NHTSA owner reports · September 18, 2026 snapshot.
Fuel/propulsion System complaints
51 reportsClear category filterMileage unknown · Mar 5, 2026
Electrical SystemFuel/propulsion SystemVehicle Speed Control
While driving northbound on US-280 freeway, the vehicle experienced sudden deceleration with maximum speed limited to approximately 40 mph. The dashboard displayed a "Check Power Supply" warning. The vehicle required a tow to the dealership. Dealer diagnosis indicates likely ICCU (Integrated Charging Control Unit) failure. This …
Read full complaint
While driving northbound on US-280 freeway, the vehicle experienced sudden deceleration with maximum speed limited to approximately 40 mph. The dashboard displayed a "Check Power Supply" warning. The vehicle required a tow to the dealership. Dealer diagnosis indicates likely ICCU (Integrated Charging Control Unit) failure. This is a known issue affecting multiple Hyundai Ioniq 5 vehicles, with numerous consumer reports of the same failure mode. The sudden loss of propulsion at highway speed created a significant safety hazard though we were able to make it off the freeway with hazards on. However shortly after exiting the vehicle further slowed and eventually died on the side of the road as did the hazard signals.
NHTSA ODI #11722142
Mileage unknown · Feb 27, 2026
Electrical SystemFuel/propulsion System
On January 31st, 2026, not long after starting a journey in my car, I got a “check electrical systems” warning. I was close to home so was able to turn around and drive home. Just before pulling into the driveway, the warning changed to a “power limited” warning. On Monday Feb 2nd, I had the car towed to my local dealershi…
Read full complaint
On January 31st, 2026, not long after starting a journey in my car, I got a “check electrical systems” warning. I was close to home so was able to turn around and drive home. Just before pulling into the driveway, the warning changed to a “power limited” warning. On Monday Feb 2nd, I had the car towed to my local dealership, where it has been since. The dealer confirmed that it was an issue with the ICCU component which is on back order to this day.
NHTSA ODI #11721005
Mileage unknown · Feb 24, 2026
Electrical SystemFuel/propulsion System
I was driving on a residential street, traveling about 25 miles per hour. I heard a loud popping sound from the back of the car and within seconds I started to lose power. I pulled over to the side of the road and my car was dead. No electrical system, I couldn't even power the locks. I waited for several hours to have it towed …
Read full complaint
I was driving on a residential street, traveling about 25 miles per hour. I heard a loud popping sound from the back of the car and within seconds I started to lose power. I pulled over to the side of the road and my car was dead. No electrical system, I couldn't even power the locks. I waited for several hours to have it towed to the dealer where it sat for 29 days waiting for the part. It's the ICCU that failed. Had I been going at highway speeds, I very likely could have been in a life threatening accident. This is unacceptable for a car.
NHTSA ODI #11720167
Mileage unknown · Feb 23, 2026
Electrical SystemFuel/propulsion System
Routine Friday morning and just finished charging my 2024 Hyundai Ioniq 5 at Walmart. As I started my vehicle to finish my commute to work, the dreaded "Check electric vehicle system" warning light came on along with a red battery icon. There were no warning signs or anything that could have foretold what would be happening. …
Read full complaint
Routine Friday morning and just finished charging my 2024 Hyundai Ioniq 5 at Walmart. As I started my vehicle to finish my commute to work, the dreaded "Check electric vehicle system" warning light came on along with a red battery icon. There were no warning signs or anything that could have foretold what would be happening. I pulled into an empty parking stall and called the Hyundai dealer for advice. I was told not to drive the vehicle and get it towed to the dealership. After being diagnosed, my car will need a new ICCU and ICCU fuse. The dealership gave me no ETA as it often takes weeks to months to receive the parts from Korea. I was told Fontana Hyundai had 9 other cars with the same ICCU issue in line before mine. I was so glad it occurred in a parking lot and not on the freeway since a malfunction with the ICCU will basically cause the car to loose total power and control. This is definitely a huge concern and safety issue.
NHTSA ODI #11719972
Mileage unknown · Feb 22, 2026
Electrical SystemFuel/propulsion System
Iccu failure in middle of busy interstate. Pop sound and then notice of electric system failure. Only made it 1.5 miles before vehicle fully died. Extreme safety concern. Couldn’t use any electrical systems on EV
NHTSA ODI #11719768
Mileage unknown · Feb 20, 2026
Fuel/propulsion SystemPower Train
Vehicle displayed "Power limited" and slowed to a crawl, was able to drive less than a quarter mile to a safe place before it displayed "Stop vehicle and check power supply" then completely shut down. Diagnosed as ICCU failure by the Hyundai Dealer service technician, with the parts on backorder and no ETA for the 15 or so othe…
Read full complaint
Vehicle displayed "Power limited" and slowed to a crawl, was able to drive less than a quarter mile to a safe place before it displayed "Stop vehicle and check power supply" then completely shut down. Diagnosed as ICCU failure by the Hyundai Dealer service technician, with the parts on backorder and no ETA for the 15 or so other Hyundai Ioniq 5's with the same failed ICCU waiting at the same dealership, in front of me.
NHTSA ODI #11719322
Mileage unknown · Feb 18, 2026
Electrical SystemFuel/propulsion System
My car gave me a "Check electrical vehicle system" message, which I have seen online may mean a problem with the ICCU. As the dealership is close - about five miles from my home, on residential roads - I decided to drive there. The car lost power very quickly and then died in the road shortly after leaving my driveway. Thankfu…
Read full complaint
My car gave me a "Check electrical vehicle system" message, which I have seen online may mean a problem with the ICCU. As the dealership is close - about five miles from my home, on residential roads - I decided to drive there. The car lost power very quickly and then died in the road shortly after leaving my driveway. Thankfully I wasn't on a busy street or an intersection and was able to safely get it to the side of the road, but if it had died while driving at a higher speed it would have been very dangerous.
NHTSA ODI #11718794
Mileage unknown · Feb 17, 2026
Electrical SystemFuel/propulsion System
Car died in neighborhood with electrical issue. Later reported to be an ICCU issue. At this point car has been at dealer service for over 29 days with no date on when it will be repaired.
NHTSA ODI #11718515
Mileage unknown · Feb 14, 2026
Electrical SystemFuel/propulsion System
While pulling into traffic the car lost power and went into limp mode risking a collision. Car was immediately backed into driveway and completely died shortly after the initial power loss and had to be towed to dealer. Dealer diagnosed an ICCU failure. Warning lights activated at the moment the car lost power. Had this occur…
Read full complaint
While pulling into traffic the car lost power and went into limp mode risking a collision. Car was immediately backed into driveway and completely died shortly after the initial power loss and had to be towed to dealer. Dealer diagnosed an ICCU failure. Warning lights activated at the moment the car lost power. Had this occurred on a highway or in heavier traffic the power loss and speed with which the car went from fully operational to dead could have had catastrophic consequences.
NHTSA ODI #11717977
Mileage unknown · Feb 13, 2026
Electrical SystemFuel/propulsion System
“Check EV System” error appeared in a red circle, with a red 12v battery icon. Then a turtle icon appeared and the car would not exceed about 30 mph. I was able to drive a mile and park in a lot. This happened after Level 2 charging to 100% and then driving one mile in 25° weather. The car was towed to the dealer.
NHTSA ODI #11717943
Official recalls
3Jul 2, 2026
Hyundai Motor America (Hyundai) is recalling certain 2023-2024 Ioniq 5 vehicles. The high voltage battery cells may contain misaligned electrodes, which can lead to a fire while parked or driving.
Consequence & remedy
Consequence: A fire increases the risk of injury.
Remedy: Owners are advised to park outside and away from structures and limit their charge to a maximum of 80% until the recall repair is complete. Dealers will replace the high voltage battery system assembly, free of charge. Owner notification letters are expected to be mailed August 31, 2026. Owners may contact Hyundai's customer service at 855-371-9460. Hyundai's number for this recall is 305. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 3, 2026.
Nov 18, 2024
Hyundai Motor America (Hyundai) is recalling certain 2022-2024 IONIQ 5, 2023-2025 IONIQ 6, Genesis GV60, Genesis GV70 "Electrified," and Genesis G80 "Electrified" vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-volt battery, which can result in a loss of drive power.
Consequence & remedy
Consequence: A loss of drive power increases the risk of a crash.
Remedy: Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed December 20, 2024. Owners may contact Hyundai customer service at 1-855-371-9460 or Genesis customer service at 1-844-340-9741. Hyundai's numbers for this recall are 272 (Hyundai) and 025G (Genesis). This recall expands and replaces previous recall number 24V-204. Vehicles previously repaired under recall 24V-204 will need to have the new remedy completed.
Additional source detail variants (2)
Electrical System:propulsion System:charging:module:software
Hyundai Motor America (Hyundai) is recalling certain 2022-2024 IONIQ 5, 2023-2025 IONIQ 6, Genesis GV60, Genesis GV70 "Electrified," and Genesis G80 "Electrified" vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-volt battery, which can result in a loss of drive power.
Consequence: A loss of drive power increases the risk of a crash.
Remedy: Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed December 20, 2024. Owners may contact Hyundai customer service at 1-855-371-9460 or Genesis customer service at 1-844-340-9741. Hyundai's numbers for this recall are 272 (Hyundai) and 025G (Genesis). This recall expands and replaces previous recall number 24V-204. Vehicles previously repaired under recall 24V-204 will need to have the new remedy completed.
Electrical SYSTEM:12V/24V/48V Battery
Hyundai Motor America (Hyundai) is recalling certain 2022-2024 IONIQ 5, 2023-2025 IONIQ 6, Genesis GV60, Genesis GV70 "Electrified," and Genesis G80 "Electrified" vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-volt battery, which can result in a loss of drive power.
Consequence: A loss of drive power increases the risk of a crash.
Remedy: Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed December 20, 2024. Owners may contact Hyundai customer service at 1-855-371-9460 or Genesis customer service at 1-844-340-9741. Hyundai's numbers for this recall are 272 (Hyundai) and 025G (Genesis). This recall expands and replaces previous recall number 24V-204. Vehicles previously repaired under recall 24V-204 will need to have the new remedy completed.
Mar 15, 2024
Hyundai Motor America (Hyundai) is recalling certain 2022-2024 IONIQ 5, 2023-2024 IONIQ 6, Genesis GV60, Genesis GV70 "Electrified," and Genesis G80 "Electrified" vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-Volt battery, which can result in a loss of drive power.
Consequence & remedy
Consequence: A loss of drive power increases the risk of a crash.
Remedy: This recall is replaced by NHTSA recall number 24V-868. Vehicles already repaired under this recall will need to have the new remedy completed. Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed April 22, 2024. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 257/021G.
Additional source detail variants (2)
Electrical SYSTEM:12V/24V/48V Battery
Hyundai Motor America (Hyundai) is recalling certain 2022-2024 IONIQ 5, 2023-2024 IONIQ 6, Genesis GV60, Genesis GV70 "Electrified," and Genesis G80 "Electrified" vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-Volt battery, which can result in a loss of drive power.
Consequence: A loss of drive power increases the risk of a crash.
Remedy: This recall is replaced by NHTSA recall number 24V-868. Vehicles already repaired under this recall will need to have the new remedy completed. Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed April 22, 2024. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 257/021G.
Electrical System:propulsion System:charging:module:software
Hyundai Motor America (Hyundai) is recalling certain 2022-2024 IONIQ 5, 2023-2024 IONIQ 6, Genesis GV60, Genesis GV70 "Electrified," and Genesis G80 "Electrified" vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-Volt battery, which can result in a loss of drive power.
Consequence: A loss of drive power increases the risk of a crash.
Remedy: This recall is replaced by NHTSA recall number 24V-868. Vehicles already repaired under this recall will need to have the new remedy completed. Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed April 22, 2024. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 257/021G.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE23011 · Loss Of Motive Power
Opened Jun 8, 2023 · Closed Apr 17, 2024
Status: closed (inferred from source dates) · Electrical SYSTEM:12V/24V/48V Battery; Electrical System:propulsion System:dc/dc Converter
On June 8, 2023, the Office of Defect Investigation (ODI) opened PE23011 to investigate allegations of loss of motor power on model year (MY) 2022 Hyundai Ioniq 5 vehicles. Some consumers reported loss of motor power immediately after a warning lamp illumination or reduction of motive power while the vehicle was in motion. This investigation found that the Integrated Charging Control Unit (ICCU) may be subject to various conditions such as overcurrent, overvoltage induced at the end of charging, and certain thermal loading during operation that can damage its internal components and open the ICCU fuse, resulting in an inability to charge the 12-volt battery. The vehicle could eventually lose all motive power, increasing the risk of a crash. In July 2023, Hyundai issued a service campaign to address certain MY 2022-2023 Ioniq 5 and MY 2023 Ioniq 6 vehicles that may have low 12V auxiliary battery charging occurrences due to an ICCU fault and may set the DTC P1A9096 “DC/DC Converter Input Voltage Sensor Fault”. On March 15, 2024, Hyundai filed Safety Recall 24V-204 for 98,878 MY 2022-2024 Hyundai Ioniq 5 vehicles and MY 2023-2024 Hyundai Ioniq 6, Genesis GV60, Genesis GV70 “Electrified” and Genesis G80 “Electrified” vehicles. The recall remedy provides an inspection, and if necessary, a replacement of the ICCU and the associated fuse. The ICCU software reduces the risk of overcurrent and implements voltage peak reduction at the end of EV battery charging. The recall also includes a software update that revises the electric water pump operational threshold to reduce thermal loading during charging and driving. In view of the recall action being taken by Hyundai, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Electrical SYSTEM:12V/24V/48V Battery
On June 8, 2023, the Office of Defect Investigation (ODI) opened PE23011 to investigate allegations of loss of motor power on model year (MY) 2022 Hyundai Ioniq 5 vehicles. Some consumers reported loss of motor power immediately after a warning lamp illumination or reduction of motive power while the vehicle was in motion. This investigation found that the Integrated Charging Control Unit (ICCU) may be subject to various conditions such as overcurrent, overvoltage induced at the end of charging, and certain thermal loading during operation that can damage its internal components and open the ICCU fuse, resulting in an inability to charge the 12-volt battery. The vehicle could eventually lose all motive power, increasing the risk of a crash. In July 2023, Hyundai issued a service campaign to address certain MY 2022-2023 Ioniq 5 and MY 2023 Ioniq 6 vehicles that may have low 12V auxiliary battery charging occurrences due to an ICCU fault and may set the DTC P1A9096 “DC/DC Converter Input Voltage Sensor Fault”. On March 15, 2024, Hyundai filed Safety Recall 24V-204 for 98,878 MY 2022-2024 Hyundai Ioniq 5 vehicles and MY 2023-2024 Hyundai Ioniq 6, Genesis GV60, Genesis GV70 “Electrified” and Genesis G80 “Electrified” vehicles. The recall remedy provides an inspection, and if necessary, a replacement of the ICCU and the associated fuse. The ICCU software reduces the risk of overcurrent and implements voltage peak reduction at the end of EV battery charging. The recall also includes a software update that revises the electric water pump operational threshold to reduce thermal loading during charging and driving. In view of the recall action being taken by Hyundai, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Electrical System:propulsion System:dc/dc Converter
On June 8, 2023, the Office of Defect Investigation (ODI) opened PE23011 to investigate allegations of loss of motor power on model year (MY) 2022 Hyundai Ioniq 5 vehicles. Some consumers reported loss of motor power immediately after a warning lamp illumination or reduction of motive power while the vehicle was in motion. This investigation found that the Integrated Charging Control Unit (ICCU) may be subject to various conditions such as overcurrent, overvoltage induced at the end of charging, and certain thermal loading during operation that can damage its internal components and open the ICCU fuse, resulting in an inability to charge the 12-volt battery. The vehicle could eventually lose all motive power, increasing the risk of a crash. In July 2023, Hyundai issued a service campaign to address certain MY 2022-2023 Ioniq 5 and MY 2023 Ioniq 6 vehicles that may have low 12V auxiliary battery charging occurrences due to an ICCU fault and may set the DTC P1A9096 “DC/DC Converter Input Voltage Sensor Fault”. On March 15, 2024, Hyundai filed Safety Recall 24V-204 for 98,878 MY 2022-2024 Hyundai Ioniq 5 vehicles and MY 2023-2024 Hyundai Ioniq 6, Genesis GV60, Genesis GV70 “Electrified” and Genesis G80 “Electrified” vehicles. The recall remedy provides an inspection, and if necessary, a replacement of the ICCU and the associated fuse. The ICCU software reduces the risk of overcurrent and implements voltage peak reduction at the end of EV battery charging. The recall also includes a software update that revises the electric water pump operational threshold to reduce thermal loading during charging and driving. In view of the recall action being taken by Hyundai, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration