2005 Hyundai Santa Fe

STARTED ENGINE. PLACED THE AUTOMATIC TRANSMISSION SELECTION INTO REVERSE. THE ENGINE IMMEDIATELY HAD AN UNINTENDED ACCELERATION TO PERHAPS 2500 RPM. OPERATOR IMMEDIATELY APPLIED VERY HEAVY PRESSURE ON THE BRAKE PEDAL TO STOP ANY REAR DIRECTION MOVEMENT. OPERATOR IMMEDIATELY MOVED THE SHIFT LEVER BACK TO THE PARK POSITION, SHUT OFF THE IGNITION AND RESTARTED THE VEHICLE. AFTER RESTARTING, EVERYTHING WAS BACK TO NORMAL. THIS HAD ALSO OCCURRED ONE OTHER TIME IN SEPTEMBER, 2013 UNDER THE SAME CIRCUMSTANCES. OPERATOR INITIALLY ASSUMED THAT PERHAPS HIS FOOT HAD MOVED TO THE RIGHT AND WAS DEPRESSING BOTH THE ACCELERATOR AND THE BRAKE AT THE SAME TIME, BUT WHEN ATTEMPTING TO SEE IF THIS COULD BE DONE, OPERATOR COULD NOT REPLICATE. IT IS ASSUMED THE THROTTLE SENSOR LOCATOR MAY BE FAULTY. VERY DISTURBING WHEN THIS HAPPENS AND COULD EASILY RESULT IN PROPERTY OR PERSONAL DAMAGE.. *TR

TL* THE CONTACT OWNS A 2005 HYUNDAI SANTA FE. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, HE SMELLED GASOLINE. THE CONTACT DISCOVERED THAT FUEL WAS LEAKING FROM UNDER THE VEHICLE. THE CONTACT TOOK THE VEHICLE TO THE DEALER, WHO REPLACED THE FUEL TANK DUE TO EXCESSIVE CORROSION. THE CONTACT INFORMED THE MANUFACTURER OF THE PROBLEM. THE FAILURE MILEAGE WAS 76,264. UPDATED 12/20/13*CN

THE AIRBAG LIGHT IS ON WHICH WAS DIAGNOSED BY THE DEALER THAT I WOULD HAVE TO REPLACE THE DRIVER SEAT BELT, AND COMPUTER PARTS IN ORDER TO RESET THE AIRBAG LIGHT. THE AIRBAG LIGHT IS ALWAYS ON AND EVENTHOUGH I WEAR MY SEAT BELT THE SYMBOL AND BEEPING NOISE COMES ON STATING I DO NOT HAVE MY SEATBELT ON. THE COST TO FIX THIS PROBLEM IS OVER $500.00. ALSO, THE DRIVER SEAT BELTS HAVE WORN AWAY WHICH HAS DAMAGED MY CLOTHING. *TR

THE RED AIRBAG LIGHT BEGAN TO INTERMITTENTLY TURN ON/OFF FOR NO APPARENT REASON. WHEN AN OCCUPANT IS IN THE FRONT SEAT, THE LIGHT IS GENERALLY OFF, BUT IF THE OCCUPANT MOVES OR CHANGES HIS/HER POSITION IN THE FRONT SEAT, THE LIGHT WOULD ACTIVATE AGAIN, IF ONLY FOR A FEW SECONDS. THE AIRBAG LIGHT IS NOW ON AT ALL TIMES AND WILL NOT SHUT OFF. *TR

TL* THE CONTACT OWNS A 2005 HYUNDAI SANTA FE. THE CONTACT STATED THAT THE OCCUPANT RESTRAINT SYSTEM FAILED. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS TOLD THAT THE SENSOR OF THE SEAT BELT THAT CONNECTED TO THE AIR BAG HAD FAILED. THE CONTACT ASKED IF THE FAILURE WAS THE SAME AS THAT LISTED IN NHTSA CAMPAIGN ID NUMBER: 05V450000 (AIR BAGS). THE CONTACT WAS TOLD THAT ALTHOUGH THE FAILURES WERE THE SAME, THE VEHICLE WAS NOT INCLUDED IN THE RECALL CAMPAIGN. THE FAILURE MILEAGE WAS UNKNOWN, BUT THE CURRENT MILEAGE WAS 95,000. *TR

TL* THE CONTACT OWNS A 2005 HYUNDAI SANTA FE. THE CONTACT STATED THAT THE AIR BAG WARNING LAMP ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE OCS SENSOR ON THE PASSENGER'S SIDE WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 47,300 AND THE CURRENT MILEAGE WAS 47,411. *TR UPDATED 07/16/13*LJ

DRIVING HOME FROM WORK, ON A MAJOR LOCAL INTERSTATE, MY CHECK BRAKE LIGHT APPEARED ON MY DASHBOARD. I PRESSED THE BRAKE PEDAL TO SLOW THE CAR DOWN, BUT FOUND OUT THAT THE BRAKE PEDAL HAD GONE SOFT AND I ENDED UP HAVING TO PUSH THE PEDAL ALL THE WAY TO THE FLOORBOARD TO GET ANY RESISTANCE. I MANAGED TO DRIVE IT TO THE HYUNDAI DEALERSHIP A MILE AWAY WHERE THEY REALIZED THAT THE BRAKE FLUID WAS EMPTY DUE TO A RUPTURED SEAL IN THE BRAKE CALIBER ON THE PASSENGER SIDE. UPON FURTHER INSPECTION, THEY FOUND THAT BOTH FRONT SUSPENSION COIL SPRINGS WERE DAMAGED. THE PASSENGER SIDE COIL HAD LITERALLY SNAPPED IN HALF AND THE DRIVER'S SIDE COIL WAS DISLOCATED AND BROKEN. MY CAR HAD JUST BEEN IN THE SAME DEALERSHIP ONE WEEK PRIOR HAVING A NEW TRANSMISSION INSTALLED IN IT (UNDER WARRANTY). AS NO LOUD BANG OR NOISE OCCURRED AS WITH THE MANY OTHERS THAT HAVE HAD THIS HAPPEN TO THEM, I CAN ONLY ASSUME THE COILS BROKE OR SHIFTED DURING THE TRANSMISSION REPLACEMENT WHEN THE WEIGHT OF THE CAR WAS ON THE LIFT, AND NOT ON THE SUSPENSION. THE GROSS NEGLIGENCE THAT NEITHER OF THESE COILS WERE FOUND BROKEN AT THAT TIME HAS ME INCENSED. THE FACT THAT A SOLID STEEL COIL THAT TAKES 4,000LBS TO COMPRESS CAN BREAK IN HALF LIKE THAT IS DISTURBING. I ASSUME THAT WITHOUT THE SUSPENSION, DUE TO THE BROKEN COILS, THE BRAKES SUFFERED DAMAGE AND THE ABOVE INCIDENT OCCURRED. I WAS VERY LUCKY INDEED THAT NOTHING WORSE HAPPENED, BUT AS THIS IS A RECURRENT ISSUE WITH THE HYUNDAI COIL SUSPENSION AND IT SHOULD BE ADDRESSED THROUGH A RECALL. PICTURES ARE AVAILABLE OF THE DAMAGE, AS ARE THE SUSPENSION COILS (WE SAVED EVERYTHING). *TR