NHTSA owner reports · September 18, 2026 snapshot.
Unknown Or Other complaints
30 reportsClear category filterMileage unknown · Apr 28, 2025
EngineFuel/propulsion SystemUnknown Or Other
Hyundai Ioniq EV's have a continuing issue with a component called that "ICCU". The ICCU and high voltage fuse failed even after two recalls meant to monitor that problem and update the software. Luckily, mine failed in my driveway at home which did not put me in immediate risk. However, many people have this part fail while d…
Read full complaint
Hyundai Ioniq EV's have a continuing issue with a component called that "ICCU". The ICCU and high voltage fuse failed even after two recalls meant to monitor that problem and update the software. Luckily, mine failed in my driveway at home which did not put me in immediate risk. However, many people have this part fail while driving on roads and highways with zero warning. There have been two ICCU-related recalls that my car has had. When I started my vehicle I heard a "pop" and then the dashboard said "Check vehicle electrical system" and then shows the "limp mode" icon allowing to drive the vehicle at a slow speed to safety.
NHTSA ODI #11657228
Mileage unknown · Apr 22, 2025
Unknown Or Other
Leaving an appt and the car gave a battery ! Warning. While is was looking for a place to pull over the Stop Check Vehicle Electric System. I pulled into a parking lot when the Turtle came up and I was barely able to back into a space. The car was dead within 10 mins of leaving until I parked. I commute daily on an interstat…
Read full complaint
Leaving an appt and the car gave a battery ! Warning. While is was looking for a place to pull over the Stop Check Vehicle Electric System. I pulled into a parking lot when the Turtle came up and I was barely able to back into a space. The car was dead within 10 mins of leaving until I parked. I commute daily on an interstate and that would not have given me much time to pull of the interstate to a safe location. Longer warning is needed. Dealer has the car and confirmed it is the ICCU unit and no eta on the part. Yet they are selling 2025 Ionic 5.
NHTSA ODI #11656128
Mileage unknown · Dec 18, 2024
Unknown Or Other
Drove less than one mile and the car suddenly dropped from 45 mph to 20 and would not accelerate (I was almost rear ended by a bus). I was able to pull off the road and the battery died.
NHTSA ODI #11631373
Mileage unknown · Aug 15, 2024
Unknown Or Other
Car has suddenly lost power three times while driving at low speeds or while stopped (eg at a stop light). I have turned off the power (EV start button) and then turned it back on, and the car restarts and starts moving again. The sudden loss of power seems dangerous-- I am concerned that if someone is following close behind…
Read full complaint
Car has suddenly lost power three times while driving at low speeds or while stopped (eg at a stop light). I have turned off the power (EV start button) and then turned it back on, and the car restarts and starts moving again. The sudden loss of power seems dangerous-- I am concerned that if someone is following close behind me, they will be unable to brake and I will be rear-ended. Please note that I purchased this vehicle used and the problem started occurring the 2nd day I drove the car. (The car was bought back by a dealer in FL under the state lemon law and was subsequently purchased by a dealer in NJ, from whom I purchased the car.) I suspect the same problem was occurring when the vehicle was bought back by the Fl dealer, and it was not properly fixed.
NHTSA ODI #11608839
Mileage unknown · Jun 14, 2024
Electrical SystemUnknown Or Other
What component or system failed or malfunctioned, and is it available for inspection upon request? The ICCU failed. The car won't charge on a level 1, 2, or 3 charger. The failure happened in the middle of a charging session. Since failing when trying to charge the car says "charging unsuccessful". The dealer has had the car for…
Read full complaint
What component or system failed or malfunctioned, and is it available for inspection upon request? The ICCU failed. The car won't charge on a level 1, 2, or 3 charger. The failure happened in the middle of a charging session. Since failing when trying to charge the car says "charging unsuccessful". The dealer has had the car for 28 days and won't tell me when it will be fixed. How was your safety or the safety of others put at risk? Yes. My family. Thankfully the failure happened in our garage. If it had of happened when we were away from home we would have been left stranded unable to charge. Also, if the ICCU fails while driving the car loses all power and comes to a stop. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes. It has been at the dealer for 28 days Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? It has been inspected by the dealer Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No, there were no warnings prior. All ICCU related recalls had been performed.
NHTSA ODI #11594323
Mileage unknown · May 29, 2024
Electrical SystemUnknown Or Other
This has happened twice so far. I was driving down the street on the main road and the check evs error came on with a yellow triangle ⚠️ light came on. Suddenly the car slowed down, it was hard to steer but I was able to get it to a neighborhood near the school before it shut down. It scare me to know what would have happened if…
Read full complaint
This has happened twice so far. I was driving down the street on the main road and the check evs error came on with a yellow triangle ⚠️ light came on. Suddenly the car slowed down, it was hard to steer but I was able to get it to a neighborhood near the school before it shut down. It scare me to know what would have happened if that was on a freeway. Now, because of the fear I hardly drive the car. The last time this happened was yesterday.
NHTSA ODI #11591280
Mileage unknown · May 29, 2024
Electrical SystemService BrakesUnknown Or Other
When you place the car in park a recall was done so that the emergency parking brake automatically engages. Well between 30 seconds to a minute after the car is in park, the brake disengage. When you go to set it manually after it disengage, it will still disengage.
NHTSA ODI #11591277
Mileage unknown · Mar 5, 2024
Unknown Or Other
Highway speed vibration of entire vehicle, particularly steering wheel and seats. This continues despite wheel balance, forced wheel balance and replacing all 4 tires. Multiple trips to dealer without improvement. Test drive of a new, same model vehicle with same or more road vibration at high speed. Numerous same complaints …
Read full complaint
Highway speed vibration of entire vehicle, particularly steering wheel and seats. This continues despite wheel balance, forced wheel balance and replacing all 4 tires. Multiple trips to dealer without improvement. Test drive of a new, same model vehicle with same or more road vibration at high speed. Numerous same complaints on internet forums.
NHTSA ODI #11575566
Mileage unknown · Feb 3, 2024
Electrical SystemEngineUnknown Or Other
It is UNKNOWN what component or system failed There was a sudden and total electrical failure with the inability to safely move the car. If this electrical failure had occurred on a turnpike or expressway it would have been a catastrophic event. Car was flat bedded to a dealership Dashboard warning provided less than 5 min time …
Read full complaint
It is UNKNOWN what component or system failed There was a sudden and total electrical failure with the inability to safely move the car. If this electrical failure had occurred on a turnpike or expressway it would have been a catastrophic event. Car was flat bedded to a dealership Dashboard warning provided less than 5 min time and 0.5 mile before ceasing to operate at all although car's computer thought that the car's health was OK.
NHTSA ODI #11569668
Mileage unknown · Aug 30, 2023
Service BrakesUnknown Or Other
Vehicle suspension in the rear feels unsettled when coming to a stop using regenerative brakes. If you hit a small pothole or recessed manhole cover the rear of the vehicle feels like the rear suspension is jumping. I've taken it to the dealer and they noticed it and also it occurred on a new ioniq 5 they had on the lot also.
NHTSA ODI #11541676
Official recalls
3Nov 18, 2024
Hyundai Motor America (Hyundai) is recalling certain 2022-2024 IONIQ 5, 2023-2025 IONIQ 6, Genesis GV60, Genesis GV70 "Electrified," and Genesis G80 "Electrified" vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-volt battery, which can result in a loss of drive power.
Consequence & remedy
Consequence: A loss of drive power increases the risk of a crash.
Remedy: Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed December 20, 2024. Owners may contact Hyundai customer service at 1-855-371-9460 or Genesis customer service at 1-844-340-9741. Hyundai's numbers for this recall are 272 (Hyundai) and 025G (Genesis). This recall expands and replaces previous recall number 24V-204. Vehicles previously repaired under recall 24V-204 will need to have the new remedy completed.
Additional source detail variants (2)
Electrical System:propulsion System:charging:module:software
Hyundai Motor America (Hyundai) is recalling certain 2022-2024 IONIQ 5, 2023-2025 IONIQ 6, Genesis GV60, Genesis GV70 "Electrified," and Genesis G80 "Electrified" vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-volt battery, which can result in a loss of drive power.
Consequence: A loss of drive power increases the risk of a crash.
Remedy: Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed December 20, 2024. Owners may contact Hyundai customer service at 1-855-371-9460 or Genesis customer service at 1-844-340-9741. Hyundai's numbers for this recall are 272 (Hyundai) and 025G (Genesis). This recall expands and replaces previous recall number 24V-204. Vehicles previously repaired under recall 24V-204 will need to have the new remedy completed.
Electrical SYSTEM:12V/24V/48V Battery
Hyundai Motor America (Hyundai) is recalling certain 2022-2024 IONIQ 5, 2023-2025 IONIQ 6, Genesis GV60, Genesis GV70 "Electrified," and Genesis G80 "Electrified" vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-volt battery, which can result in a loss of drive power.
Consequence: A loss of drive power increases the risk of a crash.
Remedy: Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed December 20, 2024. Owners may contact Hyundai customer service at 1-855-371-9460 or Genesis customer service at 1-844-340-9741. Hyundai's numbers for this recall are 272 (Hyundai) and 025G (Genesis). This recall expands and replaces previous recall number 24V-204. Vehicles previously repaired under recall 24V-204 will need to have the new remedy completed.
Mar 15, 2024
Hyundai Motor America (Hyundai) is recalling certain 2022-2024 IONIQ 5, 2023-2024 IONIQ 6, Genesis GV60, Genesis GV70 "Electrified," and Genesis G80 "Electrified" vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-Volt battery, which can result in a loss of drive power.
Consequence & remedy
Consequence: A loss of drive power increases the risk of a crash.
Remedy: This recall is replaced by NHTSA recall number 24V-868. Vehicles already repaired under this recall will need to have the new remedy completed. Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed April 22, 2024. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 257/021G.
Additional source detail variants (2)
Electrical SYSTEM:12V/24V/48V Battery
Hyundai Motor America (Hyundai) is recalling certain 2022-2024 IONIQ 5, 2023-2024 IONIQ 6, Genesis GV60, Genesis GV70 "Electrified," and Genesis G80 "Electrified" vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-Volt battery, which can result in a loss of drive power.
Consequence: A loss of drive power increases the risk of a crash.
Remedy: This recall is replaced by NHTSA recall number 24V-868. Vehicles already repaired under this recall will need to have the new remedy completed. Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed April 22, 2024. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 257/021G.
Electrical System:propulsion System:charging:module:software
Hyundai Motor America (Hyundai) is recalling certain 2022-2024 IONIQ 5, 2023-2024 IONIQ 6, Genesis GV60, Genesis GV70 "Electrified," and Genesis G80 "Electrified" vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-Volt battery, which can result in a loss of drive power.
Consequence: A loss of drive power increases the risk of a crash.
Remedy: This recall is replaced by NHTSA recall number 24V-868. Vehicles already repaired under this recall will need to have the new remedy completed. Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed April 22, 2024. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 257/021G.
May 11, 2022
Hyundai Motor America (Hyundai) is recalling certain 2022 Ioniq 5 vehicles. A software error in the Shifter Control Unit (SCU) may disengage the parking mechanism, which can allow the vehicle to rollaway.
Consequence & remedy
Consequence: Vehicle rollaway can increase the risk of a crash or injury.
Remedy: Drivers are recommended to use the Electronic Parking Brake (EPB) when parking their vehicles until the remedy has been performed. Dealers will update the Shifter Control Unit software, free of charge. Owner notification letters were mailed July 14, 2022. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 228.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE24028 · Electrical Arcing And Thermal Events, Potentially Leading To Fires, While Utilizing Enel X Way Usa, Llc's Juicebox Residential Charger.
Opened Oct 3, 2024 · Closed Jun 5, 2025
Status: closed (inferred from source dates) · Equipment:electrical
On October 3, 2024, the Office of Defects Investigations (ODI) opened PE24028 to investigate alleged failures of Enel X Way's JuiceBox Level 2 residential EV chargers. The allegations were described as thermal incidents and electrical malfunctions, which could trip the circuit breakers in Juicebox owners’ homes and disrupt electric vehicle charge cycles. On October 2, 2024, Enel X Way posted on its website that Enel X Way North America would cease operations in the United States and Canada on October 11, 2024. The closure would potentially impact the charging app and supporting software. ODI sent Enel X Way an Information Request (IR) letter on October 21, 2024. Enel X Way provided an incomplete response to the IR on December 9, 2024. Enel X Way later provided a complete response to the IR on January 24, 2025. ODI reviewed Enel X Way’s IR submissions to determine whether further action is required. Based on ODI’s analysis, there was no clear trend in the cause of the failures described in customer complaints and warranty reports. Additionally, there have been no recent reports alleging safety issues. The available information does not warrant further action at this time. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency will continue to monitor for any safety trends and reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in this Closing Resume, go to NHTSA.gov.
PE23011 · Loss Of Motive Power
Opened Jun 8, 2023 · Closed Apr 17, 2024
Status: closed (inferred from source dates) · Electrical SYSTEM:12V/24V/48V Battery; Electrical System:propulsion System:dc/dc Converter
On June 8, 2023, the Office of Defect Investigation (ODI) opened PE23011 to investigate allegations of loss of motor power on model year (MY) 2022 Hyundai Ioniq 5 vehicles. Some consumers reported loss of motor power immediately after a warning lamp illumination or reduction of motive power while the vehicle was in motion. This investigation found that the Integrated Charging Control Unit (ICCU) may be subject to various conditions such as overcurrent, overvoltage induced at the end of charging, and certain thermal loading during operation that can damage its internal components and open the ICCU fuse, resulting in an inability to charge the 12-volt battery. The vehicle could eventually lose all motive power, increasing the risk of a crash. In July 2023, Hyundai issued a service campaign to address certain MY 2022-2023 Ioniq 5 and MY 2023 Ioniq 6 vehicles that may have low 12V auxiliary battery charging occurrences due to an ICCU fault and may set the DTC P1A9096 “DC/DC Converter Input Voltage Sensor Fault”. On March 15, 2024, Hyundai filed Safety Recall 24V-204 for 98,878 MY 2022-2024 Hyundai Ioniq 5 vehicles and MY 2023-2024 Hyundai Ioniq 6, Genesis GV60, Genesis GV70 “Electrified” and Genesis G80 “Electrified” vehicles. The recall remedy provides an inspection, and if necessary, a replacement of the ICCU and the associated fuse. The ICCU software reduces the risk of overcurrent and implements voltage peak reduction at the end of EV battery charging. The recall also includes a software update that revises the electric water pump operational threshold to reduce thermal loading during charging and driving. In view of the recall action being taken by Hyundai, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Electrical SYSTEM:12V/24V/48V Battery
On June 8, 2023, the Office of Defect Investigation (ODI) opened PE23011 to investigate allegations of loss of motor power on model year (MY) 2022 Hyundai Ioniq 5 vehicles. Some consumers reported loss of motor power immediately after a warning lamp illumination or reduction of motive power while the vehicle was in motion. This investigation found that the Integrated Charging Control Unit (ICCU) may be subject to various conditions such as overcurrent, overvoltage induced at the end of charging, and certain thermal loading during operation that can damage its internal components and open the ICCU fuse, resulting in an inability to charge the 12-volt battery. The vehicle could eventually lose all motive power, increasing the risk of a crash. In July 2023, Hyundai issued a service campaign to address certain MY 2022-2023 Ioniq 5 and MY 2023 Ioniq 6 vehicles that may have low 12V auxiliary battery charging occurrences due to an ICCU fault and may set the DTC P1A9096 “DC/DC Converter Input Voltage Sensor Fault”. On March 15, 2024, Hyundai filed Safety Recall 24V-204 for 98,878 MY 2022-2024 Hyundai Ioniq 5 vehicles and MY 2023-2024 Hyundai Ioniq 6, Genesis GV60, Genesis GV70 “Electrified” and Genesis G80 “Electrified” vehicles. The recall remedy provides an inspection, and if necessary, a replacement of the ICCU and the associated fuse. The ICCU software reduces the risk of overcurrent and implements voltage peak reduction at the end of EV battery charging. The recall also includes a software update that revises the electric water pump operational threshold to reduce thermal loading during charging and driving. In view of the recall action being taken by Hyundai, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Electrical System:propulsion System:dc/dc Converter
On June 8, 2023, the Office of Defect Investigation (ODI) opened PE23011 to investigate allegations of loss of motor power on model year (MY) 2022 Hyundai Ioniq 5 vehicles. Some consumers reported loss of motor power immediately after a warning lamp illumination or reduction of motive power while the vehicle was in motion. This investigation found that the Integrated Charging Control Unit (ICCU) may be subject to various conditions such as overcurrent, overvoltage induced at the end of charging, and certain thermal loading during operation that can damage its internal components and open the ICCU fuse, resulting in an inability to charge the 12-volt battery. The vehicle could eventually lose all motive power, increasing the risk of a crash. In July 2023, Hyundai issued a service campaign to address certain MY 2022-2023 Ioniq 5 and MY 2023 Ioniq 6 vehicles that may have low 12V auxiliary battery charging occurrences due to an ICCU fault and may set the DTC P1A9096 “DC/DC Converter Input Voltage Sensor Fault”. On March 15, 2024, Hyundai filed Safety Recall 24V-204 for 98,878 MY 2022-2024 Hyundai Ioniq 5 vehicles and MY 2023-2024 Hyundai Ioniq 6, Genesis GV60, Genesis GV70 “Electrified” and Genesis G80 “Electrified” vehicles. The recall remedy provides an inspection, and if necessary, a replacement of the ICCU and the associated fuse. The ICCU software reduces the risk of overcurrent and implements voltage peak reduction at the end of EV battery charging. The recall also includes a software update that revises the electric water pump operational threshold to reduce thermal loading during charging and driving. In view of the recall action being taken by Hyundai, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
Illustration