NHTSA owner reports · September 18, 2026 snapshot.
Unknown Or Other complaints
33 reportsClear category filterMileage unknown · Nov 1, 2024
Electrical SystemUnknown Or Other
Drive side rear power door stopped working. Upon using handl to opperate as usual the door stopped only a few inches open. A gentle shove got it open and opperational. The next day it did the same thing this time refuding to eithe ropen completely or re-latch. My children were in the car with me on the way to school and the door…
Read full complaint
Drive side rear power door stopped working. Upon using handl to opperate as usual the door stopped only a few inches open. A gentle shove got it open and opperational. The next day it did the same thing this time refuding to eithe ropen completely or re-latch. My children were in the car with me on the way to school and the door could not be opened to let them out or closed to safely proceed on our route. We began diagnositcs and found that the door continued to be problematic; opening just enough to be unlatched but nor going further, opening only half way and locking in place, or openeing completely then refusing to close... the door being in manual mode or power mode makes no differnece. after complelty disasembling the door/panel to check calbles and motor, checking fuses etc we put it all back to gether and suddenly it worked fin for about a dozen tries. HOWEVER the passanger side rear door (perviously untouched) suddenly developed the same problem. Now both doors will not function in either power or manual mode and I am waiting on the dealership to look into possible computer issues.
NHTSA ODI #11623065
Mileage unknown · Oct 25, 2024
EngineFuel/propulsion SystemUnknown Or Other
After having the Honda Dealership perform an oil change and software update 23-008 (updating the Auto Idle Stop Software) last week, my engine stalled while at a busy intersection (PA turnpike/70 junction) during a road trip. At the long stop light the auto idle function engaged and the engine turned off. When the stop light tur…
Read full complaint
After having the Honda Dealership perform an oil change and software update 23-008 (updating the Auto Idle Stop Software) last week, my engine stalled while at a busy intersection (PA turnpike/70 junction) during a road trip. At the long stop light the auto idle function engaged and the engine turned off. When the stop light turned green and I lifted my foot off the brake and pressed the gas the engine shut down and automatically went into Park. I had to press the start/stop button to fully turn off then turn back on the car to get the engine to restart. This is with a giant semitruck honking right behind me. The auto idle feature does not work. It sounds terrible every time the engine restarts after it has been engaged. There really should be an option to allow users to permanently disable it, and not have to remember to turn it off every time they start the car--terrible user experience.
NHTSA ODI #11621957
Mileage unknown · Apr 30, 2024
Air BagsElectrical SystemUnknown Or Other
A recall has been issued on my vehicle since February. It is now almost May and when I call Honda about the recall they tell me that they do not have the solution as of yet.
NHTSA ODI #11586033
Mileage unknown · Apr 13, 2024
Back Over PreventionElectrical SystemUnknown Or Other
Team Honda in Merrillville refused to fix my recall unless I paid for diagnostics.
NHTSA ODI #11582755
Mileage unknown · Feb 15, 2024
Unknown Or Other
The 2021 Honda Odyssey with the VIN provided had 1) Auto Stop Idle Failure in June 2023 where the car would turn off completely at a stop (intersection, stop sign, etc.) and the car would have to me restarted. Sometimes restarting more than once. Honda replaced the car battery and conducted a software update. 2) About 7 months l…
Read full complaint
The 2021 Honda Odyssey with the VIN provided had 1) Auto Stop Idle Failure in June 2023 where the car would turn off completely at a stop (intersection, stop sign, etc.) and the car would have to me restarted. Sometimes restarting more than once. Honda replaced the car battery and conducted a software update. 2) About 7 months later in February 2024 the dashboard displayed two warnings A) Auto Engine Idle Stop System Problem and B) Charging System Problem. Honda had performed a second software update just prior to the second occurrence on 1/25/24. As of 2/15/24 Honda still has the car and is going to replace a battery sensor.
NHTSA ODI #11572191
Mileage unknown · Feb 3, 2024
Unknown Or OtherVisibility/wiper
Recall for driver side view mirror completed. However the replacement mirror is distorted and causes blurred, wavy, double images. This replacement mirror needs to be addressed as soon as possible since proper representation of objects is distorted and poses a high safety concern. This issue has been reported in several forums a…
Read full complaint
Recall for driver side view mirror completed. However the replacement mirror is distorted and causes blurred, wavy, double images. This replacement mirror needs to be addressed as soon as possible since proper representation of objects is distorted and poses a high safety concern. This issue has been reported in several forums as well.
NHTSA ODI #11569641
Mileage unknown · Jan 16, 2024
Unknown Or Other
The front windshield cracked on its own on [XXX] evening around 8 pm while the vehicle was parked. I stopped at gas station to fill gas. When I was done pumping gas and sat in the car, I can hear the crack unfold and could not believe my ears and eyes. A big crack on bottom side of front windshield. Crack is smooth to touch both…
Read full complaint
The front windshield cracked on its own on [XXX] evening around 8 pm while the vehicle was parked. I stopped at gas station to fill gas. When I was done pumping gas and sat in the car, I can hear the crack unfold and could not believe my ears and eyes. A big crack on bottom side of front windshield. Crack is smooth to touch both inside and outside but clearly visible. No object struck the windshield. The temperature was very frigid here in cleveland, ohio at that time. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11565784
Mileage unknown · Dec 17, 2023
Unknown Or Other
My sunroof exploded on my 2021 Honda Odyssey while I was driving on the interstate, I-10 East, on Dec 16, 2023, around 4:30 pm. There was no impact from a rock or other debris. There was no rain or hail present. I was not near an overpass. I was driving and heard an explosion above me and then heard outside air like the windows…
Read full complaint
My sunroof exploded on my 2021 Honda Odyssey while I was driving on the interstate, I-10 East, on Dec 16, 2023, around 4:30 pm. There was no impact from a rock or other debris. There was no rain or hail present. I was not near an overpass. I was driving and heard an explosion above me and then heard outside air like the windows were open. The center of my sunroof exploded and shattered onto my sunroof cover.
NHTSA ODI #11560516
Mileage unknown · Oct 23, 2023
Unknown Or Other
The rear view mirror on the windshield After I had the service work done for the recall, The rear view mirror on the windshield keeps breaking and hanging down. This causes hazardous conditions while driving. I took the vehicle for an oil change, and to correct the recall problem. The mirror fell apart and hung from the windsh…
Read full complaint
The rear view mirror on the windshield After I had the service work done for the recall, The rear view mirror on the windshield keeps breaking and hanging down. This causes hazardous conditions while driving. I took the vehicle for an oil change, and to correct the recall problem. The mirror fell apart and hung from the windshield shortly after that. The shop has confirmed that this is the part they worked on for the recall. Bisbee Honda of Danville, VA, has attempted to fix the problem 3 times. They have only been able to “stick it back together”. It causes a safety hazard as it cannot be adjusted. Meanwhile, per the service department, they initially ordered the wrong part, and failed to call me when it arrived. The (hopefully) correct part is now in backorder and per the service manager, it could be days, weeks or months. I guess it’s stuck back up with super glue or Velcro and I’ve been advised not to touch it…
NHTSA ODI #11551376
Mileage unknown · Jun 12, 2023
Unknown Or OtherInjury
The rear lift gate will be open and then all the sudden decide it needs to be shut. Beeps really load and then come down hard and fast with no real time to recognize what is happening and get out of the way. It hurts and doesn’t stop when it hits a person
NHTSA ODI #11526594
Official recalls
8May 21, 2026
Honda (American Honda Motor Co.) is recalling certain 2018-2021, 2023 Acura TLX, 2019-2024 RDX, 2017-2020, 2022-2026 MDX, 2017-2021, 2023, 2025 Honda Ridgeline, 2017-2022 Pilot, 2019-2021 Passport, 2018-2026 Odyssey, 2019-2022 Insight, 2019-2021 HR-V, 2018-2020 Fit, 2020-2022 CR-V Hybrid, 2017-2022 CR-V, 2017-2018, 2021 Civic Type R, 2017-2021 Civic hatchback, 2016-2020 Civic coupe, 2016-2022 Civic, 2017-2022 Accord Hybrid, and 2016-2022 Accord vehicles. The front passenger seat weight sensor may crack and short circuit, which can cause the air bags to deploy unintentionally during a crash.
