NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
222 reportsMileage unknown · Mar 5, 2026
Electrical SystemFuel/propulsion SystemVehicle Speed Control
While driving northbound on US-280 freeway, the vehicle experienced sudden deceleration with maximum speed limited to approximately 40 mph. The dashboard displayed a "Check Power Supply" warning. The vehicle required a tow to the dealership. Dealer diagnosis indicates likely ICCU (Integrated Charging Control Unit) failure. This …
Read full complaint
While driving northbound on US-280 freeway, the vehicle experienced sudden deceleration with maximum speed limited to approximately 40 mph. The dashboard displayed a "Check Power Supply" warning. The vehicle required a tow to the dealership. Dealer diagnosis indicates likely ICCU (Integrated Charging Control Unit) failure. This is a known issue affecting multiple Hyundai Ioniq 5 vehicles, with numerous consumer reports of the same failure mode. The sudden loss of propulsion at highway speed created a significant safety hazard though we were able to make it off the freeway with hazards on. However shortly after exiting the vehicle further slowed and eventually died on the side of the road as did the hazard signals.
NHTSA ODI #11722142
Mileage unknown · Mar 4, 2026
Power Train
According to Hyundai, all active recall campaigns have been addressed on this vehicle (NHTSA site says it wasn't, Hyundai claims it was on 9/22/2025). Last night (3/3/2026) while driving on an unlit, two-lane country road about 20 minutes from my house, I heard and felt a bang noise from underneath the rear cabin of the car acco…
Read full complaint
According to Hyundai, all active recall campaigns have been addressed on this vehicle (NHTSA site says it wasn't, Hyundai claims it was on 9/22/2025). Last night (3/3/2026) while driving on an unlit, two-lane country road about 20 minutes from my house, I heard and felt a bang noise from underneath the rear cabin of the car accompanied by a message stating "Stop vehicle and check power supply" on the dash. The car immediately went into a limp mode, reducing speed to ~40mph. After about 0.5 miles, the car further reduced speed to about 25mph (in a 55mph zone). As speed reduced further (no indication of what the speed would be reduced to), I pulled the car off of the road and awaited tow service. As this happened in the evening on an unlit country road, I was forced to wait for assistance along a stretch of road that could have been hazardous. Hyundai's claimed recall campaign work was performed on 9/22/25 with subsequent recurring failure about 5 months later. The dealer cannot confirm the diagnosis or offer estimates of repair time/availability until they see the car (currently scheduled for next week).
NHTSA ODI #11722069
Mileage unknown · Mar 3, 2026
Electrical System
Car was acting normally. Suddenly, the car would not accelerate. I was on a small road with no place to pull over. Vehicle said to pull over check electrical system. At great risk to my life and the safety of my children, we managed to get to a safe spot before the entire vehicle shut down. We expect that this was a failed ICCU.…
Read full complaint
Car was acting normally. Suddenly, the car would not accelerate. I was on a small road with no place to pull over. Vehicle said to pull over check electrical system. At great risk to my life and the safety of my children, we managed to get to a safe spot before the entire vehicle shut down. We expect that this was a failed ICCU.
NHTSA ODI #11721849
Mileage unknown · Feb 28, 2026
Electrical System
- What component or system failed or malfunctioned, and is it available for inspection upon request? The ICCU failed. It is not available for inspection. - How was your safety or the safety of others put at risk? Minimally. The car alerted me that it was power-limited and that I should stop the car immediate and get it towe…
Read full complaint
- What component or system failed or malfunctioned, and is it available for inspection upon request? The ICCU failed. It is not available for inspection. - How was your safety or the safety of others put at risk? Minimally. The car alerted me that it was power-limited and that I should stop the car immediate and get it towed to the dealer. - Has the problem been reproduced or confirmed by a dealer or independent service center? Yes. - Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Yes, the dealer. - Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? Yes. The car informed me it was power limited when I started it. When I started driving after about a mile I was instructed to pull over get a tow.
NHTSA ODI #11721169
Mileage unknown · Feb 27, 2026
Electrical System
Car suddenly out of the blue reported electrical system problem and battery problem. It also entered turtle mode where it would not go more than 10 MPH. If accelerating across an intersection this would have been extremely problematic if expecting to be able to travel faster than that. Towed to dealer that said it is a failed IC…
Read full complaint
Car suddenly out of the blue reported electrical system problem and battery problem. It also entered turtle mode where it would not go more than 10 MPH. If accelerating across an intersection this would have been extremely problematic if expecting to be able to travel faster than that. Towed to dealer that said it is a failed ICCU. This is a common failure mode and there needs to be a fix and safety recall for this.
NHTSA ODI #11721033
Mileage unknown · Feb 27, 2026
Electrical SystemFuel/propulsion System
On January 31st, 2026, not long after starting a journey in my car, I got a “check electrical systems” warning. I was close to home so was able to turn around and drive home. Just before pulling into the driveway, the warning changed to a “power limited” warning. On Monday Feb 2nd, I had the car towed to my local dealershi…
Read full complaint
On January 31st, 2026, not long after starting a journey in my car, I got a “check electrical systems” warning. I was close to home so was able to turn around and drive home. Just before pulling into the driveway, the warning changed to a “power limited” warning. On Monday Feb 2nd, I had the car towed to my local dealership, where it has been since. The dealer confirmed that it was an issue with the ICCU component which is on back order to this day.
NHTSA ODI #11721005
Mileage unknown · Feb 26, 2026
Electrical System
Received “check electrical system” warning when turning on vehicle. Car towed to service department. Diagnostic said it was an ICCU failure with a back ordered part and no clear timeframe on when it would be in stock and fixed.
NHTSA ODI #11720826
Mileage unknown · Feb 26, 2026
Unknown Or Other
Missing a spot weld point on liftgate frame panel and rood panel. Also, the panel gaps are open widely compare to left and right side. No accident happen, I am from a collision center, I found these factory defects.
NHTSA ODI #11720679
Mileage unknown · Feb 25, 2026
Forward Collision Avoidance
When a car is in the process of passing me on the left during a left hand curve on the highway at highway speeds, the rear left radar sensor seems to have set off a forward collision warning. This caused the ioniq5 to do an emergency collision brake. I had to press on the accelerator to cancel the emergency brake while the other…
Read full complaint
When a car is in the process of passing me on the left during a left hand curve on the highway at highway speeds, the rear left radar sensor seems to have set off a forward collision warning. This caused the ioniq5 to do an emergency collision brake. I had to press on the accelerator to cancel the emergency brake while the other car passed me on the left. There were no cars in front of me that would have triggered a frontal collision emergency brake.
NHTSA ODI #11720580
Mileage unknown · Feb 25, 2026
Electrical System
The ICCU failed at approximately 14,000 miles. I was driving on a residential street and was able to park on the side of the road, so there was no danger, but the car became undriveable
NHTSA ODI #11720569
Official recalls
3Jul 2, 2026
Hyundai Motor America (Hyundai) is recalling certain 2023-2024 Ioniq 5 vehicles. The high voltage battery cells may contain misaligned electrodes, which can lead to a fire while parked or driving.
Consequence & remedy
Consequence: A fire increases the risk of injury.
Remedy: Owners are advised to park outside and away from structures and limit their charge to a maximum of 80% until the recall repair is complete. Dealers will replace the high voltage battery system assembly, free of charge. Owner notification letters are expected to be mailed August 31, 2026. Owners may contact Hyundai's customer service at 855-371-9460. Hyundai's number for this recall is 305. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 3, 2026.
Nov 18, 2024
Hyundai Motor America (Hyundai) is recalling certain 2022-2024 IONIQ 5, 2023-2025 IONIQ 6, Genesis GV60, Genesis GV70 "Electrified," and Genesis G80 "Electrified" vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-volt battery, which can result in a loss of drive power.
Consequence & remedy
Consequence: A loss of drive power increases the risk of a crash.
Remedy: Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed December 20, 2024. Owners may contact Hyundai customer service at 1-855-371-9460 or Genesis customer service at 1-844-340-9741. Hyundai's numbers for this recall are 272 (Hyundai) and 025G (Genesis). This recall expands and replaces previous recall number 24V-204. Vehicles previously repaired under recall 24V-204 will need to have the new remedy completed.
Additional source detail variants (2)
Electrical System:propulsion System:charging:module:software
Hyundai Motor America (Hyundai) is recalling certain 2022-2024 IONIQ 5, 2023-2025 IONIQ 6, Genesis GV60, Genesis GV70 "Electrified," and Genesis G80 "Electrified" vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-volt battery, which can result in a loss of drive power.
Consequence: A loss of drive power increases the risk of a crash.
Remedy: Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed December 20, 2024. Owners may contact Hyundai customer service at 1-855-371-9460 or Genesis customer service at 1-844-340-9741. Hyundai's numbers for this recall are 272 (Hyundai) and 025G (Genesis). This recall expands and replaces previous recall number 24V-204. Vehicles previously repaired under recall 24V-204 will need to have the new remedy completed.
Electrical SYSTEM:12V/24V/48V Battery
Hyundai Motor America (Hyundai) is recalling certain 2022-2024 IONIQ 5, 2023-2025 IONIQ 6, Genesis GV60, Genesis GV70 "Electrified," and Genesis G80 "Electrified" vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-volt battery, which can result in a loss of drive power.
Consequence: A loss of drive power increases the risk of a crash.
Remedy: Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed December 20, 2024. Owners may contact Hyundai customer service at 1-855-371-9460 or Genesis customer service at 1-844-340-9741. Hyundai's numbers for this recall are 272 (Hyundai) and 025G (Genesis). This recall expands and replaces previous recall number 24V-204. Vehicles previously repaired under recall 24V-204 will need to have the new remedy completed.
Mar 15, 2024
Hyundai Motor America (Hyundai) is recalling certain 2022-2024 IONIQ 5, 2023-2024 IONIQ 6, Genesis GV60, Genesis GV70 "Electrified," and Genesis G80 "Electrified" vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-Volt battery, which can result in a loss of drive power.
Consequence & remedy
Consequence: A loss of drive power increases the risk of a crash.
Remedy: This recall is replaced by NHTSA recall number 24V-868. Vehicles already repaired under this recall will need to have the new remedy completed. Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed April 22, 2024. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 257/021G.
Additional source detail variants (2)
Electrical SYSTEM:12V/24V/48V Battery
Hyundai Motor America (Hyundai) is recalling certain 2022-2024 IONIQ 5, 2023-2024 IONIQ 6, Genesis GV60, Genesis GV70 "Electrified," and Genesis G80 "Electrified" vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-Volt battery, which can result in a loss of drive power.
Consequence: A loss of drive power increases the risk of a crash.
Remedy: This recall is replaced by NHTSA recall number 24V-868. Vehicles already repaired under this recall will need to have the new remedy completed. Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed April 22, 2024. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 257/021G.
Electrical System:propulsion System:charging:module:software
Hyundai Motor America (Hyundai) is recalling certain 2022-2024 IONIQ 5, 2023-2024 IONIQ 6, Genesis GV60, Genesis GV70 "Electrified," and Genesis G80 "Electrified" vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-Volt battery, which can result in a loss of drive power.
Consequence: A loss of drive power increases the risk of a crash.
Remedy: This recall is replaced by NHTSA recall number 24V-868. Vehicles already repaired under this recall will need to have the new remedy completed. Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed April 22, 2024. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 257/021G.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE23011 · Loss Of Motive Power
Opened Jun 8, 2023 · Closed Apr 17, 2024
Status: closed (inferred from source dates) · Electrical SYSTEM:12V/24V/48V Battery; Electrical System:propulsion System:dc/dc Converter
On June 8, 2023, the Office of Defect Investigation (ODI) opened PE23011 to investigate allegations of loss of motor power on model year (MY) 2022 Hyundai Ioniq 5 vehicles. Some consumers reported loss of motor power immediately after a warning lamp illumination or reduction of motive power while the vehicle was in motion. This investigation found that the Integrated Charging Control Unit (ICCU) may be subject to various conditions such as overcurrent, overvoltage induced at the end of charging, and certain thermal loading during operation that can damage its internal components and open the ICCU fuse, resulting in an inability to charge the 12-volt battery. The vehicle could eventually lose all motive power, increasing the risk of a crash. In July 2023, Hyundai issued a service campaign to address certain MY 2022-2023 Ioniq 5 and MY 2023 Ioniq 6 vehicles that may have low 12V auxiliary battery charging occurrences due to an ICCU fault and may set the DTC P1A9096 “DC/DC Converter Input Voltage Sensor Fault”. On March 15, 2024, Hyundai filed Safety Recall 24V-204 for 98,878 MY 2022-2024 Hyundai Ioniq 5 vehicles and MY 2023-2024 Hyundai Ioniq 6, Genesis GV60, Genesis GV70 “Electrified” and Genesis G80 “Electrified” vehicles. The recall remedy provides an inspection, and if necessary, a replacement of the ICCU and the associated fuse. The ICCU software reduces the risk of overcurrent and implements voltage peak reduction at the end of EV battery charging. The recall also includes a software update that revises the electric water pump operational threshold to reduce thermal loading during charging and driving. In view of the recall action being taken by Hyundai, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Electrical SYSTEM:12V/24V/48V Battery
On June 8, 2023, the Office of Defect Investigation (ODI) opened PE23011 to investigate allegations of loss of motor power on model year (MY) 2022 Hyundai Ioniq 5 vehicles. Some consumers reported loss of motor power immediately after a warning lamp illumination or reduction of motive power while the vehicle was in motion. This investigation found that the Integrated Charging Control Unit (ICCU) may be subject to various conditions such as overcurrent, overvoltage induced at the end of charging, and certain thermal loading during operation that can damage its internal components and open the ICCU fuse, resulting in an inability to charge the 12-volt battery. The vehicle could eventually lose all motive power, increasing the risk of a crash. In July 2023, Hyundai issued a service campaign to address certain MY 2022-2023 Ioniq 5 and MY 2023 Ioniq 6 vehicles that may have low 12V auxiliary battery charging occurrences due to an ICCU fault and may set the DTC P1A9096 “DC/DC Converter Input Voltage Sensor Fault”. On March 15, 2024, Hyundai filed Safety Recall 24V-204 for 98,878 MY 2022-2024 Hyundai Ioniq 5 vehicles and MY 2023-2024 Hyundai Ioniq 6, Genesis GV60, Genesis GV70 “Electrified” and Genesis G80 “Electrified” vehicles. The recall remedy provides an inspection, and if necessary, a replacement of the ICCU and the associated fuse. The ICCU software reduces the risk of overcurrent and implements voltage peak reduction at the end of EV battery charging. The recall also includes a software update that revises the electric water pump operational threshold to reduce thermal loading during charging and driving. In view of the recall action being taken by Hyundai, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Electrical System:propulsion System:dc/dc Converter
On June 8, 2023, the Office of Defect Investigation (ODI) opened PE23011 to investigate allegations of loss of motor power on model year (MY) 2022 Hyundai Ioniq 5 vehicles. Some consumers reported loss of motor power immediately after a warning lamp illumination or reduction of motive power while the vehicle was in motion. This investigation found that the Integrated Charging Control Unit (ICCU) may be subject to various conditions such as overcurrent, overvoltage induced at the end of charging, and certain thermal loading during operation that can damage its internal components and open the ICCU fuse, resulting in an inability to charge the 12-volt battery. The vehicle could eventually lose all motive power, increasing the risk of a crash. In July 2023, Hyundai issued a service campaign to address certain MY 2022-2023 Ioniq 5 and MY 2023 Ioniq 6 vehicles that may have low 12V auxiliary battery charging occurrences due to an ICCU fault and may set the DTC P1A9096 “DC/DC Converter Input Voltage Sensor Fault”. On March 15, 2024, Hyundai filed Safety Recall 24V-204 for 98,878 MY 2022-2024 Hyundai Ioniq 5 vehicles and MY 2023-2024 Hyundai Ioniq 6, Genesis GV60, Genesis GV70 “Electrified” and Genesis G80 “Electrified” vehicles. The recall remedy provides an inspection, and if necessary, a replacement of the ICCU and the associated fuse. The ICCU software reduces the risk of overcurrent and implements voltage peak reduction at the end of EV battery charging. The recall also includes a software update that revises the electric water pump operational threshold to reduce thermal loading during charging and driving. In view of the recall action being taken by Hyundai, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration