I am submitting this complaint regarding a suspected manufacturing defect involving an original equipment Hankook iON evo AS tire installed on my 2026 Hyundai IONIQ 9. At approximately 8,000 miles, and with the vehicle only six months old, the tire developed a severe vibration that increased with vehicle speed, becoming most no…
Read full complaint
I am submitting this complaint regarding a suspected manufacturing defect involving an original equipment Hankook iON evo AS tire installed on my 2026 Hyundai IONIQ 9. At approximately 8,000 miles, and with the vehicle only six months old, the tire developed a severe vibration that increased with vehicle speed, becoming most noticeable above approximately 55 mph. The vibration became progressively worse, raising concerns about the safe operation of the vehicle. A Hyundai dealership inspected the vehicle and determined that the sound-deadening foam attached to the inside of the tire had separated from the tire carcass. The detached foam caused the tire to become significantly out of balance. The tire required replacement. This was not the result of a road hazard, impact, puncture, or normal tire wear. The tire had been used under normal driving conditions and had accumulated only approximately 8,000 miles. Because the vehicle could not be safely driven until repaired, I was required to rent another vehicle while awaiting the repair. Hyundai denied reimbursement for the rental expense because tires are covered under the tire manufacturer's warranty rather than the vehicle warranty. I am concerned that separation of the internal foam on original equipment Hankook iON evo AS tires may represent a manufacturing defect that could affect other vehicles equipped with these tires. A severe imbalance at highway speeds could create a significant safety hazard by impairing vehicle control or distracting the driver. I respectfully request that NHTSA review this issue and determine whether similar failures have been reported and whether further investigation is warranted.
Hyundai Motor America (Hyundai) is recalling certain 2026 Ioniq 9 vehicles equipped with a Limited, Calligraphy, or Calligraphy Design trim package. The second-row power seats may fail to detect a person. As a result, the seats may continue to move after contacting a person during powered seat functions, such as automatic power fold-and-stow.
Consequence & remedy
Consequence: A person, especially a child, may become trapped by a rear powered seat, increasing the risk of injury.
Remedy: Owners are advised to exercise caution when operating the second-row power seat functions until the repair is performed. Children are advised not to be in the rear seats or near the rear seating area during power-folding operation. The seat software will be inspected and updated over-the-air (OTA) or by a dealer, as necessary, free of charge. Owner notification letters are expected to be mailed November 9, 2026. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 307. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on September 12, 2026.
Hyundai Motor America (Hyundai) is recalling certain 2025 Ioniq 5 and 2026 Ioniq 9 vehicles. The fasteners for the rear suspension may loosen and detach, which can result in a loss of vehicle control.
Consequence & remedy
Consequence: A loss of vehicle control increases the risk of a crash.
Remedy: Dealers will inspect and replace the rear suspension fasteners and perform a rear vehicle alignment, as necessary, free of charge. Owner notification letters are expected to be mailed July 17, 2026. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 303. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on May 20, 2026.
Hyundai Motor America (Hyundai) is recalling certain 2025-2026 IONIQ 5 and 2026 IONIQ 9 vehicles. The high voltage battery system may contain an improperly tightened bus bar, which can cause a short-circuit.
Consequence & remedy
Consequence: An electrical short in the high voltage battery system increases the risk of a fire.
Remedy: Dealers will inspect and tighten the bus bar retention bolts and replace the battery system assembly, as necessary, free of charge. Owner notification letters were mailed April 3, 2026. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 294. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on February 7, 2026.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2026 Hyundai Ioniq 9 Problems, Complaints & Recalls | Skip That Year
Illustration