Consequence & remedy
Consequence: Air bags that deploy unintentionally during a crash increase the risk of injury.
Remedy: Dealers will replace the seat weight sensors, free of charge. Owner notification letters were mailed July 7, 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are BOL, WO9, OOA, WOM, XOH, NOC, POD, BOE, UOF, POB, EOG, AOI, QO8, TOJ, DO7, and SOK. This recall expands previous NHTSA recall number 24V064. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning May 29, 2026.
Apr 9, 2026
Honda (American Honda Motor Co.) is recalling certain 2018-2022 Odyssey vehicles. A software programming error can cause the side and side curtain air bags to deploy unexpectedly.
Consequence & remedy
Consequence: Air bags that deploy unexpectedly can increase the risk of injury.
Remedy: Dealers will reprogram the supplemental restraint system (SRS) electronic control unit (ECU) software or replace the ECU, as necessary, free of charge. Owner notification letters were mailed May 27, 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's number for this recall is UNW. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning April 16, 2026. The information in your report suggests that Honda (American Honda Motor Co.) may have been aware of this issue more than five business days before filing a report with NHTSA. Please be reminded that under Federal law, this agency is to be notified of all safety defect and/or noncompliance decisions within five business days. 49 CFR 573.6 Significant civil penalties can be assessed for this violation.
Dec 17, 2025
Vantage Mobility, LLC (VM) is recalling certain 2021-2026 Honda Odyssey, 2021-2025 Chrysler Pacifica, and Toyota Sienna vehicles equipped with QRT-Deluxe and QRT-Max wheelchair restraints. The retractors may not lock, preventing the wheelchair from being properly secured.
Consequence & remedy
Consequence: An unsecured wheelchair can move during transit, increasing the risk of injury.
Remedy: Dealers will inspect and replace the retractors, free of charge. Owner notification letters was mailed January 27, 2026. Owners may contact Vantage Mobility customer service at 1-800-488-9082.
Feb 1, 2024
Honda (American Honda Motor Co.) is recalling certain 2020-2022 Pilot, Accord, Civic sedan, HR-V, Odyssey, 2020 Civic coupe, Fit, 2021-2022 Civic hatchback, 2021 Civic Type R, Insight, 2020-2021 CR-V, CR-V Hybrid, Passport, Ridgeline, Accord Hybrid, 2020 Acura MDX, 2022 Acura MDX, 2020-2022 Acura RDX, and 2020-2021 Acura TLX vehicles. The front passenger seat weight sensor may crack and short circuit, failing to suppress the air bag as intended.
Consequence & remedy
Consequence: An air bag that deploys unintentionally during a crash can increase the risk of injury.
Remedy: Dealers will replace the seat weight sensors, free of charge. Owner notification letters were mailed March 28, 2024. This is a phased recall. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for these recalls are XHP and VHQ.
Dec 18, 2023
Honda (American Honda Motor Co.) is recalling certain 2013-2023 Honda Accord, Civic Coupe, Civic Sedan, Civic Hatchback, Civic Type R, CR-V, HR-V, Ridgeline, Odyssey, Acura ILX, MDX, MDX Hybrid, RDX, RLX, TLX, 2019-2022 Honda Insight, Passport, 2020 Honda CR-V Hybrid, 2018-2019 Honda Clarity PHEV, Fit, and 2015-2020 Honda Accord Hybrid, Pilot, Acura NSX vehicles. The fuel pump inside the fuel tank may fail.
Consequence & remedy
Consequence: Fuel pump failure can cause an engine stall while driving, increasing the risk of a crash.
Remedy: Dealers will replace the fuel pump module, free of charge. Owner letters were mailed September 6, 2024. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are KGC and KGD. This recall is an expansion of NHTSA recall numbers 21V-215 and 20V-314.
Jun 15, 2023
Honda (American Honda Motor Co.) is recalling certain 2018-2023 Odyssey, 2019-2022 Pilot, and 2019-2023 Passport vehicles. Due to a faulty Media Oriented Systems Transport (MOST) communication coaxial cable connector, the rearview camera image may not appear on the display. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: A rearview camera that does not display an image can reduce the driver's rear view, increasing the risk of a crash or injury.
Remedy: Dealers will replace the MOST cable harness and install a straightening cover over the vehicle cable connector, free of charge. Owner notification letters were mailed July 24, 2023. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are EEL, ZEM, and SFC.
Mar 16, 2023
Honda (American Honda Motor Co) is recalling certain 2020-2021 Pilot and Ridgeline, and 2020-2022 Passport and Odyssey vehicles. The heating pads behind both side-view mirrors may not be bonded properly, allowing the mirror glass to detach. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: Detached mirror glass can reduce driver visibility, increasing the risk of a crash.
Remedy: Dealers will replace both left and right side-view mirrors, free of charge. Owner letters were mailed January 17, 2024. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is FE5.
Jan 14, 2021
Braun Corporation (Braun) is recalling certain 2018-2021 Braun-modified Honda Odyssey vehicles. The fuel tank assembly installed by Braun may be susceptible to the fuel tank overfilling into the charcoal canister. If the charcoal canister fills with a sufficient amount of fuel, fuel may leak out.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source may increase the risk of fire.
Remedy: Braun will notify owners, and dealers will inspect vehicles. If evidence of a fuel leak is present, a new fuel tank assembly and a new Honda charcoal canister will be installed, free of charge. The recall began February 22, 2021. Owners may contact Braun customer service at 1-800-488-0359.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE25018 · Inadvertent Deployment Of Side Air Bags
Opened Oct 28, 2025 · Closed Jun 25, 2026
Status: closed (inferred from source dates) · Air Bags; Air Bags:sensor:side Impact; Air Bags:side/window
On October 28, 2025, the Office of Defects Investigations (ODI) opened PE25018 to investigate complaints of inadvertent deployment of the side curtain and/or side thorax air bags. These complaints concern model year (MY) 2018-2022 Honda Odyssey vehicles manufactured by American Honda Motor Co. (Honda). Honda issued recall 26V227 on April 9, 2026, to address concerns of inadvertent side air bag deployment. In the recall filing, the company stated that “[a]s of April 2, 2026, Honda has had 130 warranty claims, 25 reports of an injury, and no reports of death related to this issue from January 24, 2017 – April 2, 2026.” Honda states that the Supplemental Restraint System (SRS) Electronic Control Unit (ECU) contains incorrect deployment parameters for the side thorax and side curtain air bags, which may cause inadvertent deployment when the vehicle encounters strong road impacts, such as driving over potholes, speed bumps, or road debris. Honda stated that the SRS control logic for the second and third rows of seating contained an insufficient deployment threshold margin, allowing signal inputs to be misinterpreted as side impacts and causing inadvertent deployment of the side thorax and side curtain air bags. Recall 26V227 states that dealers will reprogram or replace the SRS ECU with improved air bag deployment parameters. Consumers received notice of this recall in late May 2026. In view of the recall being conducted by Honda, ODI is closing this Preliminary Evaluation (PE). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Air Bags
