2000 Hyundai Elantra

The contact owns a 2000 Hyundai Elantra. The contact stated while driving at an unknown speed, there was an abnormal odor entering the cabin of the vehicle, causing the contact to be nauseated. The vehicle was taken to the dealer and the contact was informed that there was no cabin air filter installed in the vehicle. The cabin air filter was not replaced. The manufacturer was contacted and informed the contact that the vehicle was out of warranty. The failure mileage was 19,000.

AT 65 MPH, ON THE HIGHWAY, THE ENGINE STALLED, ALL LIGHTS ON THE INSTRUMENT PANEL CAME ON AND I WAS ABLE TO COAST TO A NEARBY OFF RAMP. FIVE WEEKS LATER, THE ENGINE WILL START, AND THE ONL YLIGHT ON THE INSTRUMENT PANEL IS THE AIR BAG LIGHT WHICH HAS NEVER GONE OFF SINCE THE STALLING EPISODE. THE CHECK ENGINE LIGHT HAS COME ON FOR A YEAR, WITH THE SAME MULTIPLE MISFIRE READINGS (300 AND 301). I HAVE HAD MECHANICS MAKE ALMOST EVERY POSSIBLE REPLACEMENT IN THE LAST 12 MONTHS. ASPARK PLUGS AND WIRES WERE REPLACED TWICE IN A FOUR MONTH PERIOD WITH AN UNKNOWN FACTOR BURNING THEM OUT. THERE ARE NUMEROUS ACCOUNTS OF BOTH OF THESE PROBLEMS REPORTED ON RELIABLE INTERNET SITES, ESPECIALLY THE ENGINE STALLING WHICH IS ESPECIALLY DANGEROUS. THIS VEHICLE IS REPORTED TO HAVE HAD BOTH RECALL REPAIRS COMPLETED IN 2005. WITH THOUSANDS OF NEWER ELANTRA MODELS REPORTING THE INTERMITTENT ENGINE STALLING, HYUNDAI SHOULD BE REQUIRED TO THOROUGHLY INVESTIGATE AND ISSUE A RECALL. NOTE: I AM UNABLE TO CHECK THE FUEL/PROPULSION SYSTEM IN THE LIST ABOVE. PERHAPS ONLY THREE ITEMS CAN BE CHECKED, I BELIEVE THE PROBLEM WITH ELANTRAS IS ALSO TIED TO THIS SYSTEM.

TL* THE CONTACT OWNS A 2000 HYUNDAI ELANTRA. WHILE DRIVING, THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE EVAC VALVE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE PERSISTED. THE CONTACT ALSO STATED THAT THE FRONT DRIVER SIDE AND THE REAR PASSENGER SIDE WINDOWS COULD NOT BE OPENED OR CLOSED AND THE FRONT PASSENGER SIDE DOOR WOULD NOT UNLOCK FROM OUTSIDE THE VEHICLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS 30,750.

MY WIFE PURCHASED A 2000 HYUNDAI ELANTRA VIN#[XXX] FROM BROWN HYUNDAI OF TOLEDO OH. ON 4/18/05 SHE BROUGHT THE CAR TO BROWN HYUNDAI AT 63,000 MILES DUE TO A NOTICE ABOUT POSSIBLE FOR CRACKS FORMING IN THE EXHAUST MANIFOLD, SPECIFICALLY TSB 05-01-001. NO REPLACEMENT WAS MADE AT THAT TIME. RECENTLY, I NOTICED AN EXISTING CRACK IN THE EXHAUST MANIFOLD AND PERFORMED SOME RESEARCH ON THE INTERNET ABOUT THE PROBLEM. I AM SURE YOU ARE AWARE HOW COMMON OF A PROBLEM THIS HAS BEEN AS THERE ARE NUMEROUS COMPLAINTS ON VARIOUS AUTOMOTIVE FORUMS, THE NHTSA, AND VARIOUS STATES' DEPARTMENT OF CONSUMER PROTECTION. I HAD THE VEHICLE RECENTLY (10/08/12) INSPECTED AT VOSS HYUNDAI OF CENTERVILLE OH WHO HAS CONFIRMED THE EXISTING CRACK. AT 125,000 MILES THE CAR IS PASSED ITS POWERTRAIN WARRANTY. SIMPLY BECAUSE IT WAS NOT VISIBLY EVIDENT IN 2005 DOES NOT MEAN THE MANIFOLD WAS UP TO HYUNDAI'S QUALITY STANDARDS. EXHAUST MANIFOLDS ARE CAST IRON OR STEEL AND ARE NOT A MOVING PART SUBJECT TO FRICTION. THEREFORE, I CANNOT ACCEPT THAT THIS CURRENT PROBLEM IS THE RESULT OF STANDARD OR EXPECTED WEAR-AND-TEAR BUT CAUSED BY A PRE-EXISTING DEFECT THAT HAS SURFACED OVER TIME. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR