NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
304 reportsClear category filterMileage unknown · Jun 20, 2023
Electrical System
On Apr 18, 2023, My vehicle had a complete electrical system failure while driving on the local street. When the failure occurred, a warning message along with loud audible beeps was displayed suddenly indicating the vehicle was experiencing an Electrical System failure, and we must be pulled over immediately without delay due …
Read full complaint
On Apr 18, 2023, My vehicle had a complete electrical system failure while driving on the local street. When the failure occurred, a warning message along with loud audible beeps was displayed suddenly indicating the vehicle was experiencing an Electrical System failure, and we must be pulled over immediately without delay due to safety concerns. The system completely failed shortly after, and the vehicle became unresponsive and inoperable. This post a major safety risk to those inside the vehicle, other vehicles, and pedestrians nearby if the vehicle became inoperable in the middle of traffic. The vehicle was towed to the dealership (Stevens Creek Hyundai, Santa Clara, California) the following day for inspection. The inspection report indicated a failure in the ICCU fuse unit and the 12V battery. This issue falls into the power train defect and repair will be covered under the manufacturer's warranty. The vehicle has been with the dealership for 6 weeks to date (Jun 20) without a repair ETA. The vehicle was purchased brand new in Mar 2022. It was only 13 months new, with 8090 miles at the time of incident. The work order is attached.
NHTSA ODI #11527949
Mileage unknown · Jun 20, 2023
Electrical System
I was driving about 30 mph on a secondary road when the vehicle suddenly lost power and speed and a large batter warning light came on on the dash. I restarted the vehicle, and the same thing happened again. We had the car taken to Peder Hyndai in Poway, CA. 858-486-6560. They said that there was a fault with the "battery contro…
Read full complaint
I was driving about 30 mph on a secondary road when the vehicle suddenly lost power and speed and a large batter warning light came on on the dash. I restarted the vehicle, and the same thing happened again. We had the car taken to Peder Hyndai in Poway, CA. 858-486-6560. They said that there was a fault with the "battery control module", and that they would have to order parts. They said they had "at least two" other ionic 5s with the same problem. We've been driving a loaner for 1 mo, and still the part hasn't arrived. This was the third trip that day, and there were no problems with the earlier trips. This had never happened before. The car did not make any unusual sound that sticks in my mind during the episode.
NHTSA ODI #11527880
Mileage unknown · Jun 20, 2023
Electrical SystemPower Train
The vehicle completely lost power and there was 207 miles left to the charge. The message displayed on the driver's screen read "12V battery voltage low. Stop safely" I had no other choice than to stop since the car suddenly had zero power. The car was towed to Hyundai dealership on 2/15/23 and I have yet to have the vehicle re…
Read full complaint
The vehicle completely lost power and there was 207 miles left to the charge. The message displayed on the driver's screen read "12V battery voltage low. Stop safely" I had no other choice than to stop since the car suddenly had zero power. The car was towed to Hyundai dealership on 2/15/23 and I have yet to have the vehicle repaired. Hyundai keeps informing me that the part is on order and delayed. I have been waiting a long time for a defective vehicle.
NHTSA ODI #11527874
Mileage unknown · Jun 19, 2023
Electrical SystemEnginePower Train
Car literally DIED while driving. Went from normal speed to 12mph to 6mph to dead. ICCU failure.
NHTSA ODI #11527794
Mileage unknown · Jun 19, 2023
Electrical SystemForward Collision Avoidance
- EV Fuse blown My Hyundai Ioniq5 EV electrical system stopped function on March 25th, 9 month after we purchased this EV, on a busy highway. It took Hyundai dealer 8 weeks to fix this issue. Due to the fix report, some fuse was blown. - Automatic Emergency Braking engaged On Jun 16th, when driving on HW 90 west bound, road w…
Read full complaint
- EV Fuse blown My Hyundai Ioniq5 EV electrical system stopped function on March 25th, 9 month after we purchased this EV, on a busy highway. It took Hyundai dealer 8 weeks to fix this issue. Due to the fix report, some fuse was blown. - Automatic Emergency Braking engaged On Jun 16th, when driving on HW 90 west bound, road was clean. No vehicle in front of me. The "Automatic Emergency Braking " was engaged. This could be very dangerous if the highway was busy.
NHTSA ODI #11527771
Mileage unknown · Jun 19, 2023
Electrical SystemFuel/propulsion SystemService Brakes
This is an electric vehicle that features “iPedal” driving, what Hyundai refers to as one-pedal driving. The main safety issue is that when you decelerate using one pedal, which is a fairly aggressive deceleration, the brake lights do not come on unless you lift your foot entirely from the accelerator or apply the brake pedal (w…
Read full complaint
This is an electric vehicle that features “iPedal” driving, what Hyundai refers to as one-pedal driving. The main safety issue is that when you decelerate using one pedal, which is a fairly aggressive deceleration, the brake lights do not come on unless you lift your foot entirely from the accelerator or apply the brake pedal (which one would rarely do in iPedal mode). Hyundai needs to rethink their concept of operations for how their brake lights should operate. People are at risk of getting rear-ended. I didn’t realize this was how the vehicle operated until I was almost rear-ended today. Please push them to fix this issue.
NHTSA ODI #11527751
Mileage unknown · Jun 19, 2023
Electrical SystemPower Train
Failed EV drive system. Error messages of electrical problems and shortly went complete dead. 12 volt battery was dead and won't charge. Car was towed to Ideal Hyundai in Fredrick MD. Dealer reported failed ICCU and parts for repair are on back order. Fortunately the failure occurred when pulling away from parking. If I had been…
Read full complaint
Failed EV drive system. Error messages of electrical problems and shortly went complete dead. 12 volt battery was dead and won't charge. Car was towed to Ideal Hyundai in Fredrick MD. Dealer reported failed ICCU and parts for repair are on back order. Fortunately the failure occurred when pulling away from parking. If I had been at highway speed it could have been disastrous.
NHTSA ODI #11527747
Mileage unknown · Jun 19, 2023
Electrical SystemFuel/propulsion System
I received a warning on my dashboard while driving "Check electric vehicle system". A few minutes later I received the message "Stop vehicle and check power supply". My car would not go faster than 20 MPH, and I had it towed to the dealership. They said it was an ICCU issue and the part was on nationwide backorder. My car ha…
Read full complaint
I received a warning on my dashboard while driving "Check electric vehicle system". A few minutes later I received the message "Stop vehicle and check power supply". My car would not go faster than 20 MPH, and I had it towed to the dealership. They said it was an ICCU issue and the part was on nationwide backorder. My car has been at the dealership for 41 days.
NHTSA ODI #11527692
Mileage unknown · Jun 19, 2023
Electrical SystemFuel/propulsion System
On 24 May 2023, I heard a "pop" sound when starting my Ioniq5 and immediately received warnings directing me to stop the vehicle and check the battery system. The car was taken to the dealer on the same day and is still out of service. The dealer notified me that the problem is due to an "ICCU" issue and that parts are backorder…
Read full complaint
On 24 May 2023, I heard a "pop" sound when starting my Ioniq5 and immediately received warnings directing me to stop the vehicle and check the battery system. The car was taken to the dealer on the same day and is still out of service. The dealer notified me that the problem is due to an "ICCU" issue and that parts are backordered and they do not have an estimated date for the receipt of parts or repair.
NHTSA ODI #11527664
Mileage unknown · Jun 17, 2023
Electrical SystemEnginePower Train
Called an ICCU failure. It's the control unit that charges the 12V battery from the high voltage battery. The unit fails blowing the high voltage fuse. Failure of this component causes the vehicle to all but shut down, even while driving. This is known by Hyundai. Others have said this happens at about 12 months and 10,000 miles…
Read full complaint
Called an ICCU failure. It's the control unit that charges the 12V battery from the high voltage battery. The unit fails blowing the high voltage fuse. Failure of this component causes the vehicle to all but shut down, even while driving. This is known by Hyundai. Others have said this happens at about 12 months and 10,000 miles. My car was 53/54weeks old and had 9,300 miles. This failure of this part may have also caused my AC to stop working. As pressure sensor on the 12V system that was working before the component failed was not working when I received the car back, resulting in another lengthy repair. I had about 0.7 miles warning, a yellow check EV system lit up, then the whole dash lit up saying to pull over immediately. The ICCU was replaced by Hyundai with the "2023 spec" version.
NHTSA ODI #11527547
Official recalls
3Nov 18, 2024
Hyundai Motor America (Hyundai) is recalling certain 2022-2024 IONIQ 5, 2023-2025 IONIQ 6, Genesis GV60, Genesis GV70 "Electrified," and Genesis G80 "Electrified" vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-volt battery, which can result in a loss of drive power.
Consequence & remedy
Consequence: A loss of drive power increases the risk of a crash.
Remedy: Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed December 20, 2024. Owners may contact Hyundai customer service at 1-855-371-9460 or Genesis customer service at 1-844-340-9741. Hyundai's numbers for this recall are 272 (Hyundai) and 025G (Genesis). This recall expands and replaces previous recall number 24V-204. Vehicles previously repaired under recall 24V-204 will need to have the new remedy completed.
Additional source detail variants (2)
Electrical System:propulsion System:charging:module:software
Hyundai Motor America (Hyundai) is recalling certain 2022-2024 IONIQ 5, 2023-2025 IONIQ 6, Genesis GV60, Genesis GV70 "Electrified," and Genesis G80 "Electrified" vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-volt battery, which can result in a loss of drive power.
Consequence: A loss of drive power increases the risk of a crash.
Remedy: Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed December 20, 2024. Owners may contact Hyundai customer service at 1-855-371-9460 or Genesis customer service at 1-844-340-9741. Hyundai's numbers for this recall are 272 (Hyundai) and 025G (Genesis). This recall expands and replaces previous recall number 24V-204. Vehicles previously repaired under recall 24V-204 will need to have the new remedy completed.
Electrical SYSTEM:12V/24V/48V Battery
Hyundai Motor America (Hyundai) is recalling certain 2022-2024 IONIQ 5, 2023-2025 IONIQ 6, Genesis GV60, Genesis GV70 "Electrified," and Genesis G80 "Electrified" vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-volt battery, which can result in a loss of drive power.
Consequence: A loss of drive power increases the risk of a crash.
Remedy: Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed December 20, 2024. Owners may contact Hyundai customer service at 1-855-371-9460 or Genesis customer service at 1-844-340-9741. Hyundai's numbers for this recall are 272 (Hyundai) and 025G (Genesis). This recall expands and replaces previous recall number 24V-204. Vehicles previously repaired under recall 24V-204 will need to have the new remedy completed.
Mar 15, 2024
Hyundai Motor America (Hyundai) is recalling certain 2022-2024 IONIQ 5, 2023-2024 IONIQ 6, Genesis GV60, Genesis GV70 "Electrified," and Genesis G80 "Electrified" vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-Volt battery, which can result in a loss of drive power.
Consequence & remedy
Consequence: A loss of drive power increases the risk of a crash.
Remedy: This recall is replaced by NHTSA recall number 24V-868. Vehicles already repaired under this recall will need to have the new remedy completed. Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed April 22, 2024. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 257/021G.
Additional source detail variants (2)
Electrical SYSTEM:12V/24V/48V Battery
Hyundai Motor America (Hyundai) is recalling certain 2022-2024 IONIQ 5, 2023-2024 IONIQ 6, Genesis GV60, Genesis GV70 "Electrified," and Genesis G80 "Electrified" vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-Volt battery, which can result in a loss of drive power.
Consequence: A loss of drive power increases the risk of a crash.
Remedy: This recall is replaced by NHTSA recall number 24V-868. Vehicles already repaired under this recall will need to have the new remedy completed. Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed April 22, 2024. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 257/021G.
Electrical System:propulsion System:charging:module:software
Hyundai Motor America (Hyundai) is recalling certain 2022-2024 IONIQ 5, 2023-2024 IONIQ 6, Genesis GV60, Genesis GV70 "Electrified," and Genesis G80 "Electrified" vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-Volt battery, which can result in a loss of drive power.
Consequence: A loss of drive power increases the risk of a crash.
Remedy: This recall is replaced by NHTSA recall number 24V-868. Vehicles already repaired under this recall will need to have the new remedy completed. Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed April 22, 2024. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 257/021G.
May 11, 2022
Hyundai Motor America (Hyundai) is recalling certain 2022 Ioniq 5 vehicles. A software error in the Shifter Control Unit (SCU) may disengage the parking mechanism, which can allow the vehicle to rollaway.
Consequence & remedy
Consequence: Vehicle rollaway can increase the risk of a crash or injury.
Remedy: Drivers are recommended to use the Electronic Parking Brake (EPB) when parking their vehicles until the remedy has been performed. Dealers will update the Shifter Control Unit software, free of charge. Owner notification letters were mailed July 14, 2022. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 228.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE24028 · Electrical Arcing And Thermal Events, Potentially Leading To Fires, While Utilizing Enel X Way Usa, Llc's Juicebox Residential Charger.
Opened Oct 3, 2024 · Closed Jun 5, 2025
Status: closed (inferred from source dates) · Equipment:electrical
On October 3, 2024, the Office of Defects Investigations (ODI) opened PE24028 to investigate alleged failures of Enel X Way's JuiceBox Level 2 residential EV chargers. The allegations were described as thermal incidents and electrical malfunctions, which could trip the circuit breakers in Juicebox owners’ homes and disrupt electric vehicle charge cycles. On October 2, 2024, Enel X Way posted on its website that Enel X Way North America would cease operations in the United States and Canada on October 11, 2024. The closure would potentially impact the charging app and supporting software. ODI sent Enel X Way an Information Request (IR) letter on October 21, 2024. Enel X Way provided an incomplete response to the IR on December 9, 2024. Enel X Way later provided a complete response to the IR on January 24, 2025. ODI reviewed Enel X Way’s IR submissions to determine whether further action is required. Based on ODI’s analysis, there was no clear trend in the cause of the failures described in customer complaints and warranty reports. Additionally, there have been no recent reports alleging safety issues. The available information does not warrant further action at this time. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency will continue to monitor for any safety trends and reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in this Closing Resume, go to NHTSA.gov.
PE23011 · Loss Of Motive Power
Opened Jun 8, 2023 · Closed Apr 17, 2024
Status: closed (inferred from source dates) · Electrical SYSTEM:12V/24V/48V Battery; Electrical System:propulsion System:dc/dc Converter
On June 8, 2023, the Office of Defect Investigation (ODI) opened PE23011 to investigate allegations of loss of motor power on model year (MY) 2022 Hyundai Ioniq 5 vehicles. Some consumers reported loss of motor power immediately after a warning lamp illumination or reduction of motive power while the vehicle was in motion. This investigation found that the Integrated Charging Control Unit (ICCU) may be subject to various conditions such as overcurrent, overvoltage induced at the end of charging, and certain thermal loading during operation that can damage its internal components and open the ICCU fuse, resulting in an inability to charge the 12-volt battery. The vehicle could eventually lose all motive power, increasing the risk of a crash. In July 2023, Hyundai issued a service campaign to address certain MY 2022-2023 Ioniq 5 and MY 2023 Ioniq 6 vehicles that may have low 12V auxiliary battery charging occurrences due to an ICCU fault and may set the DTC P1A9096 “DC/DC Converter Input Voltage Sensor Fault”. On March 15, 2024, Hyundai filed Safety Recall 24V-204 for 98,878 MY 2022-2024 Hyundai Ioniq 5 vehicles and MY 2023-2024 Hyundai Ioniq 6, Genesis GV60, Genesis GV70 “Electrified” and Genesis G80 “Electrified” vehicles. The recall remedy provides an inspection, and if necessary, a replacement of the ICCU and the associated fuse. The ICCU software reduces the risk of overcurrent and implements voltage peak reduction at the end of EV battery charging. The recall also includes a software update that revises the electric water pump operational threshold to reduce thermal loading during charging and driving. In view of the recall action being taken by Hyundai, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Electrical SYSTEM:12V/24V/48V Battery
On June 8, 2023, the Office of Defect Investigation (ODI) opened PE23011 to investigate allegations of loss of motor power on model year (MY) 2022 Hyundai Ioniq 5 vehicles. Some consumers reported loss of motor power immediately after a warning lamp illumination or reduction of motive power while the vehicle was in motion. This investigation found that the Integrated Charging Control Unit (ICCU) may be subject to various conditions such as overcurrent, overvoltage induced at the end of charging, and certain thermal loading during operation that can damage its internal components and open the ICCU fuse, resulting in an inability to charge the 12-volt battery. The vehicle could eventually lose all motive power, increasing the risk of a crash. In July 2023, Hyundai issued a service campaign to address certain MY 2022-2023 Ioniq 5 and MY 2023 Ioniq 6 vehicles that may have low 12V auxiliary battery charging occurrences due to an ICCU fault and may set the DTC P1A9096 “DC/DC Converter Input Voltage Sensor Fault”. On March 15, 2024, Hyundai filed Safety Recall 24V-204 for 98,878 MY 2022-2024 Hyundai Ioniq 5 vehicles and MY 2023-2024 Hyundai Ioniq 6, Genesis GV60, Genesis GV70 “Electrified” and Genesis G80 “Electrified” vehicles. The recall remedy provides an inspection, and if necessary, a replacement of the ICCU and the associated fuse. The ICCU software reduces the risk of overcurrent and implements voltage peak reduction at the end of EV battery charging. The recall also includes a software update that revises the electric water pump operational threshold to reduce thermal loading during charging and driving. In view of the recall action being taken by Hyundai, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Electrical System:propulsion System:dc/dc Converter
On June 8, 2023, the Office of Defect Investigation (ODI) opened PE23011 to investigate allegations of loss of motor power on model year (MY) 2022 Hyundai Ioniq 5 vehicles. Some consumers reported loss of motor power immediately after a warning lamp illumination or reduction of motive power while the vehicle was in motion. This investigation found that the Integrated Charging Control Unit (ICCU) may be subject to various conditions such as overcurrent, overvoltage induced at the end of charging, and certain thermal loading during operation that can damage its internal components and open the ICCU fuse, resulting in an inability to charge the 12-volt battery. The vehicle could eventually lose all motive power, increasing the risk of a crash. In July 2023, Hyundai issued a service campaign to address certain MY 2022-2023 Ioniq 5 and MY 2023 Ioniq 6 vehicles that may have low 12V auxiliary battery charging occurrences due to an ICCU fault and may set the DTC P1A9096 “DC/DC Converter Input Voltage Sensor Fault”. On March 15, 2024, Hyundai filed Safety Recall 24V-204 for 98,878 MY 2022-2024 Hyundai Ioniq 5 vehicles and MY 2023-2024 Hyundai Ioniq 6, Genesis GV60, Genesis GV70 “Electrified” and Genesis G80 “Electrified” vehicles. The recall remedy provides an inspection, and if necessary, a replacement of the ICCU and the associated fuse. The ICCU software reduces the risk of overcurrent and implements voltage peak reduction at the end of EV battery charging. The recall also includes a software update that revises the electric water pump operational threshold to reduce thermal loading during charging and driving. In view of the recall action being taken by Hyundai, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
Illustration