On October 28, 2025, the Office of Defects Investigations (ODI) opened PE25018 to investigate complaints of inadvertent deployment of the side curtain and/or side thorax air bags. These complaints concern model year (MY) 2018-2022 Honda Odyssey vehicles manufactured by American Honda Motor Co. (Honda). Honda issued recall 26V227 on April 9, 2026, to address concerns of inadvertent side air bag deployment. In the recall filing, the company stated that “[a]s of April 2, 2026, Honda has had 130 warranty claims, 25 reports of an injury, and no reports of death related to this issue from January 24, 2017 – April 2, 2026.” Honda states that the Supplemental Restraint System (SRS) Electronic Control Unit (ECU) contains incorrect deployment parameters for the side thorax and side curtain air bags, which may cause inadvertent deployment when the vehicle encounters strong road impacts, such as driving over potholes, speed bumps, or road debris. Honda stated that the SRS control logic for the second and third rows of seating contained an insufficient deployment threshold margin, allowing signal inputs to be misinterpreted as side impacts and causing inadvertent deployment of the side thorax and side curtain air bags. Recall 26V227 states that dealers will reprogram or replace the SRS ECU with improved air bag deployment parameters. Consumers received notice of this recall in late May 2026. In view of the recall being conducted by Honda, ODI is closing this Preliminary Evaluation (PE). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Air Bags:sensor:side Impact
On October 28, 2025, the Office of Defects Investigations (ODI) opened PE25018 to investigate complaints of inadvertent deployment of the side curtain and/or side thorax air bags. These complaints concern model year (MY) 2018-2022 Honda Odyssey vehicles manufactured by American Honda Motor Co. (Honda). Honda issued recall 26V227 on April 9, 2026, to address concerns of inadvertent side air bag deployment. In the recall filing, the company stated that “[a]s of April 2, 2026, Honda has had 130 warranty claims, 25 reports of an injury, and no reports of death related to this issue from January 24, 2017 – April 2, 2026.” Honda states that the Supplemental Restraint System (SRS) Electronic Control Unit (ECU) contains incorrect deployment parameters for the side thorax and side curtain air bags, which may cause inadvertent deployment when the vehicle encounters strong road impacts, such as driving over potholes, speed bumps, or road debris. Honda stated that the SRS control logic for the second and third rows of seating contained an insufficient deployment threshold margin, allowing signal inputs to be misinterpreted as side impacts and causing inadvertent deployment of the side thorax and side curtain air bags. Recall 26V227 states that dealers will reprogram or replace the SRS ECU with improved air bag deployment parameters. Consumers received notice of this recall in late May 2026. In view of the recall being conducted by Honda, ODI is closing this Preliminary Evaluation (PE). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Air Bags:side/window
On October 28, 2025, the Office of Defects Investigations (ODI) opened PE25018 to investigate complaints of inadvertent deployment of the side curtain and/or side thorax air bags. These complaints concern model year (MY) 2018-2022 Honda Odyssey vehicles manufactured by American Honda Motor Co. (Honda). Honda issued recall 26V227 on April 9, 2026, to address concerns of inadvertent side air bag deployment. In the recall filing, the company stated that “[a]s of April 2, 2026, Honda has had 130 warranty claims, 25 reports of an injury, and no reports of death related to this issue from January 24, 2017 – April 2, 2026.” Honda states that the Supplemental Restraint System (SRS) Electronic Control Unit (ECU) contains incorrect deployment parameters for the side thorax and side curtain air bags, which may cause inadvertent deployment when the vehicle encounters strong road impacts, such as driving over potholes, speed bumps, or road debris. Honda stated that the SRS control logic for the second and third rows of seating contained an insufficient deployment threshold margin, allowing signal inputs to be misinterpreted as side impacts and causing inadvertent deployment of the side thorax and side curtain air bags. Recall 26V227 states that dealers will reprogram or replace the SRS ECU with improved air bag deployment parameters. Consumers received notice of this recall in late May 2026. In view of the recall being conducted by Honda, ODI is closing this Preliminary Evaluation (PE). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
EA25004 · No Restart After Auto Start/stop Engages
Opened Mar 26, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:crank/camshaft Position Sensor; Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (4)
Engine And Engine Cooling:engine:crank/camshaft Position Sensor
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration