2022 Hyundai Ioniq 5

The car would no longer charge and the dealer said it is due to a faulty ICCU. The dealer said this part is on back order with an indefinite freeze and no ETA. My car has been at the dealership shop since January 29 and Hyundai corporate has not been helpful when I escalated to them. Overall I have had these charging issues since early December. Hyundai has denied my request to buyback the vehicle since it is over 4 years old now (2022). I’m very disappointed and concerned about the ongoing ability for this vehicle to be safe and drivable.

The ICCU failed. The car is at the dealership, availability of the failed part is unknown. The vehicle was no longer able to charge the battery. This could have happened while driving. The dealership has confirmed failure and will replace when a new part is available. Unknown if part has been inspected by others. Hyundai case has been opened. There was no warning. Indication of problem was breaker tripping at charging.

For the past few days, our 2022 Hyundai Ioniq 5 (approx. 83,000 miles) has been unable to charge using AC charging (Level 1 or Level 2). The failure is repeatable and consistent across multiple chargers: two separate home Level 2 chargers, the Hyundai-provided Level 1 charger, and a neighbor’s Level 2 charger. In each case, charging either fails to start or stops shortly after initiating. DC fast charging continues to work normally. Component/system suspected: The problem appears related to the vehicle’s onboard AC charging system (possible ICCU, onboard charger/OBC, charge port/inlet, or related high-voltage charging components). The vehicle and components are available for inspection upon request. Safety risk: This creates a safety concern because we cannot reliably charge the vehicle at home or at most public charging locations (which are predominantly Level 2 AC). This increases the risk of unexpectedly running out of charge and becoming stranded in unsafe locations, especially where DC fast chargers are not available. Reproduction/confirmation: The issue has been reproduced on multiple independent AC chargers, making it unlikely to be caused by a single EVSE/charger. A dealer appointment is scheduled for diagnosis and confirmation. Warning lamps/messages: When attempting AC charging, the vehicle reports a charging failure/unsuccessful charging condition (exact message UNKNOWN). No prior warning lamps were noticed before the issue began (UNKNOWN). This issue appears to be widespread based on numerous similar owner reports of AC charging failure on Ioniq 5 vehicles while DC fast charging still works, suggesting a potential systemic defect in the onboard charging/ICCU-related hardware.

The contact owns a 2022 Hyundai Ioniq 5. The contact stated that while driving at an undisclosed speed, the message “Check Electrical System Immediately” was displayed. The contact stated that the failure had occurred while the contact's minor children were inside the vehicle. The vehicle was driven to the residence. The vehicle was later towed to the dealer, where it was diagnosed with a failed ICCU and fuse. The contact was informed that the ICCU and fuse needed to be replaced. The vehicle was not repaired. The contact was informed that the parts for the repair were on back order. In addition, the contact stated that the vehicle was repaired under NHTSA Campaign Number: 24V868000 (Electrical System); in February 2025. The contact stated that only the software update was performed. In addition, the contact stated that the failure was a known failure with the vehicle. The manufacturer was made aware of the failure, and a case was filed. The contact was informed that the vehicle was no longer covered under warranty. The failure mileage was approximately 120,000.

ICCU failed second time wednesday february 18, 2026. First ICCU failed November 2024 and replaced under warranty. The car went in turtle mode.....20 mph or less. Limped along safely on side of roadway and used sideroads. The dealer says the ICCU and fuse need to be replaced. The dealer wants me to pay for this part, third time is a charm? I don't think I could ever trust this part again. They want to give me the exact same part they gave me when the ICCU failed b4. There were 2 messages: stop vehicle and check power supply ......check electric vehicle system. They were timely and made this failure a bit safer. The dealer inspected the vehicle but not the manufacturer or anyone else. The car is at Balise Hyundai Fairfield CT I BELIEVE 10% OF THESE ICCUs ARE DEFECTIVE.

My 2022 Ioniq5 left me stranded late at night in a freezing rainstorm in March of 2024 when I was 75 miles from home at it failed to charge both D/C fast charging and A/C level 2 charging, despite my trying several different chargers. The car gave me the dreaded "Check E/V System" warning when it failed to charge. It turned out to be the notorious ICCU but also the AC inverter, which had to be replaced. It took 12 days. The dealership's initial diagnosis was something draining the 12-volt battery, so I asked if they also replaced that. They said no because it had tested fine, but 9 days after I picked up the car, it did not start because it turned out the 12-volt battery was dead, and my dealership spent 2 days getting Hyundai to approve replacement of the 12-vold under warranty. Last month, 17 January 2026, my Ioniq5 again left me stranded. This time 120 miles from home in a snowstorm. It D/C charged for 10 minutes before the charging stopped and it gave me the dreaded “Check E/V System” warning. I tried two nearby Tesla Superchargers with my Hyundai issued adapter, and they both failed. I had just enough charge to make it to a dealership 110 miles from my home, where the vehicle stayed for nearly a month while they diagnosed and repaired it by replacing the AC inverter (note that had been replaced the last time) and also the AC compressor. The ICCU failures are well-known and well-documented, but the AC inverters that failed on me twice do not seem to be as common and should probably be investigated. In both cases I was stranded on Saturdays when no dealership service departments were open until the following Monday, so I had to pay for a motel overnight, which Hyundai refused to reimburse because I was not at least 150 miles from home.

Q: What component or system failed or malfunctioned, and is it available for inspection upon request? A: ICCU failed - Not available for inspection (at least at this time, but willing to try and make it work). Q: How was your safety or the safety of others put at risk? A: The ICCU (Integrated Charging Control Unit) is a safety-critical component subject to federal recalls 24V-204 and 24V-868. (My vehicle had all recalls performed prior to this failure.) The failure occurred while driving which was indicated by a “popping” sound. It is contextually important to note that the ICCU is responsible for charging the 12v battery, had the 12v battery failed during the duration of my drive I would have experienced a sudden loss of motive power. A sudden loss of motive power is an unacceptable risk to public safety. Q: Has the problem been reproduced or confirmed by a dealer or independent service center? A: Yes, the problem has been reproduced and confirmed to be an ICCU failure by an official Hyundai service center. Q: Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? A: No. Q: Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? A: Symptoms first appeared February 14, 2026. The first symptom of failure was the signature “pop” sound that the ICCU failure is known for. Only after my drive and upon attempting L1/L2 charging did my dash warning indicate “Check Electric Vehicle System.” I also checked for codes with my OBDII scanner, and it showed no codes.

While making the short drive to work on surface streets I was given a warning in an amber circle to check the electrical system. Moments later I was presented with a warning in a red circle reading "Stop vehicle and check power supply"; accompanying this warning was a drastic loss in power. Had I been on the highway I would not have been able to maintain speed with the likelihood of being stranded in an unsafe location. The dealership reported that the ICCU (internal charge control unit) had failed. This is the second such failure on this car. It has been over 4 weeks since the dealership received the car, and Hyundai has not been able to supply repair parts.