July 3rd - car was serviced at Humble Hyundai for engine recall July 8th- received email of recommended services needed for vehicle (only thing regarding engine were spark plug replacement) July 26th - car stalled while at red light July 27th - car was brought to Humble Hyundai for further diagnosis Aug 2nd - update regardin…
Read full complaint
July 3rd - car was serviced at Humble Hyundai for engine recall July 8th- received email of recommended services needed for vehicle (only thing regarding engine were spark plug replacement) July 26th - car stalled while at red light July 27th - car was brought to Humble Hyundai for further diagnosis Aug 2nd - update regarding engine, cylinder 3 was not receiving enough pressure/low pressure Aug 7th- no longer covered under warranty, car is not operative, need to purchase new vehicle
NHTSA ODI #11537075
Mileage unknown · Jun 24, 2023
EnginePower Train
When stopped at a red light or in traffic, (on many occasions), my car will suddenly surge and accelerate. It's leads no many near rear end collisions. Sometimes it leads up to my engine stalling. Also have shuddering (like it wants to die) when driving on freeway. The re has been to many incidents to keep track of.
NHTSA ODI #11528672
72,561 miles · Jun 16, 2023
Engine
The contact owns a 2015 Hyundai Elantra. The contact stated while driving approximately 65 MPH, the vehicle started to shudder and lost motive power before the vehicle stalled. The contact stated that the vehicle also lost power steering functionality and stopped in the right lane on the highway. The contact stated that she rest…
Read full complaint
The contact owns a 2015 Hyundai Elantra. The contact stated while driving approximately 65 MPH, the vehicle started to shudder and lost motive power before the vehicle stalled. The contact stated that the vehicle also lost power steering functionality and stopped in the right lane on the highway. The contact stated that she restarted the vehicle and was able to exit the highway. The contact stated that the vehicle stalled repeatedly while driving to the residence. The contact stated that while driving to an independent mechanic, the vehicle stalled. The vehicle was not diagnosed or repaired. The manufacturer had not been informed of the failure. The failure mileage was 72,561.
NHTSA ODI #11527370
Mileage unknown · Jun 12, 2023
Engine
The car engine seized on me. Went to work in the am and by the afternoon the car was non drivable. Had it tolled to a Hyundai dealership and couple of other car repair shops and they all confirmed that the engine has died. I haven't even had the car for a year. There was no indicators on the screen or any kind of warning such as…
Read full complaint
The car engine seized on me. Went to work in the am and by the afternoon the car was non drivable. Had it tolled to a Hyundai dealership and couple of other car repair shops and they all confirmed that the engine has died. I haven't even had the car for a year. There was no indicators on the screen or any kind of warning such as an engine light. Good thing the car was in park when before it seized, otherwise I could have been driving it and could have happened on the road.
NHTSA ODI #11526538
Mileage unknown · Jun 12, 2023
Engine
Complete engine failure at 129k miles, 3k miles after purchasing used off Hyundai car dealerships.
NHTSA ODI #11526486
Mileage unknown · Apr 21, 2023
Engine
Engine stalled while going at-speed on major highway; high risk of crash if not restarted in time. Continuous repeating stalls. Hyundai inspected car twice; failed to fix the problem on the first attempt, refused to replace engine alleging that maintenance was negligent due to residue inside motor. Hyundai did not report any res…
Read full complaint
Engine stalled while going at-speed on major highway; high risk of crash if not restarted in time. Continuous repeating stalls. Hyundai inspected car twice; failed to fix the problem on the first attempt, refused to replace engine alleging that maintenance was negligent due to residue inside motor. Hyundai did not report any residue on the first inspection, and likely did not inspect engine thoroughly when stalling was initially reported to their mechanics. Odd noises from engine present for months prior to stalling.
NHTSA ODI #11518242
Mileage unknown · Apr 9, 2023
EngineUnknown Or OtherVehicle Speed Control
Unwanted sudden engine speeding up,No warning or messages.
NHTSA ODI #11516207
Mileage unknown · Mar 23, 2023
EnginePower Train
Transmission completely went out at 86k miles with no warning. No lights on the dash, no slow build of issues. Has always had regular maintenance since I bought the car at the dealership. Second owner, and car is paid off. Drove it one day with absolutely no issues, and the very next day, all gears were slipping and was not saf…
Read full complaint
Transmission completely went out at 86k miles with no warning. No lights on the dash, no slow build of issues. Has always had regular maintenance since I bought the car at the dealership. Second owner, and car is paid off. Drove it one day with absolutely no issues, and the very next day, all gears were slipping and was not safely drivable. Was stopped at a stop light turning into work and when I put my foot on the accelerator, it went nowhere and I was stuck at intersection. Got it towed that day to a local repair shop since I was told my warranty for power train was expired, and have been waiting on a new transmission for 2 months now. The repair shop still doesn’t know when they’ll get it in, and will cost $4k to install. Mine is one of many they’ve said have come through with the same problem.
