2020 Hyundai Palisade

On [XXX], while driving on the freeway, my 2020 Hyundai Palisade suddenly malfunctioned and went up in flames without warning. My young son was in the vehicle with me. Within moments, smoke and fire spread rapidly, forcing us to stop in traffic and escape before the fire fully engulfed the car. The entire vehicle became a total loss. This was a terrifying, life-threatening situation. My safety and my son’s safety were at extreme risk. If my other family members had been in the car, the outcome could have been catastrophic. The emotional trauma from this event is significant and continues to affect us. The incident was reported to the San Antonio Fire Department, who responded to the scene and documented the fire. Their reports confirm the vehicle fire: Incident Report #[XXX] and SAFD Case #[XXX]. After researching, I discovered that similar fires have been reported in Hyundai vehicles, raising concerns that this is part of a wider safety defect. Families should not have to fear their vehicle spontaneously igniting on the road. At the time of the fire, there were no warning lamps, error messages, or symptoms that suggested the vehicle was unsafe. The failure happened suddenly and without warning. The vehicle has not been inspected by Hyundai at this time, but it is available for inspection upon request. I am urging a full investigation into Hyundai’s design and safety practices, as this fire placed lives in immediate danger. This was not just a mechanical failure—it was a potentially fatal event that could have resulted in severe injury or loss of life.

Follow-Up Complaint – Engine Failure on 2020 Hyundai Palisade (VIN: [XXX] ) I am following up on a previous complaint regarding a complete engine failure in my 2020 Hyundai Palisade. I purchased the vehicle from CarMax in 2023 and was never made aware of any known engine issues. I also signed the required Lemon Law disclosure form at purchase, which did not indicate any concerns with the engine. My vehicle experienced a sudden and total engine failure, despite being properly maintained. This failure mirrors the symptoms of engine problems that have led to multiple Hyundai recalls in other models with similar engine configurations. Although my VIN is not included in the current recall list, my engine failure is consistent with those affected, indicating a broader issue that Hyundai has not fully addressed. The engine failed prematurely and unexpectedly, which is both a serious safety hazard and a financial burden. I am now stuck with an inoperable vehicle and costly repair needs due to a failure that appears to stem from a manufacturer defect. This situation reflects a pattern of engine-related issues across Hyundai vehicles. I urge NHTSA to investigate whether the 2020 Palisade should be included in Hyundai’s ongoing or expanded recalls. Hyundai must be held accountable for engine defects—regardless of whether a VIN is currently listed. I am requesting that this matter be escalated and reconsidered. Sincerely, [XXX] VIN: [XXX] Purchased: 2023 from CarMax Mileage at failure: [Insert Approx. Mileage] Phone: [XXX] Email: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My car has been diagnosed, by a dealership, with excessive oil consumption due to a faulty piston ring which caused there to be no compression in cylinder 1. Initially my car had smoke coming from the tailpipe, then it started to shake while idling and the check engine light came on (delearship cleared it), then it overheated on me while going down the road with no warning whatsoever. Each time there was no oil on the lipstick. This is dangerous for people to not have any warning as to when the car is going to overheat until its already overheating. It could potentially set on fire while going down the highway with my [XXX] and [XXX] old. As soon as I put oil in it, it runs totally fine. I have voice recordings to confirm the diagnosis. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Rear suspension making popping sound at low speed. Rear shocks have also seemed not performing properly over potholes at one time causing an error code for the AWD system. Had local dealer make repairs for TSB for this know issue of shock mounting insulators. Vehicle noise was fixed and ride seemed to be improved for about one day then it started making same popping sound again at slow speeds. Assuming rough ride will return shortly.

This vehicle has excessive oil consumption, and the low oil light does not light up to tell you that you are low on oil. I only noticed that I was low on oil because the engine starts knocking and started to stall. I had the oil changed according to all service intervals and at one point the dealership told me my car had no oil left in it. I just had it changed, drove about 2k miles and already had to put more oil in because it didn't even show any oil on the dip stick. This is a safety hazard as well as an environmental problem with these vehicles burning this much oil. This started happening around 80-90k miles on the engine.