NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
222 reportsMileage unknown · Feb 17, 2026
Electrical SystemEnginePower Train
ICCU failure: confirmed by dealership, submitting for your records - while driving the morning of 2/11/26 in Evansville, IN a warning message appeared on the dashboard stating 'Check Electric Vehicle System' followed by a rapid deceleration. Luckily there was not a vehicle behind me as they would have rear ended me. This failure…
Read full complaint
ICCU failure: confirmed by dealership, submitting for your records - while driving the morning of 2/11/26 in Evansville, IN a warning message appeared on the dashboard stating 'Check Electric Vehicle System' followed by a rapid deceleration. Luckily there was not a vehicle behind me as they would have rear ended me. This failure occurred without warning and presented a significant safety hazard, leaving the vehicle stranded in traffic until I was able to restart it. Vehicle went in to turtle mode upon restart, would not go over 20mph at first then I stopped the car, restarted it again, it would move for 15-20 seconds before going in to turtle mode again and now it will not go over 10mph - interestingly, when I would stop and put it in reverse, the vehicle would move 10-20' and then come to a very abrupt stop as the entire vehicle shut off - had to tow the vehicle to the Hyundai dealership in Evansville Indiana where the ICCU was confirmed has having failed
NHTSA ODI #11718559
Mileage unknown · Feb 17, 2026
Electrical SystemFuel/propulsion System
Car died in neighborhood with electrical issue. Later reported to be an ICCU issue. At this point car has been at dealer service for over 29 days with no date on when it will be repaired.
NHTSA ODI #11718515
Mileage unknown · Feb 17, 2026
Electrical System
The car displayed electrical system warning messages while driving, and it would no longer drive above about 25 mph. The issue was diagnosed as an ICCU failure by the dealership and has been awaiting a backordered ICCU for about 5 weeks.
NHTSA ODI #11718512
Mileage unknown · Feb 17, 2026
Electrical SystemPower Train
“Check electrical system” warning while driving. Sudden loss of power and speed. “Turtle mode” icon. Limped home 2 miles at <10mph. Vehicle bricked. Towed to dealership.
NHTSA ODI #11718494
Mileage unknown · Feb 15, 2026
Unknown Or Other
On January 28th 2026, I got red warning signs on dashboard said: "Stop vehicle and check power supply" and "12V battery voltage low. Stop safely". I was still in the parking lot, so the issue did not pose any safety issue. The vehicle towed to Hyundai dealership. They confirmed and pre-approved "Replace ICCU +fuse". The part is…
Read full complaint
On January 28th 2026, I got red warning signs on dashboard said: "Stop vehicle and check power supply" and "12V battery voltage low. Stop safely". I was still in the parking lot, so the issue did not pose any safety issue. The vehicle towed to Hyundai dealership. They confirmed and pre-approved "Replace ICCU +fuse". The part is on 1 month back order. While the dealership initially did not commit to giving me alternate transportation, I insisted and after 6 days, I was able to get a much lower class and smaller replacement vehicle (Hyundai Venue with entry level trim). My vehicle is a lease. Since I'm paying for enjoying the vehicle amenities for a limited time, and my vehicle will not be available for at least a month, I requested Hyundai to reimburse me (or let me skip) lease payments until my vehicle is usable again. So far, the company has denied my request.
NHTSA ODI #11718124
Mileage unknown · Feb 14, 2026
Electrical SystemFuel/propulsion System
While pulling into traffic the car lost power and went into limp mode risking a collision. Car was immediately backed into driveway and completely died shortly after the initial power loss and had to be towed to dealer. Dealer diagnosed an ICCU failure. Warning lights activated at the moment the car lost power. Had this occur…
Read full complaint
While pulling into traffic the car lost power and went into limp mode risking a collision. Car was immediately backed into driveway and completely died shortly after the initial power loss and had to be towed to dealer. Dealer diagnosed an ICCU failure. Warning lights activated at the moment the car lost power. Had this occurred on a highway or in heavier traffic the power loss and speed with which the car went from fully operational to dead could have had catastrophic consequences.
NHTSA ODI #11717977
Mileage unknown · Feb 13, 2026
Electrical SystemFuel/propulsion System
“Check EV System” error appeared in a red circle, with a red 12v battery icon. Then a turtle icon appeared and the car would not exceed about 30 mph. I was able to drive a mile and park in a lot. This happened after Level 2 charging to 100% and then driving one mile in 25° weather. The car was towed to the dealer.
NHTSA ODI #11717943
Mileage unknown · Feb 12, 2026
Electrical SystemFuel/propulsion System
At approximately 10pm on Saturday night with temps in the single digits and a large snowstorm (that would cripple much of the US for several days) just about to hit, the 1.5 year old vehicle failed completely. Propulsion battery 81% charged, started normally, then gave "check electrical system" warning which upon search can be …
Read full complaint
At approximately 10pm on Saturday night with temps in the single digits and a large snowstorm (that would cripple much of the US for several days) just about to hit, the 1.5 year old vehicle failed completely. Propulsion battery 81% charged, started normally, then gave "check electrical system" warning which upon search can be due to a low 12v battery; call AAA and spouse (live 2hrs away). Began to drive towards a station two blocks away, thinking plugging in may help system warm and/or recharge 12v battery. Car goes into limp mode on road, then dies in four-lane road. Use portable battery jumper, draining it into the 12v battery and able to limp-mode out of traffic and into Walmart parking lot entrance where dies again. With bystander help, push the vehicle across parking lot to chargers; vehicle in total electrical failure w/random lights flashing (tail, dash, etc.) and no command-functions (couldn't shift into park, open charging port). Charged 12v battery from an ICE car 30 minutes w/restoration of command function, but nothing more than limp mode. AAA still hours ETA. Personally swap 12v battery purchased from Walmart w/restoration of power, but abnormal function (lane assist forcing wheel, menus malfunctioning) & warnings remaining. Drive vehicle to -thankfully- nearby dealership before another failure. Abandon vehicle & wait for pickup by spouse, drive last hour in a snowstorm. Very lucky I wasn't stranded on the highway, hit and killed in a snowstorm. Very lucky I wasn't hit and killed in the road where it died. Very lucky I called for help early, wasn't stranded more than 20 minutes in dangerous-cold, didn't wreck in snowstorm getting home. Very lucky the malfunctioning systems did not steer/force me into another vehicle or pedestrian, causing injury or death. Dealership confirmed (longstanding and very well-known) failure of ICCU module that Hyundai refuses to properly address. These are unsafe vehicles, hand-grenades on a timer.
NHTSA ODI #11717548
Mileage unknown · Feb 11, 2026
Electrical SystemExterior LightingFuel/propulsion System
As we drove toward the highway to begin our journey home in our 2024 RWD Ioniq 5 with our entire family and luggage in the vehicle, we received a "Check Electric Vehicle System" warning and immediately pulled over and called Hyundai Roadside Assistance. They initially were going to send someone to jump the car, assuming it was …
Read full complaint
As we drove toward the highway to begin our journey home in our 2024 RWD Ioniq 5 with our entire family and luggage in the vehicle, we received a "Check Electric Vehicle System" warning and immediately pulled over and called Hyundai Roadside Assistance. They initially were going to send someone to jump the car, assuming it was an ICE, but once we said it was an EV, they said they didn't have the equipment to jump an EV. We then spoke to Hyundai Customer Care, and we reported that we received the "Check Electric Vehicle System" warning. The HCC rep said that she did not see any issues with the vehicle on her end, so we would be OK to drive it. We specified that we had a 1.5 hour drive home and asked her explicitly if we would be OK to drive this length of time with this warning and make it home? She again said that we would be OK to drive it. After getting off the phone with her, we proceeded onto the highway and within about 2 minutes, received the "Stop Vehicle and Check Power Supply" warning and then, within a few seconds, began to lose power. This was extremely dangerous, as we were going down a hill on a highway frequented by semi trucks in the rain. Fortunately, we were still able to turn on the hazard lights and coast into a nearby hotel parking lot. As we were losing power, we were afraid we would not be able to get out of the car because all the doors were locked and the windows were up due to the rain, so we quickly unlocked two of the doors as soon as we pulled into the parking lot. One of us then had to stay with the car at all times because we couldn't lock or unlock the car. We eventually had the car towed to the Hyundai dealer closest to us who determined that the ICCU and fuse had failed and needed to be replaced, but they could only replace them with new parts of the same design that could potentially fail again; Hyundai does not yet have a fix for the ICCU failure.
