NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
22 reportsClear category filterMileage unknown · Aug 3, 2026
EngineUnknown Or Other
The car engine shutdown mid drive. One minute before the complete stop, the car was stalling every 20 sec or so, then the acceleration stop responding to the drive pedal. The car was gliding to a stopping point. The "Engine " warning was on the display. Afterward, the car was towed to the Earnhardt Hyundai North Scottsdale, wher…
Read full complaint
The car engine shutdown mid drive. One minute before the complete stop, the car was stalling every 20 sec or so, then the acceleration stop responding to the drive pedal. The car was gliding to a stopping point. The "Engine " warning was on the display. Afterward, the car was towed to the Earnhardt Hyundai North Scottsdale, where the service center could not recreate the problem. They concluded that is a non issue since they did not observe the same issue during the test and diagnostic.
NHTSA ODI #11754557
Mileage unknown · Jun 15, 2026
Electrical SystemEngineFuel/propulsion System
On June 13, 2026, my 2024 Hyundai Ioniq 5 experienced a sudden and dangerous propulsion failure while in active motion. The vehicle had approximately 9,447 miles on it and was at 58% battery charge at the time of the incident. The vehicle was leased in January 2025 and has been serviced exclusively at the Hyundai dealership. W…
Read full complaint
On June 13, 2026, my 2024 Hyundai Ioniq 5 experienced a sudden and dangerous propulsion failure while in active motion. The vehicle had approximately 9,447 miles on it and was at 58% battery charge at the time of the incident. The vehicle was leased in January 2025 and has been serviced exclusively at the Hyundai dealership. While driving with two occupants, the vehicle abruptly lost all ability to accelerate. The dashboard displayed a critical warning: “Stop vehicle and check power supply” along with a red battery icon. This failure occurred without warning and immediately placed us in danger of being struck by surrounding traffic, as the vehicle could no longer maintain speed or respond to throttle input. I was able to coast the vehicle off the roadway. Shortly after stopping, the vehicle issued an additional warning stating that auxiliary functions were draining the battery. Within moments, the vehicle shut itself down completely. This left both occupants stranded in extreme heat (over 100°F) with no air conditioning, no ventilation, and no ability to restart or power the vehicle while waiting for rescue. This created a serious risk of heat-related medical distress in addition to the initial roadway hazard. The vehicle’s complete loss of propulsion followed by a full electrical shutdown represents a severe safety defect. At no point should an electric vehicle with more than half a charge and fewer than 10,000 miles lose propulsion during active driving or shut down all systems while occupants are inside. This incident posed a significant risk of collision, injury, or heat-related harm. I am requesting that NHTSA investigate this failure mode, as it may indicate a broader defect affecting the propulsion or battery management systems of the Hyundai Ioniq 5. The vehicle is currently at the Hyundai dealership undergoing diagnostics and they confirmed they had difficulty jumping it to move it from where the tow truck had parked it on arrival.
NHTSA ODI #11744328
Mileage unknown · Apr 11, 2026
Electrical SystemEngine
For the second time, the integrated control unit, ICCU, has failed to this is AFTER being replaced under the recall. The recall solution has not fixed the problem, and is a fake bandaid on a problem that means cars will totally stop working in the middle of the road. This is totally unsafe and unacceptable.
NHTSA ODI #11730552
Mileage unknown · Mar 19, 2026
EngineUnknown Or Other
The vehicle experienced a sudden failure of the 12V battery while on the road. The car stopped completely and became inoperable. At the time of failure, there were no tail lights or proper warning indicators working, which created a very dangerous situation, especially in traffic. I was stuck on the road for about one hour waiti…
Read full complaint
The vehicle experienced a sudden failure of the 12V battery while on the road. The car stopped completely and became inoperable. At the time of failure, there were no tail lights or proper warning indicators working, which created a very dangerous situation, especially in traffic. I was stuck on the road for about one hour waiting for a tow truck. During that time, other vehicles were honking and passing by, increasing the risk of an accident. The vehicle had to be jump-started before it could be moved. Details: What component failed: The 12V battery system failed unexpectedly. The vehicle is available for inspection upon request. Safety risk: Loss of power caused the vehicle to stop on the road with no tail lights, putting my safety and others at serious risk. Reproduction/confirmation: Issue was temporarily resolved with a jump-start, but this is a known issue reported by other owners as well. Inspection: The vehicle has not yet been inspected by the manufacturer or dealer after this incident. Warnings/symptoms: There were no clear warning lights or messages before the failure. The issue happened suddenly without notice.
NHTSA ODI #11725650
Mileage unknown · Mar 19, 2026
Electrical SystemEngineFuel/propulsion System
I was driving and the car gave an electrical system warning, slowed, and thereafter would not go above about 20mph. Fortunately this happened on a local, low speed limit street. I'd rather not think about what might have happened if this had happened on a highway. The Integrated Charging Control Unit (ICCU) is no longer work…
Read full complaint
I was driving and the car gave an electrical system warning, slowed, and thereafter would not go above about 20mph. Fortunately this happened on a local, low speed limit street. I'd rather not think about what might have happened if this had happened on a highway. The Integrated Charging Control Unit (ICCU) is no longer working as it should. The problem has been confirmed by the dealer/manufacturer service station.
NHTSA ODI #11725530
Mileage unknown · Mar 18, 2026
Electrical SystemEnginePower Train
While driving I received the infamous "Stop vehicle and check power supply" warning, and it was then inoperable, needed a tow to the dealer for ICCU replacement. I can't believe you terminated your initial investigation into this in 2023 because they did a recall (which my car received). That recall did not fix the issue. It is…
Read full complaint
While driving I received the infamous "Stop vehicle and check power supply" warning, and it was then inoperable, needed a tow to the dealer for ICCU replacement. I can't believe you terminated your initial investigation into this in 2023 because they did a recall (which my car received). That recall did not fix the issue. It is March 2026 and Ioniq 5 and other models with the same electric system are dying on the road at the same rate as before. There is a large percentage of failed cars, and every failure is dangerous. This is a huge safety issue, and is not receiving adequate oversight by the NHTSA.
NHTSA ODI #11725342
Mileage unknown · Mar 17, 2026
EngineFuel/propulsion SystemPower Train
I was merging onto the highway. I got a warning that I needed to check my electrical system. I was able to back down the highway ramp and park on a side street. Within 20 minutes the car was fully dead and AAA needed to tow it to the dealer. The dealer confirmed that the ICCU needs a replacement. My family is lucky this happen…
Read full complaint
I was merging onto the highway. I got a warning that I needed to check my electrical system. I was able to back down the highway ramp and park on a side street. Within 20 minutes the car was fully dead and AAA needed to tow it to the dealer. The dealer confirmed that the ICCU needs a replacement. My family is lucky this happened in a place we could safely get to a side street. Had it happened 5 minutes later we would have been stranded on the highway with 2 small children.
NHTSA ODI #11724910
Mileage unknown · Feb 23, 2026
Electrical SystemEngine
ICCU failed after 14k miles. Car suddenly went into "turtle" mode (displayed on dash), car could only go 10 mph and my wife had to pull the car off the street asap and was a very scary experience. Dealer has confirmed the ICCU failure and given me a loaner vehicle. No eta on when the part can be fixed, just that it's current sta…
Read full complaint
ICCU failed after 14k miles. Car suddenly went into "turtle" mode (displayed on dash), car could only go 10 mph and my wife had to pull the car off the street asap and was a very scary experience. Dealer has confirmed the ICCU failure and given me a loaner vehicle. No eta on when the part can be fixed, just that it's current status is back order.
NHTSA ODI #11719947
Mileage unknown · Feb 20, 2026
Electrical SystemEnginePower Train
The car stalled while being driven by my son. It displaced an error code. The Car had to be towed to dealership. It was diagnosed with ICCU unit failure. Needs to wait over a months for parts.
NHTSA ODI #11719483
Mileage unknown · Feb 17, 2026
Electrical SystemEnginePower Train
ICCU failure: confirmed by dealership, submitting for your records - while driving the morning of 2/11/26 in Evansville, IN a warning message appeared on the dashboard stating 'Check Electric Vehicle System' followed by a rapid deceleration. Luckily there was not a vehicle behind me as they would have rear ended me. This failure…
Read full complaint
ICCU failure: confirmed by dealership, submitting for your records - while driving the morning of 2/11/26 in Evansville, IN a warning message appeared on the dashboard stating 'Check Electric Vehicle System' followed by a rapid deceleration. Luckily there was not a vehicle behind me as they would have rear ended me. This failure occurred without warning and presented a significant safety hazard, leaving the vehicle stranded in traffic until I was able to restart it. Vehicle went in to turtle mode upon restart, would not go over 20mph at first then I stopped the car, restarted it again, it would move for 15-20 seconds before going in to turtle mode again and now it will not go over 10mph - interestingly, when I would stop and put it in reverse, the vehicle would move 10-20' and then come to a very abrupt stop as the entire vehicle shut off - had to tow the vehicle to the Hyundai dealership in Evansville Indiana where the ICCU was confirmed has having failed
NHTSA ODI #11718559
Official recalls
3Jul 2, 2026
Hyundai Motor America (Hyundai) is recalling certain 2023-2024 Ioniq 5 vehicles. The high voltage battery cells may contain misaligned electrodes, which can lead to a fire while parked or driving.
Consequence & remedy
Consequence: A fire increases the risk of injury.
Remedy: Owners are advised to park outside and away from structures and limit their charge to a maximum of 80% until the recall repair is complete. Dealers will replace the high voltage battery system assembly, free of charge. Owner notification letters are expected to be mailed August 31, 2026. Owners may contact Hyundai's customer service at 855-371-9460. Hyundai's number for this recall is 305. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 3, 2026.
Nov 18, 2024
Hyundai Motor America (Hyundai) is recalling certain 2022-2024 IONIQ 5, 2023-2025 IONIQ 6, Genesis GV60, Genesis GV70 "Electrified," and Genesis G80 "Electrified" vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-volt battery, which can result in a loss of drive power.
Consequence & remedy
Consequence: A loss of drive power increases the risk of a crash.
Remedy: Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed December 20, 2024. Owners may contact Hyundai customer service at 1-855-371-9460 or Genesis customer service at 1-844-340-9741. Hyundai's numbers for this recall are 272 (Hyundai) and 025G (Genesis). This recall expands and replaces previous recall number 24V-204. Vehicles previously repaired under recall 24V-204 will need to have the new remedy completed.
Additional source detail variants (2)
Electrical System:propulsion System:charging:module:software
Hyundai Motor America (Hyundai) is recalling certain 2022-2024 IONIQ 5, 2023-2025 IONIQ 6, Genesis GV60, Genesis GV70 "Electrified," and Genesis G80 "Electrified" vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-volt battery, which can result in a loss of drive power.
Consequence: A loss of drive power increases the risk of a crash.
Remedy: Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed December 20, 2024. Owners may contact Hyundai customer service at 1-855-371-9460 or Genesis customer service at 1-844-340-9741. Hyundai's numbers for this recall are 272 (Hyundai) and 025G (Genesis). This recall expands and replaces previous recall number 24V-204. Vehicles previously repaired under recall 24V-204 will need to have the new remedy completed.
Electrical SYSTEM:12V/24V/48V Battery
Hyundai Motor America (Hyundai) is recalling certain 2022-2024 IONIQ 5, 2023-2025 IONIQ 6, Genesis GV60, Genesis GV70 "Electrified," and Genesis G80 "Electrified" vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-volt battery, which can result in a loss of drive power.
Consequence: A loss of drive power increases the risk of a crash.
Remedy: Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed December 20, 2024. Owners may contact Hyundai customer service at 1-855-371-9460 or Genesis customer service at 1-844-340-9741. Hyundai's numbers for this recall are 272 (Hyundai) and 025G (Genesis). This recall expands and replaces previous recall number 24V-204. Vehicles previously repaired under recall 24V-204 will need to have the new remedy completed.
Mar 15, 2024
Hyundai Motor America (Hyundai) is recalling certain 2022-2024 IONIQ 5, 2023-2024 IONIQ 6, Genesis GV60, Genesis GV70 "Electrified," and Genesis G80 "Electrified" vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-Volt battery, which can result in a loss of drive power.
Consequence & remedy
Consequence: A loss of drive power increases the risk of a crash.
Remedy: This recall is replaced by NHTSA recall number 24V-868. Vehicles already repaired under this recall will need to have the new remedy completed. Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed April 22, 2024. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 257/021G.
Additional source detail variants (2)
Electrical SYSTEM:12V/24V/48V Battery
Hyundai Motor America (Hyundai) is recalling certain 2022-2024 IONIQ 5, 2023-2024 IONIQ 6, Genesis GV60, Genesis GV70 "Electrified," and Genesis G80 "Electrified" vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-Volt battery, which can result in a loss of drive power.
Consequence: A loss of drive power increases the risk of a crash.
Remedy: This recall is replaced by NHTSA recall number 24V-868. Vehicles already repaired under this recall will need to have the new remedy completed. Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed April 22, 2024. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 257/021G.
Electrical System:propulsion System:charging:module:software
Hyundai Motor America (Hyundai) is recalling certain 2022-2024 IONIQ 5, 2023-2024 IONIQ 6, Genesis GV60, Genesis GV70 "Electrified," and Genesis G80 "Electrified" vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-Volt battery, which can result in a loss of drive power.
Consequence: A loss of drive power increases the risk of a crash.
Remedy: This recall is replaced by NHTSA recall number 24V-868. Vehicles already repaired under this recall will need to have the new remedy completed. Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed April 22, 2024. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 257/021G.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE23011 · Loss Of Motive Power
Opened Jun 8, 2023 · Closed Apr 17, 2024
Status: closed (inferred from source dates) · Electrical SYSTEM:12V/24V/48V Battery; Electrical System:propulsion System:dc/dc Converter
On June 8, 2023, the Office of Defect Investigation (ODI) opened PE23011 to investigate allegations of loss of motor power on model year (MY) 2022 Hyundai Ioniq 5 vehicles. Some consumers reported loss of motor power immediately after a warning lamp illumination or reduction of motive power while the vehicle was in motion. This investigation found that the Integrated Charging Control Unit (ICCU) may be subject to various conditions such as overcurrent, overvoltage induced at the end of charging, and certain thermal loading during operation that can damage its internal components and open the ICCU fuse, resulting in an inability to charge the 12-volt battery. The vehicle could eventually lose all motive power, increasing the risk of a crash. In July 2023, Hyundai issued a service campaign to address certain MY 2022-2023 Ioniq 5 and MY 2023 Ioniq 6 vehicles that may have low 12V auxiliary battery charging occurrences due to an ICCU fault and may set the DTC P1A9096 “DC/DC Converter Input Voltage Sensor Fault”. On March 15, 2024, Hyundai filed Safety Recall 24V-204 for 98,878 MY 2022-2024 Hyundai Ioniq 5 vehicles and MY 2023-2024 Hyundai Ioniq 6, Genesis GV60, Genesis GV70 “Electrified” and Genesis G80 “Electrified” vehicles. The recall remedy provides an inspection, and if necessary, a replacement of the ICCU and the associated fuse. The ICCU software reduces the risk of overcurrent and implements voltage peak reduction at the end of EV battery charging. The recall also includes a software update that revises the electric water pump operational threshold to reduce thermal loading during charging and driving. In view of the recall action being taken by Hyundai, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Electrical SYSTEM:12V/24V/48V Battery
On June 8, 2023, the Office of Defect Investigation (ODI) opened PE23011 to investigate allegations of loss of motor power on model year (MY) 2022 Hyundai Ioniq 5 vehicles. Some consumers reported loss of motor power immediately after a warning lamp illumination or reduction of motive power while the vehicle was in motion. This investigation found that the Integrated Charging Control Unit (ICCU) may be subject to various conditions such as overcurrent, overvoltage induced at the end of charging, and certain thermal loading during operation that can damage its internal components and open the ICCU fuse, resulting in an inability to charge the 12-volt battery. The vehicle could eventually lose all motive power, increasing the risk of a crash. In July 2023, Hyundai issued a service campaign to address certain MY 2022-2023 Ioniq 5 and MY 2023 Ioniq 6 vehicles that may have low 12V auxiliary battery charging occurrences due to an ICCU fault and may set the DTC P1A9096 “DC/DC Converter Input Voltage Sensor Fault”. On March 15, 2024, Hyundai filed Safety Recall 24V-204 for 98,878 MY 2022-2024 Hyundai Ioniq 5 vehicles and MY 2023-2024 Hyundai Ioniq 6, Genesis GV60, Genesis GV70 “Electrified” and Genesis G80 “Electrified” vehicles. The recall remedy provides an inspection, and if necessary, a replacement of the ICCU and the associated fuse. The ICCU software reduces the risk of overcurrent and implements voltage peak reduction at the end of EV battery charging. The recall also includes a software update that revises the electric water pump operational threshold to reduce thermal loading during charging and driving. In view of the recall action being taken by Hyundai, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Electrical System:propulsion System:dc/dc Converter
On June 8, 2023, the Office of Defect Investigation (ODI) opened PE23011 to investigate allegations of loss of motor power on model year (MY) 2022 Hyundai Ioniq 5 vehicles. Some consumers reported loss of motor power immediately after a warning lamp illumination or reduction of motive power while the vehicle was in motion. This investigation found that the Integrated Charging Control Unit (ICCU) may be subject to various conditions such as overcurrent, overvoltage induced at the end of charging, and certain thermal loading during operation that can damage its internal components and open the ICCU fuse, resulting in an inability to charge the 12-volt battery. The vehicle could eventually lose all motive power, increasing the risk of a crash. In July 2023, Hyundai issued a service campaign to address certain MY 2022-2023 Ioniq 5 and MY 2023 Ioniq 6 vehicles that may have low 12V auxiliary battery charging occurrences due to an ICCU fault and may set the DTC P1A9096 “DC/DC Converter Input Voltage Sensor Fault”. On March 15, 2024, Hyundai filed Safety Recall 24V-204 for 98,878 MY 2022-2024 Hyundai Ioniq 5 vehicles and MY 2023-2024 Hyundai Ioniq 6, Genesis GV60, Genesis GV70 “Electrified” and Genesis G80 “Electrified” vehicles. The recall remedy provides an inspection, and if necessary, a replacement of the ICCU and the associated fuse. The ICCU software reduces the risk of overcurrent and implements voltage peak reduction at the end of EV battery charging. The recall also includes a software update that revises the electric water pump operational threshold to reduce thermal loading during charging and driving. In view of the recall action being taken by Hyundai, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration