Hyundai Elantra electrical problems

The contact owns a 2012 Hyundai Elantra. The contact stated that while driving at an undisclosed speed, the instrument panel became inoperable and failed to operate as needed. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and a complaint was filed. The failure mileage was approximately 66,000.

The headlights still cannot be used on high beam as the lights strobe when used. This was complaint was previously submitted with the same Vin#. This is dangerous for driver and others, including oncoming traffic. The local Hyundai dealer said it is would be $200+ for them to diagnostic and if they fixed it, the diagnostic fee would be credited toward the repair. How can this not be coved under a recall when it is clearly a safety issue and many mentions on line with others having the same problem? The vin.# says there are no open recalls. How can I get this covered on my car that is the same model and year as others with the same problem. I see a couple service bulletin's and would like to know if any apply. Please respond with any help or suggestions on this matter as I need help from the NHTSA to get Hyundai to fix it. I am happy to send a video for proof. I look forward to your reply. Thank you very much!

While driving, pressing the accelerator pedal, the vehicle hesitated and stalled. No warning lights came on until after I attempted to turn the vehicle back on then the check engine light and low oil light were illuminated. My vehicle was towed to a local mechanic and I was informed that the engine was blown and to tow my car to a Hyundai dealership as I was still under the 10 year/100k mile warranty. After getting my car to Hyundai, I was told I had to get a combustion cleaning for $800 whether the cleaning worked or not before any warranty work could be completed. The cleaning did not work and it was then found that a pin was sheared off inside the engine. My engine was then replaced under warranty but I still had to pay for the cleaning. A second mechanic looked over my paperwork after getting my car back 2 months later and noted that the engine failure could have been diagnosed without the cleaning as the cleaning would not have affected where the pin was sheared off. My 2017 Elantra had 90,315 at the time of this incident.

No accident has occurred as of yet (for my case). Ongoing issues with Hyundai left brake bulb and center brake bulb burning out due to over-amperage. These two are on their own 10A circuit separate from the 5A circuit for the right brakelight bulb. It appears that these two bulbs are possibly receiving 15A and therefore burning out prematurely (3 months or less). I recently replaced these two bulbs at the same time, and now my battery is shorted. To keep my battery charged, I need to pull my 15A Brake Lamp fuse while the car is parked. This has now caused my ABS light to come on, as that system relies on the signal from the 15A brake lamp circuit. I suspect that some 15A components (10A+5A) received 20A (15A+5A) and welded shut. I am still looking for it to trace it down, resources are limited and I'm intent on just buying the $35 diagnostics book. Hyundai dealership did not inform me that this fuse was pulled while I drove home from the shop yesterday, creating an unsafe condition. They quoted me $500 to replace a brake lamp relay and the ABS (I'm assuming the whole ABS, but maybe just the control module), I declined. My plan for now, as this car isn't driven much, is to trace it down and find the shorted component. From my research, this is clearly affecting many years of Hyundais and Kias, not just my Elantra and not just my year. In fact, it's SO common that there are facebook groups (such as this one [XXX] ) dedicated to helping owners remedy this defect. I think a recall service, and a full investigation of what is electrically wrong with these cars, and what the actual remedy should be, is necessary based on the amount of cars that could be impacted. Hyundai & Kia technicians I am SURE are intimately knowledgeable about this issue by now and us owners are on the hook, having only 80,000 miles of warranty on anything purchased used. Please reach out with any add'l questions. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Vehicle: 2022 Hyundai N Line Mileage at Initial Incident: ~17,000 miles Components Involved: Engine and Engine Cooling; Exhaust System / Emissions; Air Bags (SRS) I am submitting this complaint to document unresolved emissions system and Supplemental Restraint System (SRS) safety concerns involving my 2022 Hyundai N Line, as well as the manufacturer’s refusal to ensure proper diagnosis and corrective action following a documented dealer service error and subsequent warranty repair. At approximately 17,000 miles, a Hyundai-authorized dealership failed to reinstall an engine oil seal during a routine oil change. This error caused rapid engine oil loss at highway speed, activation of the oil warning system, and oil discharge onto the roadway. The incident is documented in Hyundai service records and is not disputed. Sudden oil-loss events of this nature are known to cause latent or progressive damage to internal engine components and federally regulated emissions systems, even when immediate engine failure does not occur. Despite proper maintenance after this incident, the vehicle subsequently set DTC P0420 (Catalyst System Efficiency Below Threshold – Bank 1) at a mileage far below expected durability. Hyundai replaced the catalytic converter under warranty. I requested diagnostic data, inspection findings, and documentation supporting the repair, but the dealership refused to provide anything beyond a basic repair invoice. Immediately following this Hyundai-authorized warranty repair, the vehicle developed a new drivability defect, specifically hesitation during acceleration, which was not present prior to the catalytic converter replacement. This indicates a post-repair nonconformity and raises concern that emissions-related components may not have been fully repaired or that additional systems were affected during the warranty repair process. When I returned the vehicle for evaluation, the dealership stated that it would not diagnose the vehicle unless an acti

to whoever it is that can help, I am reaching out to submit a formal complaint regarding my 2017 Hyundai Elantra due to ongoing mechanical and structural issues that began very shortly after I purchased the vehicle, which have progressively worsened. I made the purchase in January 2024 for approximately $13,000 with 60,000 miles. The vehicle now currently has approximately 108,000 miles. Since purchasing the car, I have experienced consistent time consuming and serious issues that I believe indicate defects in manufacturing or design. First, the thermostat had failed during the first winter season I owned the Elantra, despite replacement the vehicle’s heating system still does not function properly. I’m not a fan of the cold. Also, the engine burns oil at an extreme rate. I am required to add oil literally every 2–3 days to prevent the engine from running dry, which presents a serious risk of engine failure and potential safety hazards while driving. And is also costly as oil is not cheap. In addition, the vehicle’s headlights developed spiderweb pattern cracking and shattered from the inside after approximately nine months of use, without any external damage. The paint has chipped across the vehicle, including in door jambs and other protected areas, suggesting poor paint quality. And recently, the lower engine underbody cover has completely broken down and disintegrated over time due to clips constantly falling out. Given the age of the vehicle and the normal use, the amount and severity of these issues are unacceptable. These defects have caused significant financial burden and raise serious concerns on vehicle safety and manufacturing quality. I am requesting that this complaint be reviewed for potential defects or recalls. I would also like Hyundai to be held accountable, either through compensation for the repairs required or replacement. Thank you for your time and attention to this matter. Sincerely, Owner of the 2017 Hyundai Elantra

The EPS light started coming on intermittently back in Nov. 2025 and power steering became very difficult. I could get it to reset by turning off the car and turning steering wheel all the way to right and then left and then back to center and restart. The steering ability returned but the light eventually came back on. I had Firestone look at this in Nov. and they recalibrated but advised if problem returned that I should contact dealer due to recall for 2010 Elantras for same issue. The light came back on this weekend. I note the recall is for Elantras manufactured through April 30, 2010. My car was manufactured June 20, 2010…. 6 weeks after the dates of the recalled models. Clearly this issue is affecting my car also. I plan to call the dealer and try to get them to look at it and see if they will repair under the recall… but I wanted to report this to you also since is affecting models outside the original recall dates.

What component or system failed or malfunctioned, and is it available for inspection upon request? The car began stalling and started to become unresponsive while I was driving to work. While I was not 100% sure of what component was malfunctioning at the time, I suspected that it might be a timing chain problem because I had this same exact issue happen to to this car back in January 2025. I did not expect this issue to occur again because at the time of the previous problem, the dealership confirmed that issue was the timing chain and the VVT system, and replaced those components with new parts. How was your safety or the safety of others put at risk? The car started stalling and sputtering, then became unresponsive while I was driving. If I were in a high-traffic area, I'm not confident that I would have been able to accelerate, stop, or safely pull over to the side of the road without putting myself and/or someone else in harms way. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes, the car is currently at the dealership and they confirmed that the issue is the timing chain and the VVT system. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Yes, the car is currently at the dealership and they confirmed that the issue is the timing chain and the VVT system. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No, there were absolutely no warning lights, messages, or symptoms prior to the failure.