The contact owns a 2008 Hyundai Santa Fe. The contact stated that after a visual inspection of underneath the vehicle, he observed excessive corrosion on the subframe. The vehicle was taken to the dealer, who confirmed the excessive corrosion of the subframe. The vehicle was not repaired. The manufacturer was notified of the fai…
Read full complaint
The contact owns a 2008 Hyundai Santa Fe. The contact stated that after a visual inspection of underneath the vehicle, he observed excessive corrosion on the subframe. The vehicle was taken to the dealer, who confirmed the excessive corrosion of the subframe. The vehicle was not repaired. The manufacturer was notified of the failure but did not assist. The failure mileage was 205,000.
NHTSA ODI #11574445
Mileage unknown · Dec 4, 2023
StructureSuspension
Rusted out subframe, less than 95k miles. No “salt belt” treatment offered to this vehicle. Vehicle in Ohio since bought. Took to dealer for engine recall, found $1200 subframe replacement bill. Car was garage stored all of the time.
NHTSA ODI #11558440
Mileage unknown · Aug 28, 2023
Structure
Car is unsafe to drive due to rusted out frame. The car has less than 100,000 miles on it.
NHTSA ODI #11541267
Mileage unknown · Jun 20, 2023
Structure
2008 HYUNDAI SANTA FE- The car goes to the dealer every 6 months for the grease and oil and then the New York State Inspection every November. That car has been up on the lifts numerous times since 2008 and I am now just being informed the undercarriage - driver side frame was rotted. I don't think the frame could have rotted ou…
Read full complaint
2008 HYUNDAI SANTA FE- The car goes to the dealer every 6 months for the grease and oil and then the New York State Inspection every November. That car has been up on the lifts numerous times since 2008 and I am now just being informed the undercarriage - driver side frame was rotted. I don't think the frame could have rotted out since my last inspection in November of 2022. I found the recall was from 2017 campaign #947.I was never notified of this recall, I feel Hyundai has put me as risk to be involved in an accident if the undercarriage falls out. If it was a warranty job back in 2017 I would have been covered as I had a 10 year warranty which would have expired November 2018. Hyundai should repair the vehicle at no cost to me as I was never notified of of the recall for service campaign 947 and I would have been covered under the 1O year warranty . This was negligence on Hyundai's behalf I might not have this problem if the service campaign #947 was performed in 2017 / 2018. If they knew the campaign was out there it should have been completed with one my New York State Inspections in November of of 2017 or 2018. This question goes to Hyundai- on the invoice it states LIFETIME OIL CHANGES - why was I charged $19.98? I asked the service advisor and his was reply was we got bought out and no more free oil changes. Not a good answer - I should be grandfathered in and refunded the $21.55.
NHTSA ODI #11527887
Mileage unknown · May 25, 2022
Structure
I noticed a Crack in the lower part of the windshield on the driver's side. I was told by Safelite there was rust around the windshield and they would not replace the windshield unless the rust was repaired.
NHTSA ODI #11466133
72,000 miles · Nov 29, 2021
StructureSuspension
The contact owns a 2008 Hyundai Santa Fe. The contact stated that while reversing out of his driveway at 1 MPH, the front end on the passenger’s side of the vehicle collapsed almost causing the wheel to detach. The contact stated there was no warning light illuminated. There was no injury sustained. The contact had the vehicle t…
Read full complaint
The contact owns a 2008 Hyundai Santa Fe. The contact stated that while reversing out of his driveway at 1 MPH, the front end on the passenger’s side of the vehicle collapsed almost causing the wheel to detach. The contact stated there was no warning light illuminated. There was no injury sustained. The contact had the vehicle towed to the dealer to be diagnosed. The contact was informed that the control arm and ball joint had shattered. The contact stated that the vehicle remained at the dealer awaiting the arrival of the replacement part. The manufacturer was contacted and provided the contact a case number. The approximate failure mileage was 72,000. Repaired at cost of $1666.67 at Napelton Hyundai 3703 Northlake BLVD Lake Park Florida 33403. The car had a faulty fuel gauge which could NOT be repaired after 3 attempts. Car also experienced loss of power brakes and power steering while driving on the highway.
NHTSA ODI #11441983
Mileage unknown · Dec 12, 2020
SeatsStructureSuspension
PRIOR TO CONTACTING NHTSA WE CONTACTED HYUNDAI AND INFORMED THEM THAT THE BOTTOM OF THE VEHICLE HAS RUSTED THROUGH AND WE CAN SEE THE BOTTOM OF THE INTERIOR IN THIS VEHICLE WHEN THE CAR IS ON A LIFT (THIS WAS POINTED OUT TO US BY A THIRD PARTY REPAIR SHOP AND NOT THE DEALER). IT APPEARS THAT HYUNDAI MAY BE CONCEALING DATA FROM N…
Read full complaint
PRIOR TO CONTACTING NHTSA WE CONTACTED HYUNDAI AND INFORMED THEM THAT THE BOTTOM OF THE VEHICLE HAS RUSTED THROUGH AND WE CAN SEE THE BOTTOM OF THE INTERIOR IN THIS VEHICLE WHEN THE CAR IS ON A LIFT (THIS WAS POINTED OUT TO US BY A THIRD PARTY REPAIR SHOP AND NOT THE DEALER). IT APPEARS THAT HYUNDAI MAY BE CONCEALING DATA FROM NHTSA REGARDING CORROSION PROBLEMS ON ITS VEHICLES. WHAT IS CLEAR IS THAT HYUNDAI IS SHIRKING ITS SAFETY OBLIGATIONS AND WILL NOT COVER CORROSION, REGARDLESS OF WHETHER IT IS FUNCTIONAL OR SAFETY, IF THE WARRANTY HAS EXPIRED. BASED ON PRIOR DEALINGS WITH NHTSA I KNOW THAT RECALLS ARE NOT LIMITED TO THE WARRANTY PERIOD IF VEHICLE SAFETY IS IN QUESTION. WHEN WE CONTACTED HYUNDAI, THEIR EXCUSE FOR WHY THE VEHICLE HAD A MASSIVE HOLE IN THE UNDERCARRIAGE WAS THAT THE VEHICLE IS DRIVEN PRIMARILY IN ILLINOIS AND ILLINOIS USES SALT ON THE ROADS IN WINTER. IF I'M NOT MISTAKEN, MORE THAN HALF OF THE VEHICLES IN THE US ARE DRIVEN ON ROADS THAT ARE SALTED IN THE WINTER. THIS EXCUSE IS SIMPLY NOT ACCEPTABLE AND PERHAPS NHTSA NEEDS TO PROHIBIT HYUNDAI FROM SELLING VEHICLES IN THE NORTHERN HALF OF THE US IF THIS IS GOING TO BE HYUNDAI'S ATTITUDE. I'VE NEVER HAD THIS PROBLEM WITH ANY OTHER MANUFACTURER.
NHTSA ODI #11383146
80,000 miles · Nov 16, 2020
StructureSuspensionWheels
I WAS BACKING UP TO TURN AROUND AND AS I WAS TURNING MY STEERING WHEEL I HEARD AND FELT VERY LOUD PULSING THUMPS COMING FROM THE FRONT OF THE VEHICLE. I GOT OUT AND SAW MY DRIVERS SIDE FRONT WHEEL WAS LEANING OUT FROM THE VEHICLE. THE ARM BROKE OF FROM MY WHEEL ALSO I FOUND OUT WHEN I HAD IT REPAIRED THE AXEL ALSO BROKE!! GOO…
Read full complaint
I WAS BACKING UP TO TURN AROUND AND AS I WAS TURNING MY STEERING WHEEL I HEARD AND FELT VERY LOUD PULSING THUMPS COMING FROM THE FRONT OF THE VEHICLE. I GOT OUT AND SAW MY DRIVERS SIDE FRONT WHEEL WAS LEANING OUT FROM THE VEHICLE. THE ARM BROKE OF FROM MY WHEEL ALSO I FOUND OUT WHEN I HAD IT REPAIRED THE AXEL ALSO BROKE!! GOOD THING I WASN'T ON A HIGHWAY OR DRIVING I OR OTHERS MIGHT HAVE BEEN HURT OR WORSE!!!
NHTSA ODI #11374889
80,000 miles · May 9, 2020
Structure
FRONT SUB FRAME IS RUSTING SEVERELY. LAST INSPECTION WAS MARGINAL. INSPECTOR SAID IT PROBABLY WON'T PASS INSPECTION AT THE NEXT INTERVAL TIME. *TR
NHTSA ODI #11323946
135,000 miles · Nov 6, 2019
Structure
TL* THE CONTACT OWNS A 2008 HYUNDAI SANTA FE. THE CONTACT TOOK THE VEHICLE TO WRIGHT HYUNDAI (10677 PERRY HWY, WEXFORD, PA 15090) BECAUSE HE HEARD SQUEAKING NOISES COMING FROM THE FRONT END OF THE VEHICLE. THE CONTACT WAS INFORMED THAT THERE WAS A HOLE IN THE FRAME OF THE VEHICLE. THE CONTACT QUESTIONED THE DEALER ABOUT THE NOIS…
Read full complaint
TL* THE CONTACT OWNS A 2008 HYUNDAI SANTA FE. THE CONTACT TOOK THE VEHICLE TO WRIGHT HYUNDAI (10677 PERRY HWY, WEXFORD, PA 15090) BECAUSE HE HEARD SQUEAKING NOISES COMING FROM THE FRONT END OF THE VEHICLE. THE CONTACT WAS INFORMED THAT THERE WAS A HOLE IN THE FRAME OF THE VEHICLE. THE CONTACT QUESTIONED THE DEALER ABOUT THE NOISES, BUT NO DIAGNOSTIC TEST WAS RENDERED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND PROVIDED CASE NUMBER: 326790. THE MANUFACTURER OFFERED A BUYBACK ABOVE THE KBB VEHICLE VALUE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 135,000.
Hyundai Motor Company (Hyundai) is recalling certain model year 2006-2009 Accent, model year 2007-2011 Azera, Sonata and Sante Fe,2006-2011 Tucson, 2009-2011 Elantra Touring, 2007-2010 Elantra, 2008-2011 Veracruz, 2009-2011 Genesis, 2010-2011 Genesis Coupe, 2007-2008 Entourage, and 2006-2008 Tiburon vehicles. Originally, in April 2013, Hyundai recalled 1,059,824 model year 2007-2009 Accent and Tucson, model year 2007-2010 Elantra, model year 2007-2011 Santa Fe, model year 2008-2009 Veracruz, model year 2010-2011 Genesis Coupe, and model year 2011 Sonata vehicles. In September 2013, Hyundai informed the agency that it was adding more vehicles to this campaign, representing an additional 652,512 units. The total number of vehicles being recalled is now 1,712,336. In the affected vehicles, the stop lamp switch may malfunction. A malfunctioning stop lamp switch may cause the brake lights to not illuminate when the brake pedal is depressed or may cause an inability to deactivate the cruise control by depressing the brake pedal. Additionally, a malfunctioning stop lamp switch may also result in intermittent operation of the push-button start feature, affect the operation of the brake transmission shift interlock feature, preventing the shifter from being moved out of the PARK position and cause the Electronic Stability Control (ESC) malfunction light to illuminate.
Consequence & remedy
Consequence: Failure to illuminate the stop lamps during braking or inability to disengage the cruise control could increase the risk of a crash. Additionally, when the ignition is in the 'ON' position, the transmission shifter may be able to be moved out of Park without first applying the brake. This may lead to unintentional movement of the car which may increase the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will replace the stop lamp switch, free of charge. The safety recall began on April 22, 2013. Owners may contact Hyundai at 1-800-633-5151. Hyundai's recall campaign number is 110.
Hyundai is recalling certain model year 2007 through 2009 Santa Fe vehicles manufactured from April 19, 2006, through July 7, 2008. The occupant classification system (OCS) may need recalibration to accurately detect small statured adults.
Consequence & remedy
Consequence: Improper classification or detection may cause the front passenger airbag not to deploy in the event of a crash, increasing the risk of injury to the front passenger.
Remedy: Hyundai will notify owners, and dealers will update the classification software free of charge. The safety recall began on September 7, 2012. Owners may contact Hyundai at 1-800-633-5151.
HYUNDAI IS RECALLING CERTAIN MODEL YEAR 2007-2008 HYUNDAI VERACRUZ VEHICLES MANUFACTURED FROM DECEMBER 26, 2006, THROUGH MARCH 21, 2008, AND MODEL YEAR 2007-2008 HYUNDAI SANTA FE VEHICLES MANUFACTURED FROM APRIL 19, 2006 THROUGH MARCH 20, 2008. THE CLOCK SPRING CONTACT ASSEMBLY FOR THE DRIVER'S AIR BAG SUPPLEMENTAL RESTRAINT SYSTEM (SRS) MAY BECOME DAMAGED THROUGH USAGE OVER TIME. THE DRIVER'S AIR BAG ELECTRICAL CIRCUIT WILL EXPERIENCE A HIGH RESISTANCE CONDITION, POTENTIALLY CAUSING THE DRIVER'S AIR BAG TO NOT DEPLOY.
Consequence & remedy
Consequence: IF THE CLOCK SPRING DEVELOPS HIGH RESISTANCE, IN THE EVENT OF A CRASH, THE DRIVERS AIR BAG WILL NOT DEPLOY AND WILL NOT BE ABLE TO PROPERLY PROTECT THE DRIVER, INCREASING THE RISK OF INJURIES.
Remedy: HYUNDAI DEALERS WILL REPLACE THE VEHICLE'S DRIVER'S AIR BAG CLOCK SPRING CONTACT ASSEMBLY FREE OF CHARGE. THE SAFETY RECALL BEGAN IN NOVEMBER 2011. OWNERS MAY CONTACT HYUNDAI CUSTOMER CONNECT CENTER AT 1-800-633-5151.
HYUNDAI IS RECALLING 88,943 MY 2007-2008 HYUNDAI SANTA FE VEHICLES EQUIPPED WITH P235/60R18 TIRES. THESE VEHICLES FAIL TO COMPLY WITH THE LABELING REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110 "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES." THE BLACK CERTIFICATION LABEL AFFIXED TO THE DRIVER'S SIDE CENTER PILLAR, INCORRECTLY LISTS THE GROSS AXLE WEIGHT RATINGS (GAWR).
Consequence & remedy
Consequence: OVERLOADING YOUR VEHICLE MAY ADVERSELY AFFECT HANDLING AND BRAKING AND MAY CAUSE TIRE DAMAGE, RESULTING IN TIRE FAILURE AND A CRASH WITHOUT WARNING.
Remedy: HYUNDAI WILL MAIL CORRECTED CERTIFICATION LABELS ALONG WITH THE INSTRUCTIONS TO THE AFFECTED OWNERS. THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 5, 2008. OWNERS MAY CONTACT HYUNDAI AT 1-800-633-5151.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
DP21003 · Throttle Control System Vulnerabilities
Opened Nov 12, 2021 · Closed Jun 20, 2023
Status: closed (inferred from source dates) · Vehicle Speed Control:throttle
The Office of Defects Investigation (ODI) of the National Highway Traffic Safety Administration (NHTSA) received a petition letter dated October 10, 2021, requesting an investigation of possible defects in the electronic throttle control (ETC) system on certain Kia vehicles resulting in the opening of DP21-003. Accordingly, Model Year (MY) 2005-2016 Kia Optima/K5, MY 2006-2015 Kia Sorento, MY 2007-2016 Hyundai Elantra, MY 2007-2016 Hyundai Santa Fe, MY 2006-2015 Hyundai Sonatas are all part of the subject population. The petition was originally filed as a Vehicle Owner Questionnaire that can be reviewed at NHTSA.gov under reference (ODI) number 11439675.On November 12, 2021, ODI opened Defect Petition DP21-003 to evaluate the petitioner?s request. ODI performed trend analyses of the VOQs related to vehicle speed control issues for all the subject vehicles and found that none of the 52 Model/Model Year Hyundai/Kia vehicles demonstrated any actionable trend that warranted an investigation.Petitioners submitted 1119 VOQs and non-VOQ cases in which sudden uncommanded acceleration (SUA) or loss of motive power (LOMP) incidents were alleged.For the 1119 reports, 220 were incidents involving crashes, from which 69 subject Hyundai-Kia vehicles were inspected by Hyundai/Kia dealer technicians, Hyundai/Kia engineers, and/or third-party representatives.ODI found the inspections identified no vehicle defects related to the ETC system.Of the 220 crash-involved reports, 13 Event Data Recorder (EDR) records were downloaded successfully and 11 of those indicated driver error: (i.e.) pedal misapplication.A condition where the accelerator pedal is mistakenly applied instead of the brake pedal when the driver wants to stop the vehicle.In addition, ODI reviewed a scientific journal paper published in Forensic Science International in 2016 by Mr. Park et al ., as well as related test videos. ODI does not believe there is any evidence of uncontrollable SUA occurrences in any of the tests reviewed. NHTSA's Office of Vehicle Safety Compliance (OVSC) reviewed the allegations regarding the potential noncompliance with Federal Motor Vehicle Safety Standard No. 124.Based on the information provided, the Agency concludes there is insufficient information for us to determine if a possible non-compliance exists.Finally, both Hyundai and Kia informed ODI that all their vehicles manufactured after 2012 were equipped with an ETC management system, in which the engine speed will go to idle when the system sees signals from both the brake pedal and accelerator pedal at the same time; this is commonly known as the brake-throttle override system.After thoroughly assessing the material submitted by the petitioner, information already in NHTSA's possession, information submitted by Hyundai and Kia in response to an Information Request letter, and the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that a formal investigation is warranted. After full consideration of appropriate factors, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA?s reasons for denial of the petition will be published.
2008 Hyundai Santa Fe Problems, Complaints & Recalls | Skip That Year
Illustration