NHTSA ODI #11717409
Mileage unknown · Feb 10, 2026
Electrical System
My vehicle is 1 year old and has 7800 miles on it. I was driving on Friday evening (it was dark) and the vehicle acceleration was greatly reduced. I was about to get onto the highway but the warning light came on that said to have the electrical system checked. I pulled over and got a power limited warning and the vehicle would …
Read full complaint
My vehicle is 1 year old and has 7800 miles on it. I was driving on Friday evening (it was dark) and the vehicle acceleration was greatly reduced. I was about to get onto the highway but the warning light came on that said to have the electrical system checked. I pulled over and got a power limited warning and the vehicle would not drive after that and had to be towed. My toddler was in the car and if this had happened while we were on the highway in the dark I would have had trouble getting off the highway safely. The dealership inspected the car and said the Integrated Charging Control Unit (ICCU) had failed. They stated that there were 16 other cars were on the lot that had to be towed in with the same problem and that the part has been backordered since the beginning of January. I feel Hyundai is underreporting this issue and a recall investigation should be opened. There was no warning of this issue, I had been charging the vehicle and using it normally.
NHTSA ODI #11717102
Official recalls
3Jul 2, 2026
Hyundai Motor America (Hyundai) is recalling certain 2023-2024 Ioniq 5 vehicles. The high voltage battery cells may contain misaligned electrodes, which can lead to a fire while parked or driving.
Consequence & remedy
Consequence: A fire increases the risk of injury.
Remedy: Owners are advised to park outside and away from structures and limit their charge to a maximum of 80% until the recall repair is complete. Dealers will replace the high voltage battery system assembly, free of charge. Owner notification letters are expected to be mailed August 31, 2026. Owners may contact Hyundai's customer service at 855-371-9460. Hyundai's number for this recall is 305. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 3, 2026.
Nov 18, 2024
Hyundai Motor America (Hyundai) is recalling certain 2022-2024 IONIQ 5, 2023-2025 IONIQ 6, Genesis GV60, Genesis GV70 "Electrified," and Genesis G80 "Electrified" vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-volt battery, which can result in a loss of drive power.
Consequence & remedy
Consequence: A loss of drive power increases the risk of a crash.
Remedy: Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed December 20, 2024. Owners may contact Hyundai customer service at 1-855-371-9460 or Genesis customer service at 1-844-340-9741. Hyundai's numbers for this recall are 272 (Hyundai) and 025G (Genesis). This recall expands and replaces previous recall number 24V-204. Vehicles previously repaired under recall 24V-204 will need to have the new remedy completed.
Additional source detail variants (2)
Electrical System:propulsion System:charging:module:software
Hyundai Motor America (Hyundai) is recalling certain 2022-2024 IONIQ 5, 2023-2025 IONIQ 6, Genesis GV60, Genesis GV70 "Electrified," and Genesis G80 "Electrified" vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-volt battery, which can result in a loss of drive power.
Consequence: A loss of drive power increases the risk of a crash.
Remedy: Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed December 20, 2024. Owners may contact Hyundai customer service at 1-855-371-9460 or Genesis customer service at 1-844-340-9741. Hyundai's numbers for this recall are 272 (Hyundai) and 025G (Genesis). This recall expands and replaces previous recall number 24V-204. Vehicles previously repaired under recall 24V-204 will need to have the new remedy completed.
Electrical SYSTEM:12V/24V/48V Battery
Hyundai Motor America (Hyundai) is recalling certain 2022-2024 IONIQ 5, 2023-2025 IONIQ 6, Genesis GV60, Genesis GV70 "Electrified," and Genesis G80 "Electrified" vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-volt battery, which can result in a loss of drive power.
Consequence: A loss of drive power increases the risk of a crash.
Remedy: Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed December 20, 2024. Owners may contact Hyundai customer service at 1-855-371-9460 or Genesis customer service at 1-844-340-9741. Hyundai's numbers for this recall are 272 (Hyundai) and 025G (Genesis). This recall expands and replaces previous recall number 24V-204. Vehicles previously repaired under recall 24V-204 will need to have the new remedy completed.
Mar 15, 2024
Hyundai Motor America (Hyundai) is recalling certain 2022-2024 IONIQ 5, 2023-2024 IONIQ 6, Genesis GV60, Genesis GV70 "Electrified," and Genesis G80 "Electrified" vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-Volt battery, which can result in a loss of drive power.
Consequence & remedy
Consequence: A loss of drive power increases the risk of a crash.
Remedy: This recall is replaced by NHTSA recall number 24V-868. Vehicles already repaired under this recall will need to have the new remedy completed. Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed April 22, 2024. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 257/021G.
Additional source detail variants (2)
Electrical SYSTEM:12V/24V/48V Battery
Hyundai Motor America (Hyundai) is recalling certain 2022-2024 IONIQ 5, 2023-2024 IONIQ 6, Genesis GV60, Genesis GV70 "Electrified," and Genesis G80 "Electrified" vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-Volt battery, which can result in a loss of drive power.
Consequence: A loss of drive power increases the risk of a crash.
Remedy: This recall is replaced by NHTSA recall number 24V-868. Vehicles already repaired under this recall will need to have the new remedy completed. Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed April 22, 2024. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 257/021G.
Electrical System:propulsion System:charging:module:software
Hyundai Motor America (Hyundai) is recalling certain 2022-2024 IONIQ 5, 2023-2024 IONIQ 6, Genesis GV60, Genesis GV70 "Electrified," and Genesis G80 "Electrified" vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-Volt battery, which can result in a loss of drive power.
Consequence: A loss of drive power increases the risk of a crash.
Remedy: This recall is replaced by NHTSA recall number 24V-868. Vehicles already repaired under this recall will need to have the new remedy completed. Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed April 22, 2024. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 257/021G.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE23011 · Loss Of Motive Power
Opened Jun 8, 2023 · Closed Apr 17, 2024
Status: closed (inferred from source dates) · Electrical SYSTEM:12V/24V/48V Battery; Electrical System:propulsion System:dc/dc Converter
On June 8, 2023, the Office of Defect Investigation (ODI) opened PE23011 to investigate allegations of loss of motor power on model year (MY) 2022 Hyundai Ioniq 5 vehicles. Some consumers reported loss of motor power immediately after a warning lamp illumination or reduction of motive power while the vehicle was in motion. This investigation found that the Integrated Charging Control Unit (ICCU) may be subject to various conditions such as overcurrent, overvoltage induced at the end of charging, and certain thermal loading during operation that can damage its internal components and open the ICCU fuse, resulting in an inability to charge the 12-volt battery. The vehicle could eventually lose all motive power, increasing the risk of a crash. In July 2023, Hyundai issued a service campaign to address certain MY 2022-2023 Ioniq 5 and MY 2023 Ioniq 6 vehicles that may have low 12V auxiliary battery charging occurrences due to an ICCU fault and may set the DTC P1A9096 “DC/DC Converter Input Voltage Sensor Fault”. On March 15, 2024, Hyundai filed Safety Recall 24V-204 for 98,878 MY 2022-2024 Hyundai Ioniq 5 vehicles and MY 2023-2024 Hyundai Ioniq 6, Genesis GV60, Genesis GV70 “Electrified” and Genesis G80 “Electrified” vehicles. The recall remedy provides an inspection, and if necessary, a replacement of the ICCU and the associated fuse. The ICCU software reduces the risk of overcurrent and implements voltage peak reduction at the end of EV battery charging. The recall also includes a software update that revises the electric water pump operational threshold to reduce thermal loading during charging and driving. In view of the recall action being taken by Hyundai, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Electrical SYSTEM:12V/24V/48V Battery
On June 8, 2023, the Office of Defect Investigation (ODI) opened PE23011 to investigate allegations of loss of motor power on model year (MY) 2022 Hyundai Ioniq 5 vehicles. Some consumers reported loss of motor power immediately after a warning lamp illumination or reduction of motive power while the vehicle was in motion. This investigation found that the Integrated Charging Control Unit (ICCU) may be subject to various conditions such as overcurrent, overvoltage induced at the end of charging, and certain thermal loading during operation that can damage its internal components and open the ICCU fuse, resulting in an inability to charge the 12-volt battery. The vehicle could eventually lose all motive power, increasing the risk of a crash. In July 2023, Hyundai issued a service campaign to address certain MY 2022-2023 Ioniq 5 and MY 2023 Ioniq 6 vehicles that may have low 12V auxiliary battery charging occurrences due to an ICCU fault and may set the DTC P1A9096 “DC/DC Converter Input Voltage Sensor Fault”. On March 15, 2024, Hyundai filed Safety Recall 24V-204 for 98,878 MY 2022-2024 Hyundai Ioniq 5 vehicles and MY 2023-2024 Hyundai Ioniq 6, Genesis GV60, Genesis GV70 “Electrified” and Genesis G80 “Electrified” vehicles. The recall remedy provides an inspection, and if necessary, a replacement of the ICCU and the associated fuse. The ICCU software reduces the risk of overcurrent and implements voltage peak reduction at the end of EV battery charging. The recall also includes a software update that revises the electric water pump operational threshold to reduce thermal loading during charging and driving. In view of the recall action being taken by Hyundai, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Electrical System:propulsion System:dc/dc Converter
On June 8, 2023, the Office of Defect Investigation (ODI) opened PE23011 to investigate allegations of loss of motor power on model year (MY) 2022 Hyundai Ioniq 5 vehicles. Some consumers reported loss of motor power immediately after a warning lamp illumination or reduction of motive power while the vehicle was in motion. This investigation found that the Integrated Charging Control Unit (ICCU) may be subject to various conditions such as overcurrent, overvoltage induced at the end of charging, and certain thermal loading during operation that can damage its internal components and open the ICCU fuse, resulting in an inability to charge the 12-volt battery. The vehicle could eventually lose all motive power, increasing the risk of a crash. In July 2023, Hyundai issued a service campaign to address certain MY 2022-2023 Ioniq 5 and MY 2023 Ioniq 6 vehicles that may have low 12V auxiliary battery charging occurrences due to an ICCU fault and may set the DTC P1A9096 “DC/DC Converter Input Voltage Sensor Fault”. On March 15, 2024, Hyundai filed Safety Recall 24V-204 for 98,878 MY 2022-2024 Hyundai Ioniq 5 vehicles and MY 2023-2024 Hyundai Ioniq 6, Genesis GV60, Genesis GV70 “Electrified” and Genesis G80 “Electrified” vehicles. The recall remedy provides an inspection, and if necessary, a replacement of the ICCU and the associated fuse. The ICCU software reduces the risk of overcurrent and implements voltage peak reduction at the end of EV battery charging. The recall also includes a software update that revises the electric water pump operational threshold to reduce thermal loading during charging and driving. In view of the recall action being taken by Hyundai, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration