NHTSA owner reports · September 18, 2026 snapshot.
Fuel/propulsion System complaints
51 reportsClear category filterMileage unknown · Jun 25, 2025
Electrical SystemEngineFuel/propulsion System
The car made a loud popping noise and immediately started displaying electrical system fault errors. The car propulsion stopped within 15 seconds and was not able to be moved after. I was on the freeway and just barely made it over to the side. Car was not able to be towed by a regular tow truck because the electrical system was…
Read full complaint
The car made a loud popping noise and immediately started displaying electrical system fault errors. The car propulsion stopped within 15 seconds and was not able to be moved after. I was on the freeway and just barely made it over to the side. Car was not able to be towed by a regular tow truck because the electrical system was gone and the car was not able to be shifted into neutral. Jump starting the battery did nothing. Car was sent to the dealer who confirmed that the car sustained an ICCU failure which controls the entire battery electric system. The ICCU had to be replaced. There is already a mandatory recall on the vehicle regarding the ICCU. The recall was to check the status and confirm that the ICCU was working properly and in good condition. I had this recall done BEFORE the ICCU failed, so even though the recall check was performed, the ICCU still failed and put me in a very dangerous situation. The car is 6 months old and has 6200 miles on the odometer.
NHTSA ODI #11669293
Mileage unknown · Jun 22, 2025
Electrical SystemFuel/propulsion SystemPower Train
Dear NHTSA, On [XXX] at [XXX] CST, my 2024 Hyundai Ioniq 5 SEL experienced a sudden ICCU failure. While reversing into my driveway, I heard a loud “pop,” followed by warning messages: “Stop vehicle and check power supply” and “Check electric vehicle system.” A DTC scan showed code P1A90(96). The car became inoperable and had to…
Read full complaint
Dear NHTSA, On [XXX] at [XXX] CST, my 2024 Hyundai Ioniq 5 SEL experienced a sudden ICCU failure. While reversing into my driveway, I heard a loud “pop,” followed by warning messages: “Stop vehicle and check power supply” and “Check electric vehicle system.” A DTC scan showed code P1A90(96). The car became inoperable and had to be towed to a Hyundai dealership. The dealer confirmed ICCU failure and replaced both the ICCU and fuse on 6/17/2025. However, the replacement was not a redesigned part—it was the same model that failed. I purchased this vehicle in March 2025 as a Certified Pre-Owned with ~12,000 miles. All recall-related ICCU updates had been completed before this incident. There were no warning signs before the failure. This failure could have been dangerous had it occurred on a highway, in extreme weather, or far from help with my [XXX] daughter with me. I no longer feel safe driving this car. Hyundai’s recall remedy is clearly not effective, and they continue replacing defective ICCUs with the same flawed units. They have not disclosed the root cause or implemented a permanent fix. I urge NHTSA to: Investigate ongoing ICCU failures despite recall compliance. Mandate a stop-sale of affected vehicles until a real fix is found. Require Hyundai to disclose the root cause. Consider a buyback program if no safe solution is available. This is a serious safety risk. These failures will continue without regulatory action. Sincerely, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11668456
Mileage unknown · Jun 5, 2025
Electrical SystemFuel/propulsion System
Vehicle lost power on a two lane highway with a 55mph speed limit, which increased the risk of an accident. Warning lights appeared after the failure occurred; essentially giving the driver little to no warning. The vehicle kept slowing down to 30-25 mph, but fortunately close enough to home and was able to slowly roll into the …
Read full complaint
Vehicle lost power on a two lane highway with a 55mph speed limit, which increased the risk of an accident. Warning lights appeared after the failure occurred; essentially giving the driver little to no warning. The vehicle kept slowing down to 30-25 mph, but fortunately close enough to home and was able to slowly roll into the garage. The vehicle was towed to the dealership and will take 2 months for the ICCU and ICCU fuse to be replaced due to backordered parts. This occurred after an ICCU update was done in 12/24.
NHTSA ODI #11665145
Mileage unknown · May 19, 2025
Electrical SystemFuel/propulsion SystemPower Train
ICCU (Intergrated Charging Control Unit) failed after two mandatory recalls were completed. Vehicle is not drivable as it’s awaiting for a replacement ICCU (backordered). Replacement ICCU will not remedy the issue since it has not been improved upon from the original failure. Vehicle shutdown on a two lane highway with a 65mph…
Read full complaint
ICCU (Intergrated Charging Control Unit) failed after two mandatory recalls were completed. Vehicle is not drivable as it’s awaiting for a replacement ICCU (backordered). Replacement ICCU will not remedy the issue since it has not been improved upon from the original failure. Vehicle shutdown on a two lane highway with a 65mph speed limit. The section where the vehicle shutdown was without cellular service and on a bend with no shoulder, which increased the risk of an accident. The problem was reproduced in other vehicles using the same part. The component has been inspected by the manufacturer and dealer with a temporary remedy of replacement. Warning lights appeared after the failure occurred; essentially giving the driver no warning or time to react. The vehicle displayed a warning message to pull over and turn off vehicle immediately. Power was reduced to 15mph for about 15-20 minutes.
NHTSA ODI #11661948
Mileage unknown · May 19, 2025
Electrical SystemFuel/propulsion System
On Monday May 12, 2025, while driving my Ioniq5 (2024) several warnings appeared concerning the EV electrical system. One warning dealt with 12 volt battery issue and other warning alerted the entire vehicle's electrical system was failing with instruction to stop driving vehicle immediately. I was out of town and my car was …
Read full complaint
On Monday May 12, 2025, while driving my Ioniq5 (2024) several warnings appeared concerning the EV electrical system. One warning dealt with 12 volt battery issue and other warning alerted the entire vehicle's electrical system was failing with instruction to stop driving vehicle immediately. I was out of town and my car was towed to local hyundai dealership. The problem appears to be a faulty ICCU component and parts have been ordered. Having my brand new EV turn off in traffic is scary and this experience has been frustrating and nerve wrecking. Knowing Hyundai was aware of this problem makes it even worse.
NHTSA ODI #11661824
Mileage unknown · Mar 31, 2025
Electrical SystemFuel/propulsion SystemVehicle Speed Control
ICCU failed while driving. Causing the car to dangerously decelerate with little to no warning. The car then bricked itself on the side of the road. Diagnoses is a failed ICCU. This failure was insanely dangerous as the car lost all power and would not accelerate.
NHTSA ODI #11651827
Mileage unknown · Mar 26, 2025
Forward Collision AvoidanceFuel/propulsion SystemService BrakesCrash
My wife was parking the 2024 ioniq and it lurched forward at a high rate of speed and slammed into another car parked in our driveway and drove that vehicle through our home garage door. She feels certain that her foot was on the brake, but even if she accidentally slipped and appleid the brake the forward collision system shou…
Read full complaint
My wife was parking the 2024 ioniq and it lurched forward at a high rate of speed and slammed into another car parked in our driveway and drove that vehicle through our home garage door. She feels certain that her foot was on the brake, but even if she accidentally slipped and appleid the brake the forward collision system should have prevented the accident additionally the impact occurred with such force it is unlikely due to human error as it pushed our very heavy 4Runner back 3 feet and thorough a closed garage door.
NHTSA ODI #11650928
Mileage unknown · Feb 3, 2025
Electrical SystemFuel/propulsion SystemPower Train
Started car and proceeded to drive to work. 1 mile from home, heard a "pop" noise and the car displayed "Check Electric Vehicle System" warning and went into a "turtle" mode that limited speed. Luckily I was on a side street and had not yet made the turn onto the main highway or it may have obstructed traffic or resulted in a c…
Read full complaint
Started car and proceeded to drive to work. 1 mile from home, heard a "pop" noise and the car displayed "Check Electric Vehicle System" warning and went into a "turtle" mode that limited speed. Luckily I was on a side street and had not yet made the turn onto the main highway or it may have obstructed traffic or resulted in a crash. I was able to return home and have the car towed back to a Hyundai dealer for diagnosis and repair. The dealer identified the issue as the ICCU fuse and ICCU itself that needed replacing. All previous recalls and software updates were completed, including the latest ICCU recall (272?) which was completed on December 3. There have now been multiple software updates and recalls targeting this part, but it still resulted in the vehicle losing power and being inoperable.
NHTSA ODI #11640396
Mileage unknown · Feb 2, 2025
Electrical SystemFuel/propulsion SystemPower Train
Our 8-mo old 9800 mile Ioniq 5 failed to maintain its 12v battery while parked for a week. It was dead when we came back to it. Jump started successfully. I replaced the OEM battery with an AGM battery, which the car failed to maintain charge on after 2 weeks. At that time, while driving, the car displayed "Stop vehicle an…
Read full complaint
Our 8-mo old 9800 mile Ioniq 5 failed to maintain its 12v battery while parked for a week. It was dead when we came back to it. Jump started successfully. I replaced the OEM battery with an AGM battery, which the car failed to maintain charge on after 2 weeks. At that time, while driving, the car displayed "Stop vehicle and check power supply" and "check vehicle electrical system." I had a battery monitor installed which showed the car only had 44% charge left in a new 12v battery. By the time we made it to the dealer 15 minutes away, the car was barely above 20% on its battery, and was about to stop on the road. The car has been diagnosed with an ICCU failure and replacement parts are 2+ months backordered. This car appears to brick itself without much warning to the driver -- and clearly Hyundai's software-only recalls are not fixing the root cause of this dangerous safety issue.
NHTSA ODI #11640156
Mileage unknown · Jul 12, 2024
Electrical SystemFuel/propulsion System
Auto lost all power. No instruments visible. Propulsion system would not charge. Thankfully vehicle at a stop when occurred. Unable to drive. Car as dead as a home in a power outage. Everything dark. Nothing electrical worked. Had to use emergency manual key to enter vehicle. Tow truck driver said this was the 4th Hyund…
Read full complaint
Auto lost all power. No instruments visible. Propulsion system would not charge. Thankfully vehicle at a stop when occurred. Unable to drive. Car as dead as a home in a power outage. Everything dark. Nothing electrical worked. Had to use emergency manual key to enter vehicle. Tow truck driver said this was the 4th Hyundai Ioniq 5 he towed that week. All dead. Car at dealer awaiting diagnostics, which because of backlog, could take 3 or 4 weeks.
NHTSA ODI #11601474
Official recalls
3Jul 2, 2026
Hyundai Motor America (Hyundai) is recalling certain 2023-2024 Ioniq 5 vehicles. The high voltage battery cells may contain misaligned electrodes, which can lead to a fire while parked or driving.
Consequence & remedy
Consequence: A fire increases the risk of injury.
Remedy: Owners are advised to park outside and away from structures and limit their charge to a maximum of 80% until the recall repair is complete. Dealers will replace the high voltage battery system assembly, free of charge. Owner notification letters are expected to be mailed August 31, 2026. Owners may contact Hyundai's customer service at 855-371-9460. Hyundai's number for this recall is 305. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 3, 2026.
Nov 18, 2024
Hyundai Motor America (Hyundai) is recalling certain 2022-2024 IONIQ 5, 2023-2025 IONIQ 6, Genesis GV60, Genesis GV70 "Electrified," and Genesis G80 "Electrified" vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-volt battery, which can result in a loss of drive power.
Consequence & remedy
Consequence: A loss of drive power increases the risk of a crash.
Remedy: Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed December 20, 2024. Owners may contact Hyundai customer service at 1-855-371-9460 or Genesis customer service at 1-844-340-9741. Hyundai's numbers for this recall are 272 (Hyundai) and 025G (Genesis). This recall expands and replaces previous recall number 24V-204. Vehicles previously repaired under recall 24V-204 will need to have the new remedy completed.
Additional source detail variants (2)
Electrical System:propulsion System:charging:module:software
Hyundai Motor America (Hyundai) is recalling certain 2022-2024 IONIQ 5, 2023-2025 IONIQ 6, Genesis GV60, Genesis GV70 "Electrified," and Genesis G80 "Electrified" vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-volt battery, which can result in a loss of drive power.
Consequence: A loss of drive power increases the risk of a crash.
Remedy: Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed December 20, 2024. Owners may contact Hyundai customer service at 1-855-371-9460 or Genesis customer service at 1-844-340-9741. Hyundai's numbers for this recall are 272 (Hyundai) and 025G (Genesis). This recall expands and replaces previous recall number 24V-204. Vehicles previously repaired under recall 24V-204 will need to have the new remedy completed.
Electrical SYSTEM:12V/24V/48V Battery
Hyundai Motor America (Hyundai) is recalling certain 2022-2024 IONIQ 5, 2023-2025 IONIQ 6, Genesis GV60, Genesis GV70 "Electrified," and Genesis G80 "Electrified" vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-volt battery, which can result in a loss of drive power.
Consequence: A loss of drive power increases the risk of a crash.
Remedy: Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed December 20, 2024. Owners may contact Hyundai customer service at 1-855-371-9460 or Genesis customer service at 1-844-340-9741. Hyundai's numbers for this recall are 272 (Hyundai) and 025G (Genesis). This recall expands and replaces previous recall number 24V-204. Vehicles previously repaired under recall 24V-204 will need to have the new remedy completed.
Mar 15, 2024
Hyundai Motor America (Hyundai) is recalling certain 2022-2024 IONIQ 5, 2023-2024 IONIQ 6, Genesis GV60, Genesis GV70 "Electrified," and Genesis G80 "Electrified" vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-Volt battery, which can result in a loss of drive power.
Consequence & remedy
Consequence: A loss of drive power increases the risk of a crash.
Remedy: This recall is replaced by NHTSA recall number 24V-868. Vehicles already repaired under this recall will need to have the new remedy completed. Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed April 22, 2024. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 257/021G.
Additional source detail variants (2)
Electrical SYSTEM:12V/24V/48V Battery
Hyundai Motor America (Hyundai) is recalling certain 2022-2024 IONIQ 5, 2023-2024 IONIQ 6, Genesis GV60, Genesis GV70 "Electrified," and Genesis G80 "Electrified" vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-Volt battery, which can result in a loss of drive power.
Consequence: A loss of drive power increases the risk of a crash.
Remedy: This recall is replaced by NHTSA recall number 24V-868. Vehicles already repaired under this recall will need to have the new remedy completed. Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed April 22, 2024. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 257/021G.
Electrical System:propulsion System:charging:module:software
Hyundai Motor America (Hyundai) is recalling certain 2022-2024 IONIQ 5, 2023-2024 IONIQ 6, Genesis GV60, Genesis GV70 "Electrified," and Genesis G80 "Electrified" vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-Volt battery, which can result in a loss of drive power.
Consequence: A loss of drive power increases the risk of a crash.
Remedy: This recall is replaced by NHTSA recall number 24V-868. Vehicles already repaired under this recall will need to have the new remedy completed. Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed April 22, 2024. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 257/021G.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE23011 · Loss Of Motive Power
Opened Jun 8, 2023 · Closed Apr 17, 2024
Status: closed (inferred from source dates) · Electrical SYSTEM:12V/24V/48V Battery; Electrical System:propulsion System:dc/dc Converter
On June 8, 2023, the Office of Defect Investigation (ODI) opened PE23011 to investigate allegations of loss of motor power on model year (MY) 2022 Hyundai Ioniq 5 vehicles. Some consumers reported loss of motor power immediately after a warning lamp illumination or reduction of motive power while the vehicle was in motion. This investigation found that the Integrated Charging Control Unit (ICCU) may be subject to various conditions such as overcurrent, overvoltage induced at the end of charging, and certain thermal loading during operation that can damage its internal components and open the ICCU fuse, resulting in an inability to charge the 12-volt battery. The vehicle could eventually lose all motive power, increasing the risk of a crash. In July 2023, Hyundai issued a service campaign to address certain MY 2022-2023 Ioniq 5 and MY 2023 Ioniq 6 vehicles that may have low 12V auxiliary battery charging occurrences due to an ICCU fault and may set the DTC P1A9096 “DC/DC Converter Input Voltage Sensor Fault”. On March 15, 2024, Hyundai filed Safety Recall 24V-204 for 98,878 MY 2022-2024 Hyundai Ioniq 5 vehicles and MY 2023-2024 Hyundai Ioniq 6, Genesis GV60, Genesis GV70 “Electrified” and Genesis G80 “Electrified” vehicles. The recall remedy provides an inspection, and if necessary, a replacement of the ICCU and the associated fuse. The ICCU software reduces the risk of overcurrent and implements voltage peak reduction at the end of EV battery charging. The recall also includes a software update that revises the electric water pump operational threshold to reduce thermal loading during charging and driving. In view of the recall action being taken by Hyundai, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Electrical SYSTEM:12V/24V/48V Battery
On June 8, 2023, the Office of Defect Investigation (ODI) opened PE23011 to investigate allegations of loss of motor power on model year (MY) 2022 Hyundai Ioniq 5 vehicles. Some consumers reported loss of motor power immediately after a warning lamp illumination or reduction of motive power while the vehicle was in motion. This investigation found that the Integrated Charging Control Unit (ICCU) may be subject to various conditions such as overcurrent, overvoltage induced at the end of charging, and certain thermal loading during operation that can damage its internal components and open the ICCU fuse, resulting in an inability to charge the 12-volt battery. The vehicle could eventually lose all motive power, increasing the risk of a crash. In July 2023, Hyundai issued a service campaign to address certain MY 2022-2023 Ioniq 5 and MY 2023 Ioniq 6 vehicles that may have low 12V auxiliary battery charging occurrences due to an ICCU fault and may set the DTC P1A9096 “DC/DC Converter Input Voltage Sensor Fault”. On March 15, 2024, Hyundai filed Safety Recall 24V-204 for 98,878 MY 2022-2024 Hyundai Ioniq 5 vehicles and MY 2023-2024 Hyundai Ioniq 6, Genesis GV60, Genesis GV70 “Electrified” and Genesis G80 “Electrified” vehicles. The recall remedy provides an inspection, and if necessary, a replacement of the ICCU and the associated fuse. The ICCU software reduces the risk of overcurrent and implements voltage peak reduction at the end of EV battery charging. The recall also includes a software update that revises the electric water pump operational threshold to reduce thermal loading during charging and driving. In view of the recall action being taken by Hyundai, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Electrical System:propulsion System:dc/dc Converter
On June 8, 2023, the Office of Defect Investigation (ODI) opened PE23011 to investigate allegations of loss of motor power on model year (MY) 2022 Hyundai Ioniq 5 vehicles. Some consumers reported loss of motor power immediately after a warning lamp illumination or reduction of motive power while the vehicle was in motion. This investigation found that the Integrated Charging Control Unit (ICCU) may be subject to various conditions such as overcurrent, overvoltage induced at the end of charging, and certain thermal loading during operation that can damage its internal components and open the ICCU fuse, resulting in an inability to charge the 12-volt battery. The vehicle could eventually lose all motive power, increasing the risk of a crash. In July 2023, Hyundai issued a service campaign to address certain MY 2022-2023 Ioniq 5 and MY 2023 Ioniq 6 vehicles that may have low 12V auxiliary battery charging occurrences due to an ICCU fault and may set the DTC P1A9096 “DC/DC Converter Input Voltage Sensor Fault”. On March 15, 2024, Hyundai filed Safety Recall 24V-204 for 98,878 MY 2022-2024 Hyundai Ioniq 5 vehicles and MY 2023-2024 Hyundai Ioniq 6, Genesis GV60, Genesis GV70 “Electrified” and Genesis G80 “Electrified” vehicles. The recall remedy provides an inspection, and if necessary, a replacement of the ICCU and the associated fuse. The ICCU software reduces the risk of overcurrent and implements voltage peak reduction at the end of EV battery charging. The recall also includes a software update that revises the electric water pump operational threshold to reduce thermal loading during charging and driving. In view of the recall action being taken by Hyundai, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration