2025 Hyundai Palisade

On XXX at approximately 5:20 PM, I was driving my 2025 Hyundai Palisade in [XXX] near [XXX] and [XXX] when the front sunroof glass suddenly shattered with a loud explosive sound. The outside temperature was approximately 102°F and conditions were sunny. I did not see or hear any object strike the sunroof before the glass failed. There was no collision or other event immediately preceding the failure. The interior sunshade was closed and contained much of the shattered glass. The front sunroof glass was extensively fractured while the surrounding roof and rear roof glass showed no apparent impact damage. I have photographs documenting the condition immediately after the incident. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2025 Hyundai Palisade. The contact stated that the passenger’s side windshield wiper failed to operate as needed. The vehicle was taken to the dealer, where the contact was informed that the part was covered under warranty and the vehicle was repaired. The contact stated that less than a month after the repair, the failure recurred. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was unknown.

I purchased the 2025 CPO Palisade Calligraphy in April 9, 2025. Two weeks after I purchased it, I started noticing abnormal scratches and chips in the windshield. I had not driven behind a vehicle that threw rocks, I was not a beach for sand to scratch, nor had my vehicle been exposed to a creature that could have scratched the windshield. I reached out to my sales person and he said he'd connect back with me. That never happened. A couple months later, after getting my car detailed, I noticed many more scratches and dozens of chips. I reached back out to the dealer and my salesperson had left. I connected with a manager, as the chipping and scratching was causing a safety issue as I was focusing on it while driving and the way the sun would hit it caused awful glares. After speaking with a manager and then general sales manager, they agreed to replace the windshield. It was not until after this situation and my moonroof randomly exploding that I realized there were a number of windshield complaints on Hyundai's, specifically Palisades. While most reports are from 2020, I wanted to report to NTHSB that the issue is still happening.

My windshield appears to be extremely prone to rock chips and cracks. My vehicle is available for inspection. My Hyundai is only a year old and has several rock chips and a large crack in the windshield. This is now beginning to affect the visibility through my windshield. The problem has not been reported to the dealer but it will be on my next service appointment. Im pretty confident that the dealer will tell me to contact my insurance. The problem has not been reported to anyone at this time. My other vehicles do not have this problem and they are a lot older than my Hyundai.

We have had two chips in the windshield in approximately 7 months of ownership, which have resulted in spiderweb type cracks in the windshield. One of the cracks is in the field of view for the driver which creates an impairment/distraction. I believe that the windshield may be defective based on the numerous reports of this issue that I have researched on the internet.

Purchased car new on 01/10/2025. Drove across country to my home without any problems. At 3300 miles, on 02/21/2025, I was entering circular freeway onramp when a horizontal crack about 6 inches long in windshield suddenly appeared midway up on driver's side. No object observed striking glass either visually or audibly. After parking, crack was in outer glass layer with no indication of impact damage, such as spider cracking. Small glass fragments flaked off in area where glass crack originated. Crack has continued expanding horizontally to about 18 inches as of this writing. Crack is in direct line of driver's vision creating distraction. Structural integrity of the glass is now in question. Appears to be a stress induced crack. Due to recent crack, windshield has not yet been inspected by professionals but is available for inspection. Mild temperature in the high 50's and no rapid temperature changes. Car has Heads Up Display (HUD) which I understand has a different windshield from non-HUD models.