TO TURN AROUND AND AS I WAS TURNING MY STEERING WHEEL I HEARD AND FELT VERY LOUD PULSING THUMPS COMING FROM THE FRONT OF THE VEHICLE. I GOT OUT AND SAW MY DRIVERS SIDE FRONT WHEEL WAS LEANING OUT FROM THE VEHICLE. THE ARM BROKE OF FROM MY WHEEL ALSO I FOUND OUT WHEN I HAD IT REPAIRED THE AXEL ALSO BROKE!! GOO…
Read full complaint
I WAS BACKING UP TO TURN AROUND AND AS I WAS TURNING MY STEERING WHEEL I HEARD AND FELT VERY LOUD PULSING THUMPS COMING FROM THE FRONT OF THE VEHICLE. I GOT OUT AND SAW MY DRIVERS SIDE FRONT WHEEL WAS LEANING OUT FROM THE VEHICLE. THE ARM BROKE OF FROM MY WHEEL ALSO I FOUND OUT WHEN I HAD IT REPAIRED THE AXEL ALSO BROKE!! GOOD THING I WASN'T ON A HIGHWAY OR DRIVING I OR OTHERS MIGHT HAVE BEEN HURT OR WORSE!!!
TL* THE CONTACT OWNS A 2008 HYUNDAI SANTA FE. THE CONTACT STATED WHILE DRIVING AT A LOW SPEED AND MAKING A RIGHT TURN, THE FRONT AXLE AND FRONT DRIVER'S SIDE LOWER CONTROL ARM FRACTURED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THE VEHICLE AND DETERMINED THAT THE LOWER CONTROL ARM AND THE FRONT AXLE FRACTUR…
Read full complaint
TL* THE CONTACT OWNS A 2008 HYUNDAI SANTA FE. THE CONTACT STATED WHILE DRIVING AT A LOW SPEED AND MAKING A RIGHT TURN, THE FRONT AXLE AND FRONT DRIVER'S SIDE LOWER CONTROL ARM FRACTURED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THE VEHICLE AND DETERMINED THAT THE LOWER CONTROL ARM AND THE FRONT AXLE FRACTURED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. A DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 80,000.
TL* THE CONTACT OWNS A 2008 HYUNDAI SANTA FE. WHILE DRIVING APPROXIMATELY 55 MPH, THE VEHICLE BEGAN TO HYDROPLANE WITHOUT WARNING. THE CONTACT STATED THAT THE STEERING FAILED AND, DUE TO THE CONTACT ATTEMPTING TO APPLY THE BRAKES, THE VEHICLE BEGAN TO SPIN. THE VEHICLE CRASHED INTO THE ROAD DIVIDER. THE PASSENGER SIDE OF THE VEH…
Read full complaint
TL* THE CONTACT OWNS A 2008 HYUNDAI SANTA FE. WHILE DRIVING APPROXIMATELY 55 MPH, THE VEHICLE BEGAN TO HYDROPLANE WITHOUT WARNING. THE CONTACT STATED THAT THE STEERING FAILED AND, DUE TO THE CONTACT ATTEMPTING TO APPLY THE BRAKES, THE VEHICLE BEGAN TO SPIN. THE VEHICLE CRASHED INTO THE ROAD DIVIDER. THE PASSENGER SIDE OF THE VEHICLE WAS DAMAGED. THE AIR BAGS DID NOT DEPLOY. THE VEHICLE WAS TOWED. A POLICE REPORT WAS FILED. THE CONTACT RECEIVED SHOULDER AND BACK INJURIES, WHICH REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE BALL BEARINGS ON THE FRONT AXLE WERE WORN OUT. THE TIE RODS WERE REPLACED, BUT THE CALIPERS NEEDED TO BE REPLACED ALSO. THE VEHICLE WAS REPAIRED. THE BODY OF THE VEHICLE WAS NOT REPAIRED. THE CONTACT STATED THAT THE ESC AND ABS SENSORS ILLUMINATED. THE CONTACT RETURNED THE VEHICLE TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE TIRES AND BRAKE PADS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.
HYUNDAI DEALER SAID MY BALL JOINTS WERE BAD, $750.00 FOR REPAIRS, HYUNDAI HAS RECALL I WAS NOT NOTIFIED. DRIVERS AIR BAG ILLUMINATED, GOING IN FOR REPAIR FRIDAY COST UNKNOWN. AGAIN I WAS NOT NOTIFIED ABOUT RECALL. I HAVE TO PAY FOR REPAIRS BECAUSE I WAS NOT NOTIFIED ABOUT RECALLS.
TL* THE CONTACT OWNS A 2008 HYUNDAI SANTA FE. THE CONTACT STATED THAT THE CONTROL ARM AND WHEEL BEARING SEIZED AND WERE UNUSUALLY WORN. THE MECHANIC WAS UNABLE TO REPLACE THE TIRES DUE TO THE FAILURE. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 122,644.
TL* THE CONTACT OWNS A 2008 HYUNDAI SANTA FE. THE CONTACT STATED THAT WHILE DRIVING, THE VEHICLE STARTED JERKING AND VIBRATING. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE TIRES WERE CUPPLING AND NEEDED TO BE REPLACED. THE REMEDY FAILED TO REPAIR THE PROBLEM. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHO DIAGNOSED …
Read full complaint
TL* THE CONTACT OWNS A 2008 HYUNDAI SANTA FE. THE CONTACT STATED THAT WHILE DRIVING, THE VEHICLE STARTED JERKING AND VIBRATING. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE TIRES WERE CUPPLING AND NEEDED TO BE REPLACED. THE REMEDY FAILED TO REPAIR THE PROBLEM. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHO DIAGNOSED THAT THE FRONT AXLE WAS BENT AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 5 AND THE CURRENT MILEAGE WAS 67,000.
Official recalls
413V113000 · Exterior Lighting:brake Lights:switch
Apr 1, 2013
Hyundai Motor Company (Hyundai) is recalling certain model year 2006-2009 Accent, model year 2007-2011 Azera, Sonata and Sante Fe,2006-2011 Tucson, 2009-2011 Elantra Touring, 2007-2010 Elantra, 2008-2011 Veracruz, 2009-2011 Genesis, 2010-2011 Genesis Coupe, 2007-2008 Entourage, and 2006-2008 Tiburon vehicles. Originally, in April 2013, Hyundai recalled 1,059,824 model year 2007-2009 Accent and Tucson, model year 2007-2010 Elantra, model year 2007-2011 Santa Fe, model year 2008-2009 Veracruz, model year 2010-2011 Genesis Coupe, and model year 2011 Sonata vehicles. In September 2013, Hyundai informed the agency that it was adding more vehicles to this campaign, representing an additional 652,512 units. The total number of vehicles being recalled is now 1,712,336. In the affected vehicles, the stop lamp switch may malfunction. A malfunctioning stop lamp switch may cause the brake lights to not illuminate when the brake pedal is depressed or may cause an inability to deactivate the cruise control by depressing the brake pedal. Additionally, a malfunctioning stop lamp switch may also result in intermittent operation of the push-button start feature, affect the operation of the brake transmission shift interlock feature, preventing the shifter from being moved out of the PARK position and cause the Electronic Stability Control (ESC) malfunction light to illuminate.
Consequence & remedy
Consequence: Failure to illuminate the stop lamps during braking or inability to disengage the cruise control could increase the risk of a crash. Additionally, when the ignition is in the 'ON' position, the transmission shifter may be able to be moved out of Park without first applying the brake. This may lead to unintentional movement of the car which may increase the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will replace the stop lamp switch, free of charge. The safety recall began on April 22, 2013. Owners may contact Hyundai at 1-800-633-5151. Hyundai's recall campaign number is 110.
12V354000 · Air Bags:frontal:sensor/control MODULE-INACTIVE
Jul 25, 2012
Hyundai is recalling certain model year 2007 through 2009 Santa Fe vehicles manufactured from April 19, 2006, through July 7, 2008. The occupant classification system (OCS) may need recalibration to accurately detect small statured adults.
Consequence & remedy
Consequence: Improper classification or detection may cause the front passenger airbag not to deploy in the event of a crash, increasing the risk of injury to the front passenger.
Remedy: Hyundai will notify owners, and dealers will update the classification software free of charge. The safety recall began on September 7, 2012. Owners may contact Hyundai at 1-800-633-5151.
11V472000 · Air Bags:frontal
Sep 9, 2011
HYUNDAI IS RECALLING CERTAIN MODEL YEAR 2007-2008 HYUNDAI VERACRUZ VEHICLES MANUFACTURED FROM DECEMBER 26, 2006, THROUGH MARCH 21, 2008, AND MODEL YEAR 2007-2008 HYUNDAI SANTA FE VEHICLES MANUFACTURED FROM APRIL 19, 2006 THROUGH MARCH 20, 2008. THE CLOCK SPRING CONTACT ASSEMBLY FOR THE DRIVER'S AIR BAG SUPPLEMENTAL RESTRAINT SYSTEM (SRS) MAY BECOME DAMAGED THROUGH USAGE OVER TIME. THE DRIVER'S AIR BAG ELECTRICAL CIRCUIT WILL EXPERIENCE A HIGH RESISTANCE CONDITION, POTENTIALLY CAUSING THE DRIVER'S AIR BAG TO NOT DEPLOY.
Consequence & remedy
Consequence: IF THE CLOCK SPRING DEVELOPS HIGH RESISTANCE, IN THE EVENT OF A CRASH, THE DRIVERS AIR BAG WILL NOT DEPLOY AND WILL NOT BE ABLE TO PROPERLY PROTECT THE DRIVER, INCREASING THE RISK OF INJURIES.
Remedy: HYUNDAI DEALERS WILL REPLACE THE VEHICLE'S DRIVER'S AIR BAG CLOCK SPRING CONTACT ASSEMBLY FREE OF CHARGE. THE SAFETY RECALL BEGAN IN NOVEMBER 2011. OWNERS MAY CONTACT HYUNDAI CUSTOMER CONNECT CENTER AT 1-800-633-5151.
08V272000 · Equipment:other:labels
Jun 19, 2008
HYUNDAI IS RECALLING 88,943 MY 2007-2008 HYUNDAI SANTA FE VEHICLES EQUIPPED WITH P235/60R18 TIRES. THESE VEHICLES FAIL TO COMPLY WITH THE LABELING REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110 "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES." THE BLACK CERTIFICATION LABEL AFFIXED TO THE DRIVER'S SIDE CENTER PILLAR, INCORRECTLY LISTS THE GROSS AXLE WEIGHT RATINGS (GAWR).
Consequence & remedy
Consequence: OVERLOADING YOUR VEHICLE MAY ADVERSELY AFFECT HANDLING AND BRAKING AND MAY CAUSE TIRE DAMAGE, RESULTING IN TIRE FAILURE AND A CRASH WITHOUT WARNING.
Remedy: HYUNDAI WILL MAIL CORRECTED CERTIFICATION LABELS ALONG WITH THE INSTRUCTIONS TO THE AFFECTED OWNERS. THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 5, 2008. OWNERS MAY CONTACT HYUNDAI AT 1-800-633-5151.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1DP21003 · Throttle Control System Vulnerabilities
Opened Nov 12, 2021 · Closed Jun 20, 2023
Status: closed (inferred from source dates) · Vehicle Speed Control:throttle
The Office of Defects Investigation (ODI) of the National Highway Traffic Safety Administration (NHTSA) received a petition letter dated October 10, 2021, requesting an investigation of possible defects in the electronic throttle control (ETC) system on certain Kia vehicles resulting in the opening of DP21-003. Accordingly, Model Year (MY) 2005-2016 Kia Optima/K5, MY 2006-2015 Kia Sorento, MY 2007-2016 Hyundai Elantra, MY 2007-2016 Hyundai Santa Fe, MY 2006-2015 Hyundai Sonatas are all part of the subject population. The petition was originally filed as a Vehicle Owner Questionnaire that can be reviewed at NHTSA.gov under reference (ODI) number 11439675.On November 12, 2021, ODI opened Defect Petition DP21-003 to evaluate the petitioner?s request. ODI performed trend analyses of the VOQs related to vehicle speed control issues for all the subject vehicles and found that none of the 52 Model/Model Year Hyundai/Kia vehicles demonstrated any actionable trend that warranted an investigation.Petitioners submitted 1119 VOQs and non-VOQ cases in which sudden uncommanded acceleration (SUA) or loss of motive power (LOMP) incidents were alleged.For the 1119 reports, 220 were incidents involving crashes, from which 69 subject Hyundai-Kia vehicles were inspected by Hyundai/Kia dealer technicians, Hyundai/Kia engineers, and/or third-party representatives.ODI found the inspections identified no vehicle defects related to the ETC system.Of the 220 crash-involved reports, 13 Event Data Recorder (EDR) records were downloaded successfully and 11 of those indicated driver error: (i.e.) pedal misapplication.A condition where the accelerator pedal is mistakenly applied instead of the brake pedal when the driver wants to stop the vehicle.In addition, ODI reviewed a scientific journal paper published in Forensic Science International in 2016 by Mr. Park et al ., as well as related test videos. ODI does not believe there is any evidence of uncontrollable SUA occurrences in any of the tests reviewed. NHTSA's Office of Vehicle Safety Compliance (OVSC) reviewed the allegations regarding the potential noncompliance with Federal Motor Vehicle Safety Standard No. 124.Based on the information provided, the Agency concludes there is insufficient information for us to determine if a possible non-compliance exists.Finally, both Hyundai and Kia informed ODI that all their vehicles manufactured after 2012 were equipped with an ETC management system, in which the engine speed will go to idle when the system sees signals from both the brake pedal and accelerator pedal at the same time; this is commonly known as the brake-throttle override system.After thoroughly assessing the material submitted by the petitioner, information already in NHTSA's possession, information submitted by Hyundai and Kia in response to an Information Request letter, and the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that a formal investigation is warranted. After full consideration of appropriate factors, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA?s reasons for denial of the petition will be published.