NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
74 reportsClear category filter50,945 miles · Nov 3, 2016
Electrical SystemFuel/propulsion System
AFTER A PERIOD OF TIME WHERE I NOTICED THE FUEL GAUGE ACTING ERRATICALLY (OCCASIONALLY WIDELY SWINGING) THE CHECK ENGINE LIGHT EVENTUALLY ILLUMINATED. DEALER SERVICE FOUND CODE P0464: "INSPECTED CLUSTER FOR ANY LOOSE CONNECTIONS OR DAMAGE, NO ISSUE FOUND WITH CLUSTER OR WIRING. REMOVED THE SENDING UNITS AND FOUND SEND UNITS OUT …
Read full complaint
AFTER A PERIOD OF TIME WHERE I NOTICED THE FUEL GAUGE ACTING ERRATICALLY (OCCASIONALLY WIDELY SWINGING) THE CHECK ENGINE LIGHT EVENTUALLY ILLUMINATED. DEALER SERVICE FOUND CODE P0464: "INSPECTED CLUSTER FOR ANY LOOSE CONNECTIONS OR DAMAGE, NO ISSUE FOUND WITH CLUSTER OR WIRING. REMOVED THE SENDING UNITS AND FOUND SEND UNITS OUT OF SPEC WHEN MOVING BY HAND AND OHM SENDERS. REPLACED BOTH SENDING UNITS AND CLEARED CODES." *TR
NHTSA ODI #10923989
83,000 miles · Nov 2, 2016
Electrical SystemFuel/propulsion System
MY VEHICLE HAS HAD A FUEL GAUGE THAT WOULD MOVE UP AND DOWN WHILE CAR IS STILL. TODAY THE CHECK ENGINE LIGHT CAME ON WITH A CODE P0464-FUEL LEVEL SENSOR. THE FUEL IN VEHICLE IS AT HALF AND THE GAUGE WOULD GO ALL THE WAY TO EMPTY (WITH EMPTY LIGHT COMING ON) THEN IT WOULD GO BACK TO HALF AND MOVE EVERY NOW AND THEN. THE VEHICL…
Read full complaint
MY VEHICLE HAS HAD A FUEL GAUGE THAT WOULD MOVE UP AND DOWN WHILE CAR IS STILL. TODAY THE CHECK ENGINE LIGHT CAME ON WITH A CODE P0464-FUEL LEVEL SENSOR. THE FUEL IN VEHICLE IS AT HALF AND THE GAUGE WOULD GO ALL THE WAY TO EMPTY (WITH EMPTY LIGHT COMING ON) THEN IT WOULD GO BACK TO HALF AND MOVE EVERY NOW AND THEN. THE VEHICLE IS AT 83000. SO FAR THE THE GAUGE IS SOMEWHAT WORKING BUT IS VERY FRUSTRATING KNOWING THAT THIS CAN BE A $500 REPAIR SINCE IT WILL INVOLVE THE GAS TANK. THIS CAN MAKE FOR A BAD SITUATION IF THE GAUGE COMPLETELY FAILS.
NHTSA ODI #10923938
143,000 miles · Oct 18, 2016
Electrical SystemEngineFuel/propulsion System
TL* THE CONTACT OWNS A 2008 HYUNDIA SANTA FE. WHILE OPERATING THE VEHICLE, THE CHECK ENGINE INDICATOR ILLUMINATED AND THE FUEL GAUGE INDICATOR PROVIDED FALSE READINGS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 143,000.
NHTSA ODI #10916743
94,000 miles · Oct 17, 2016
Electrical SystemFuel/propulsion System
A PROBLEM IS REGARDING FUEL GAUGE FAILURE /CHECK ENGINE LIGHT. CHECK ENGINE LIGHT COMES ON ,GOES OFF ,FUEL GAUGE REGISTER ON EMPTY WITH LIGHT INDICATOR ANYTIME TANK IS LESS THAN FULL.
NHTSA ODI #10916475
110,000 miles · Sep 23, 2016
Electrical System
MY MOTHER PURCHASED A 2008 HYUNDAI SANTA FE, AWD 2.7L V6 MODEL BRAND NEW IN 2009. HER FUEL GAUGE FAILED AT AROUND 110,000 MILES APPROX. I NOTICED OTHER PEOPLE COMPLAINING ABOUT THE SAME ISSUE...SO I THOUGHT I'D MENTION THAT HER FUEL GAUGE ALSO QUIT WORKING! SHE TOOK IT IN TO GET FIXED, AND I BELIEVE IT WAS A PRETTY COSTLY JOB! M…
Read full complaint
MY MOTHER PURCHASED A 2008 HYUNDAI SANTA FE, AWD 2.7L V6 MODEL BRAND NEW IN 2009. HER FUEL GAUGE FAILED AT AROUND 110,000 MILES APPROX. I NOTICED OTHER PEOPLE COMPLAINING ABOUT THE SAME ISSUE...SO I THOUGHT I'D MENTION THAT HER FUEL GAUGE ALSO QUIT WORKING! SHE TOOK IT IN TO GET FIXED, AND I BELIEVE IT WAS A PRETTY COSTLY JOB! MAYBE WITH EVERYBODY PUTTING THEIR HEADS TOGETHER, THIS ISSUE CAN GET MORE ATTENTION AND POSSIBLY LEAD TO A RECALL. THANKS!
NHTSA ODI #10909383
135,542 miles · Aug 30, 2016
Electrical SystemElectronic Stability Control (esc)
ESC LIGHT ILLUMINATES. CAR LOOSES POWER WHILE DRIVING, AND STALLS.
NHTSA ODI #10899509
110,000 miles · Jun 20, 2016
Electrical SystemService BrakesFire
TL* THE CONTACT OWNS A 2008 HYUNDAI SANTA FE. WHILE DRIVING 60 MPH, THE BRAKES FAILED TO DISENGAGE AFTER THE BRAKE PEDAL WAS DEPRESSED AND A BURNING ODOR WAS NOTICED. THE ANTI-LOCK BRAKING SYSTEM AND THE ELECTRONIC STABILITY CONTROL WARNING LIGHT ILLUMINATED. THE CONTACT PULLED OVER TO THE SIDE OF THE ROAD AND NOTICED SMOKE COMI…
Read full complaint
TL* THE CONTACT OWNS A 2008 HYUNDAI SANTA FE. WHILE DRIVING 60 MPH, THE BRAKES FAILED TO DISENGAGE AFTER THE BRAKE PEDAL WAS DEPRESSED AND A BURNING ODOR WAS NOTICED. THE ANTI-LOCK BRAKING SYSTEM AND THE ELECTRONIC STABILITY CONTROL WARNING LIGHT ILLUMINATED. THE CONTACT PULLED OVER TO THE SIDE OF THE ROAD AND NOTICED SMOKE COMING FROM ALL FOUR TIRES. THE CONTACT LEFT THE VEHICLE IDLING FOR AWHILE AND THE SMOKE STOPPED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE HYDRAULIC AND ELECTRICAL CONTROL UNITS FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 110,000.
NHTSA ODI #10875338
54,000 miles · Mar 17, 2016
Electrical SystemEngine
TL* THE CONTACT OWNS A 2008 HYUNDAI SANTA FE. THE CONTACT STATED THAT THE SPEEDOMETER WAS READING EMPTY AND ALL OVER THE PLACE. THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 54,000. UPDATED 05/10/1…
Read full complaint
TL* THE CONTACT OWNS A 2008 HYUNDAI SANTA FE. THE CONTACT STATED THAT THE SPEEDOMETER WAS READING EMPTY AND ALL OVER THE PLACE. THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 54,000. UPDATED 05/10/16*LJ *TR
NHTSA ODI #10850231
134,000 miles · Feb 22, 2016
Electrical SystemEngineService Brakes
WHEN DRIVING AND YOU HIT THE BREAKS, THE VEHICLE ATTEMPTS TO STALL, OR IF YOU USE THE HIGH OR LOW BREAMS THE RADIO SHUTS OFF AND THE GPS TURNS ON OR YOU LOSES IT ALL, WHILE ON HIGH WAY WAY IF YOU USE YOUR HIGH OR LOW BEAMS THE ENGINE STARTS TO STALL THEN KEEPS GOING CAUSING THE VEHICLE BEHIND YOU HAVE TO BREAK QUICKLY TO AVOID …
Read full complaint
WHEN DRIVING AND YOU HIT THE BREAKS, THE VEHICLE ATTEMPTS TO STALL, OR IF YOU USE THE HIGH OR LOW BREAMS THE RADIO SHUTS OFF AND THE GPS TURNS ON OR YOU LOSES IT ALL, WHILE ON HIGH WAY WAY IF YOU USE YOUR HIGH OR LOW BEAMS THE ENGINE STARTS TO STALL THEN KEEPS GOING CAUSING THE VEHICLE BEHIND YOU HAVE TO BREAK QUICKLY TO AVOID HITTING YOU AS YOU LOOSE ALL POWER FOR A MATTER OF SECONDS THIS HAPPEN WHILE MOVING OR PARKED, I MHAVE INSTALLED TWO NEW ALTERNATORS IN THE PAST THREE WEEKS AND THE PROBLEM CONIINUES
NHTSA ODI #10837613
120,002 miles · Feb 22, 2016
Electrical SystemSeatsFireInjury
TL* THE CONTACT OWNS A 2008 HYUNDAI SANTA FE. WHILE DRIVING 45 MPH, THE PASSENGER SIDE SEAT BECAME EXCESSIVELY HOT. THE PASSENGER OBSERVED THAT THE SEAT WAS ON FIRE. A FIRE REPORT WAS NOT FILED. THE CONTACT EXTINGUISHED THE FIRE. THE PASSENGER SUSTAINED BURN INJURIES TO HER HANDS AND BUTTOCKS BUT DID NOT RECEIVE MEDICAL ATTENTIO…
Read full complaint
TL* THE CONTACT OWNS A 2008 HYUNDAI SANTA FE. WHILE DRIVING 45 MPH, THE PASSENGER SIDE SEAT BECAME EXCESSIVELY HOT. THE PASSENGER OBSERVED THAT THE SEAT WAS ON FIRE. A FIRE REPORT WAS NOT FILED. THE CONTACT EXTINGUISHED THE FIRE. THE PASSENGER SUSTAINED BURN INJURIES TO HER HANDS AND BUTTOCKS BUT DID NOT RECEIVE MEDICAL ATTENTION. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 120,002.
NHTSA ODI #10837542
Official recalls
4Apr 1, 2013
Hyundai Motor Company (Hyundai) is recalling certain model year 2006-2009 Accent, model year 2007-2011 Azera, Sonata and Sante Fe,2006-2011 Tucson, 2009-2011 Elantra Touring, 2007-2010 Elantra, 2008-2011 Veracruz, 2009-2011 Genesis, 2010-2011 Genesis Coupe, 2007-2008 Entourage, and 2006-2008 Tiburon vehicles. Originally, in April 2013, Hyundai recalled 1,059,824 model year 2007-2009 Accent and Tucson, model year 2007-2010 Elantra, model year 2007-2011 Santa Fe, model year 2008-2009 Veracruz, model year 2010-2011 Genesis Coupe, and model year 2011 Sonata vehicles. In September 2013, Hyundai informed the agency that it was adding more vehicles to this campaign, representing an additional 652,512 units. The total number of vehicles being recalled is now 1,712,336. In the affected vehicles, the stop lamp switch may malfunction. A malfunctioning stop lamp switch may cause the brake lights to not illuminate when the brake pedal is depressed or may cause an inability to deactivate the cruise control by depressing the brake pedal. Additionally, a malfunctioning stop lamp switch may also result in intermittent operation of the push-button start feature, affect the operation of the brake transmission shift interlock feature, preventing the shifter from being moved out of the PARK position and cause the Electronic Stability Control (ESC) malfunction light to illuminate.
Consequence & remedy
Consequence: Failure to illuminate the stop lamps during braking or inability to disengage the cruise control could increase the risk of a crash. Additionally, when the ignition is in the 'ON' position, the transmission shifter may be able to be moved out of Park without first applying the brake. This may lead to unintentional movement of the car which may increase the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will replace the stop lamp switch, free of charge. The safety recall began on April 22, 2013. Owners may contact Hyundai at 1-800-633-5151. Hyundai's recall campaign number is 110.
Jul 25, 2012
Hyundai is recalling certain model year 2007 through 2009 Santa Fe vehicles manufactured from April 19, 2006, through July 7, 2008. The occupant classification system (OCS) may need recalibration to accurately detect small statured adults.
Consequence & remedy
Consequence: Improper classification or detection may cause the front passenger airbag not to deploy in the event of a crash, increasing the risk of injury to the front passenger.
Remedy: Hyundai will notify owners, and dealers will update the classification software free of charge. The safety recall began on September 7, 2012. Owners may contact Hyundai at 1-800-633-5151.
Sep 9, 2011
HYUNDAI IS RECALLING CERTAIN MODEL YEAR 2007-2008 HYUNDAI VERACRUZ VEHICLES MANUFACTURED FROM DECEMBER 26, 2006, THROUGH MARCH 21, 2008, AND MODEL YEAR 2007-2008 HYUNDAI SANTA FE VEHICLES MANUFACTURED FROM APRIL 19, 2006 THROUGH MARCH 20, 2008. THE CLOCK SPRING CONTACT ASSEMBLY FOR THE DRIVER'S AIR BAG SUPPLEMENTAL RESTRAINT SYSTEM (SRS) MAY BECOME DAMAGED THROUGH USAGE OVER TIME. THE DRIVER'S AIR BAG ELECTRICAL CIRCUIT WILL EXPERIENCE A HIGH RESISTANCE CONDITION, POTENTIALLY CAUSING THE DRIVER'S AIR BAG TO NOT DEPLOY.
Consequence & remedy
Consequence: IF THE CLOCK SPRING DEVELOPS HIGH RESISTANCE, IN THE EVENT OF A CRASH, THE DRIVERS AIR BAG WILL NOT DEPLOY AND WILL NOT BE ABLE TO PROPERLY PROTECT THE DRIVER, INCREASING THE RISK OF INJURIES.
Remedy: HYUNDAI DEALERS WILL REPLACE THE VEHICLE'S DRIVER'S AIR BAG CLOCK SPRING CONTACT ASSEMBLY FREE OF CHARGE. THE SAFETY RECALL BEGAN IN NOVEMBER 2011. OWNERS MAY CONTACT HYUNDAI CUSTOMER CONNECT CENTER AT 1-800-633-5151.
Jun 19, 2008
HYUNDAI IS RECALLING 88,943 MY 2007-2008 HYUNDAI SANTA FE VEHICLES EQUIPPED WITH P235/60R18 TIRES. THESE VEHICLES FAIL TO COMPLY WITH THE LABELING REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110 "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES." THE BLACK CERTIFICATION LABEL AFFIXED TO THE DRIVER'S SIDE CENTER PILLAR, INCORRECTLY LISTS THE GROSS AXLE WEIGHT RATINGS (GAWR).
Consequence & remedy
Consequence: OVERLOADING YOUR VEHICLE MAY ADVERSELY AFFECT HANDLING AND BRAKING AND MAY CAUSE TIRE DAMAGE, RESULTING IN TIRE FAILURE AND A CRASH WITHOUT WARNING.
Remedy: HYUNDAI WILL MAIL CORRECTED CERTIFICATION LABELS ALONG WITH THE INSTRUCTIONS TO THE AFFECTED OWNERS. THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 5, 2008. OWNERS MAY CONTACT HYUNDAI AT 1-800-633-5151.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1DP21003 · Throttle Control System Vulnerabilities
Opened Nov 12, 2021 · Closed Jun 20, 2023
Status: closed (inferred from source dates) · Vehicle Speed Control:throttle
The Office of Defects Investigation (ODI) of the National Highway Traffic Safety Administration (NHTSA) received a petition letter dated October 10, 2021, requesting an investigation of possible defects in the electronic throttle control (ETC) system on certain Kia vehicles resulting in the opening of DP21-003. Accordingly, Model Year (MY) 2005-2016 Kia Optima/K5, MY 2006-2015 Kia Sorento, MY 2007-2016 Hyundai Elantra, MY 2007-2016 Hyundai Santa Fe, MY 2006-2015 Hyundai Sonatas are all part of the subject population. The petition was originally filed as a Vehicle Owner Questionnaire that can be reviewed at NHTSA.gov under reference (ODI) number 11439675.On November 12, 2021, ODI opened Defect Petition DP21-003 to evaluate the petitioner?s request. ODI performed trend analyses of the VOQs related to vehicle speed control issues for all the subject vehicles and found that none of the 52 Model/Model Year Hyundai/Kia vehicles demonstrated any actionable trend that warranted an investigation.Petitioners submitted 1119 VOQs and non-VOQ cases in which sudden uncommanded acceleration (SUA) or loss of motive power (LOMP) incidents were alleged.For the 1119 reports, 220 were incidents involving crashes, from which 69 subject Hyundai-Kia vehicles were inspected by Hyundai/Kia dealer technicians, Hyundai/Kia engineers, and/or third-party representatives.ODI found the inspections identified no vehicle defects related to the ETC system.Of the 220 crash-involved reports, 13 Event Data Recorder (EDR) records were downloaded successfully and 11 of those indicated driver error: (i.e.) pedal misapplication.A condition where the accelerator pedal is mistakenly applied instead of the brake pedal when the driver wants to stop the vehicle.In addition, ODI reviewed a scientific journal paper published in Forensic Science International in 2016 by Mr. Park et al ., as well as related test videos. ODI does not believe there is any evidence of uncontrollable SUA occurrences in any of the tests reviewed. NHTSA's Office of Vehicle Safety Compliance (OVSC) reviewed the allegations regarding the potential noncompliance with Federal Motor Vehicle Safety Standard No. 124.Based on the information provided, the Agency concludes there is insufficient information for us to determine if a possible non-compliance exists.Finally, both Hyundai and Kia informed ODI that all their vehicles manufactured after 2012 were equipped with an ETC management system, in which the engine speed will go to idle when the system sees signals from both the brake pedal and accelerator pedal at the same time; this is commonly known as the brake-throttle override system.After thoroughly assessing the material submitted by the petitioner, information already in NHTSA's possession, information submitted by Hyundai and Kia in response to an Information Request letter, and the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that a formal investigation is warranted. After full consideration of appropriate factors, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA?s reasons for denial of the petition will be published.
Illustration