NHTSA ODI #11513340
Mileage unknown · Feb 16, 2023
Engine
The engine failed under with under 100,000 miles on the car. It dies going under 20 miles per hour. This is a safety issue because it will die anywhere and can cause wrecks due to sudden failure. The vehicle was inspected Stivers Hyundai, and they could not determine what caused the failure. The problem was confirmed with the sa…
Read full complaint
The engine failed under with under 100,000 miles on the car. It dies going under 20 miles per hour. This is a safety issue because it will die anywhere and can cause wrecks due to sudden failure. The vehicle was inspected Stivers Hyundai, and they could not determine what caused the failure. The problem was confirmed with the same dealer. There were no warning lamps or signs prior to the failure. Beneath, I am reporting the issue on the date it first occurred, though it has occurred multiple times since.
NHTSA ODI #11507598
Mileage unknown · Feb 3, 2023
Engine
My vehicle is just over 80k miles and has received regular maintenance services. Inspection available upon request. My engine would rattle during idle, stopped at a light, and sounded as if the RPM were increasing. I would have to turn my car off then back on for it to stop. No engine or warning lights. As this became more frequ…
Read full complaint
My vehicle is just over 80k miles and has received regular maintenance services. Inspection available upon request. My engine would rattle during idle, stopped at a light, and sounded as if the RPM were increasing. I would have to turn my car off then back on for it to stop. No engine or warning lights. As this became more frequent, I also noticed a very intense shaking coming from the front passenger side of the vehicle while driving on the highway. The shaking was most intense as the car accelerated from 2k-3k RPM. It felt like I could have lost control. On 11/29/22, my car was towed to a repair shop because the engine would stall when I started my car. After examination they recommended I take it to a Hyundai dealer, determined the engine may need replaced and informed me of other recalls from similar models. When the vehicle was brought to the Hyundai dealer, they stated they could not replicate the issue - the engine would start without stalling - but they also speculated my problem was from a loose cable, and attempted to send my car home with me the same day. It is important to note that the battery cable was examined and was connected prior to bringing it in to the dealer. My car is not under recall so my request was taken lightly, they stated I had no engine issues. I pressed for them to address the rattling of my vehicle, for which they then told me I had a leak in my front left axle. Axle was repaired and car brought home. My car drove for about 212 miles before it started stalling again with multiple attempts to start it. When I was able to successfully turn the engine over, I drove it back to the Hyundai dealer on 1/02/23. They found no codes but determined the crank sensor needed replaced. After replacement, they informed me my vehicle still “acted up” once, so they have held onto the vehicle for the past month, letting it sit and occasionally test driving it. Still no answer to this irregular issue.
Hyundai Motor America (Hyundai) is recalling certain 2015-2016 Elantra and 2016 Elantra GT vehicles. The driver's air bag inflator may rupture during deployment.
Consequence & remedy
Consequence: An air bag inflator that ruptures may result in sharp metal fragments striking the driver or passengers, increasing the risk of injury or death.
Remedy: Dealers will inspect and replace the air bag inflator, as necessary, free of charge. Interim notification letters, notifying owners of the safety risk, were mailed July 3, 2026. Additional letters will be sent once the final remedy is available, anticipated August, 2026. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 300. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on May 16, 2026.
Hyundai Motor America (Hyundai) is recalling certain 2015-2016 Elantra vehicles. The trunk latch may become damaged, preventing the opening of the trunk from the inside. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 401, "Internal Trunk Release."
Consequence & remedy
Consequence: A person inside the trunk compartment may become trapped, increasing their risk of injury.
Remedy: Dealers will replace the trunk latch base sub-assembly, free of charge. Owner notification letters were mailed April 5, 2024. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 256.
Hyundai Motor America (Hyundai) is recalling certain 2011-2015 Elantra, Genesis Coupe, Sonata Hybrid, 2012-2015 Accent, Azera, Veloster, 2013-2015 Elantra Coupe, Santa Fe, 2014-2015 Equus, 2010-2012 Veracruz, 2010-2013 Tucson, 2015 Tucson Fuel Cell, and 2013 Santa Fe Sport vehicles. The Anti-Lock Brake System (ABS) module may leak brake fluid internally and cause an electrical short, which can result in an engine compartment fire while parked or driving.
Consequence & remedy
Consequence: An engine compartment fire while parked or driving can increase the risk of injury.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the ABS fuse, free of charge. Owner notification letters were mailed April 10, 2024 through October 11, 2024. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 251.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
AQ23002 · Hyundai And Kia Abs Module Fires
Opened Nov 17, 2023 · No close date supplied
Status: open (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
The Office of Defects Investigation (ODI) has received eight Hyundai Motor America (Hyundai) and eight Kia America, Inc. (Kia) Part 573 Recall Reports between 2016 and 2023. The combined 16 safety recalls all involve the antilock braking system (ABS) modules or Hydraulic Electronic Control Units (HECU) manufactured by the equipment supplier Mando. The Part 573 Recall Reports contain varying defect descriptions and differing remedy descriptions for the same or similar equipment supplied by Mando. Safety recalls included in this Audit Query (AQ) review include: Hyundai recalls 20V-520, 20V-543, 21V-161, 21V-160, 21V-303, 22V-056, 22V-810, and 23V-651. Kia recalls 16V-815, 20V-518, 20V-519, 21V-137, 21V-331, 22V-051, 22V-800, and 23V-652 The purpose of this AQ is to evaluate the timeliness and scoping of Hyundai and Kia’s defect decision making and adherence with reporting requirements; and understand the varying defect descriptions and remedies between these recalls.
DP21003 · Throttle Control System Vulnerabilities
Opened Nov 12, 2021 · Closed Jun 20, 2023
Status: closed (inferred from source dates) · Vehicle Speed Control:throttle
The Office of Defects Investigation (ODI) of the National Highway Traffic Safety Administration (NHTSA) received a petition letter dated October 10, 2021, requesting an investigation of possible defects in the electronic throttle control (ETC) system on certain Kia vehicles resulting in the opening of DP21-003. Accordingly, Model Year (MY) 2005-2016 Kia Optima/K5, MY 2006-2015 Kia Sorento, MY 2007-2016 Hyundai Elantra, MY 2007-2016 Hyundai Santa Fe, MY 2006-2015 Hyundai Sonatas are all part of the subject population. The petition was originally filed as a Vehicle Owner Questionnaire that can be reviewed at NHTSA.gov under reference (ODI) number 11439675.On November 12, 2021, ODI opened Defect Petition DP21-003 to evaluate the petitioner?s request. ODI performed trend analyses of the VOQs related to vehicle speed control issues for all the subject vehicles and found that none of the 52 Model/Model Year Hyundai/Kia vehicles demonstrated any actionable trend that warranted an investigation.Petitioners submitted 1119 VOQs and non-VOQ cases in which sudden uncommanded acceleration (SUA) or loss of motive power (LOMP) incidents were alleged.For the 1119 reports, 220 were incidents involving crashes, from which 69 subject Hyundai-Kia vehicles were inspected by Hyundai/Kia dealer technicians, Hyundai/Kia engineers, and/or third-party representatives.ODI found the inspections identified no vehicle defects related to the ETC system.Of the 220 crash-involved reports, 13 Event Data Recorder (EDR) records were downloaded successfully and 11 of those indicated driver error: (i.e.) pedal misapplication.A condition where the accelerator pedal is mistakenly applied instead of the brake pedal when the driver wants to stop the vehicle.In addition, ODI reviewed a scientific journal paper published in Forensic Science International in 2016 by Mr. Park et al ., as well as related test videos. ODI does not believe there is any evidence of uncontrollable SUA occurrences in any of the tests reviewed. NHTSA's Office of Vehicle Safety Compliance (OVSC) reviewed the allegations regarding the potential noncompliance with Federal Motor Vehicle Safety Standard No. 124.Based on the information provided, the Agency concludes there is insufficient information for us to determine if a possible non-compliance exists.Finally, both Hyundai and Kia informed ODI that all their vehicles manufactured after 2012 were equipped with an ETC management system, in which the engine speed will go to idle when the system sees signals from both the brake pedal and accelerator pedal at the same time; this is commonly known as the brake-throttle override system.After thoroughly assessing the material submitted by the petitioner, information already in NHTSA's possession, information submitted by Hyundai and Kia in response to an Information Request letter, and the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that a formal investigation is warranted. After full consideration of appropriate factors, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA?s reasons for denial of the petition will be published.
Illustration