NHTSA owner reports · September 18, 2026 snapshot.
Suspension complaints
6 reportsClear category filterMileage unknown · Aug 28, 2026
Suspension
At 64,000 miles both rear shock absorbers failed (rusted), one completely the other on the verge. Driving the car was dangerous as the car became unstable at higher speeds when going over normal bumps and road holes. The repair including parts, labor, and necessary four wheel alignment was $1,051. The dealer did not acknowledge…
Read full complaint
At 64,000 miles both rear shock absorbers failed (rusted), one completely the other on the verge. Driving the car was dangerous as the car became unstable at higher speeds when going over normal bumps and road holes. The repair including parts, labor, and necessary four wheel alignment was $1,051. The dealer did not acknowledge this being a common issue nor did they deny it. A google search indicates this is a common issue with Honda Odyssey Vans for the 2021-2024 manufacturing years. There were no warning indicators other than experiencing the effect of the shock absorber failures while driving the vehicle. The vehicle passed PA State Inspection earlier in 2026 (March).
NHTSA ODI #11760327
Mileage unknown · Mar 24, 2026
Suspension
Rear passenger side shock absorber snapped on a family road trip. Vehicle began to fishtail with every bump in the road leading to excursions very close to lane markings at times. Inspection by dealer not only confirmed the damage but also found older damage involving the right front control arm which also had to be replaced. …
Read full complaint
Rear passenger side shock absorber snapped on a family road trip. Vehicle began to fishtail with every bump in the road leading to excursions very close to lane markings at times. Inspection by dealer not only confirmed the damage but also found older damage involving the right front control arm which also had to be replaced. Owner had noticed a rattle in the steering column before original new car warranty expired. Original dealer could not locate the source years ago. Problem completely vanished after the current control arm repair. Owner is concerned that had rear passenger side shock absorber and front swing arm completely failed at the same time that vehicle would have departed.the road surface at speed. Vehicle has 64,000 miles on it, relatively low, light mileage for a vehicle of this age. A Google search reveals many other owner of this same make and model year have experienced the same problems.
NHTSA ODI #11726851
Mileage unknown · Aug 27, 2025
Electrical SystemEngineSuspension
Can has been making a popping noise that can be felt in the steering wheel for 2 years. Honda has told me nothing was wrong after taking it in 4 times. Now my car keeps stalling at lights, sometimes it takes a while to get it to restart, and they can not figure out why. They keep saying the battery is fine and diagnostics finds …
Read full complaint
Can has been making a popping noise that can be felt in the steering wheel for 2 years. Honda has told me nothing was wrong after taking it in 4 times. Now my car keeps stalling at lights, sometimes it takes a while to get it to restart, and they can not figure out why. They keep saying the battery is fine and diagnostics finds nothing.
NHTSA ODI #11683344
Mileage unknown · Aug 24, 2025
Suspension
Approximately May 2023, while pulling away from stop light, heard loud pop (like gunshot inside vehicle) and vehicle shuddered/jolted. It feels almost like someone hit vehicle with sledgehammer. I looked underneath but no issues found. No bump in road was hit at the time. December 24th 2024, while moving at less then 5 mph, …
Read full complaint
Approximately May 2023, while pulling away from stop light, heard loud pop (like gunshot inside vehicle) and vehicle shuddered/jolted. It feels almost like someone hit vehicle with sledgehammer. I looked underneath but no issues found. No bump in road was hit at the time. December 24th 2024, while moving at less then 5 mph, heard another loud pop and shudder/jolt. Someone sitting in the back thought that something fell on the vehicle. This time noticed that left rear tire was into wheel well with vehicle unloaded. After pulling wheel, found left rear coil spring broken in 2 places. Believe broke first in 23 and again in 24. At time, we were 1200 miles from home and needed to delay trip so Honda in Killeen TX could repair. Dealer service advisor stated they had never seen anything like that except from crash. June 19th 2025. On highway doing 70-75 mph when heard another loud pop and shudder. No pot hole or any significant bump hit. Stopped, pulled wheel, and found right rear spring broken. Honda dealership in Marysville OH unable to find new spring either through OEM or aftermarket. We have also been unable to find aftermarket or junkyards. Being told that there is a nationwide backorder and no eta for when replacment parts are going to start being available. So being forced to continue driving a vehicle that is unsafe. First this does not seem normal for springs just to randomly break. Second for a critical suspension component on a relatively new vehicle, why is manufacturer unable to proved parts. We are now 2 months into it being broken and can't even order replacment parts yet because Honda is not allowing orders to be placed.
NHTSA ODI #11682656
Mileage unknown · Sep 19, 2024
Suspension
I purchased a 2021 Honda Odyssey with 55,000 miles on it. At 57,000 miles with normal driving conditions, I heard a metal on metal noise on rear passenger side. Upon taking it to the mechanic, both rear springs were rusted & broken - essentially giving my van no rear suspension and making it very dangerous to drive. I had to fi…
Read full complaint
I purchased a 2021 Honda Odyssey with 55,000 miles on it. At 57,000 miles with normal driving conditions, I heard a metal on metal noise on rear passenger side. Upon taking it to the mechanic, both rear springs were rusted & broken - essentially giving my van no rear suspension and making it very dangerous to drive. I had to find a new vehicle for my kids for a month and a half as there is no aftermarket part. Honda would not find the part for me and wanted me to work through the dealership, but I did not have the time as this is family vehicle that I need each day. I had an independent mechanic find a pair of springs from a junkyard & he confirmed that in his 40 years of servicing exclusively Hondas, he's never seen springs fail like this at this mileage. He expected a faulty part. I drove this vehicle multiple times thinking that it was safe & only something loose in the car. At any moment, the suspension could have failed & caused a serious accident. I do have the springs & have attached photos. Component has not been inspected by anyone other than myself & mechanic. No prior warnings or messages noting a problem.
NHTSA ODI #11615521
Mileage unknown · Jun 3, 2024
Suspension
The inside shoulder of all four tires are bald and unsafe. The rest of the tire tread has ~7/32 of depth remaining. Because this suspension issue only affects the inside edge of the tire it is difficult to detect. Not all Gen 5 Honda Odysseys have this problem but I've read of others with the same problems as mine. The tires…
Read full complaint
The inside shoulder of all four tires are bald and unsafe. The rest of the tire tread has ~7/32 of depth remaining. Because this suspension issue only affects the inside edge of the tire it is difficult to detect. Not all Gen 5 Honda Odysseys have this problem but I've read of others with the same problems as mine. The tires cross the threshold of 2/32" by approx. 23k miles. When the rest of the tire still looks good the avg consumer is not inspecting the inner shoulder because it would require tire removal or getting under the vehicle. Therefore, the issue goes undetected until a traction event occurs.
NHTSA ODI #11592306
Official recalls
8May 21, 2026
Honda (American Honda Motor Co.) is recalling certain 2018-2021, 2023 Acura TLX, 2019-2024 RDX, 2017-2020, 2022-2026 MDX, 2017-2021, 2023, 2025 Honda Ridgeline, 2017-2022 Pilot, 2019-2021 Passport, 2018-2026 Odyssey, 2019-2022 Insight, 2019-2021 HR-V, 2018-2020 Fit, 2020-2022 CR-V Hybrid, 2017-2022 CR-V, 2017-2018, 2021 Civic Type R, 2017-2021 Civic hatchback, 2016-2020 Civic coupe, 2016-2022 Civic, 2017-2022 Accord Hybrid, and 2016-2022 Accord vehicles. The front passenger seat weight sensor may crack and short circuit, which can cause the air bags to deploy unintentionally during a crash.
Consequence & remedy
Consequence: Air bags that deploy unintentionally during a crash increase the risk of injury.
Remedy: Dealers will replace the seat weight sensors, free of charge. Owner notification letters were mailed July 7, 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are BOL, WO9, OOA, WOM, XOH, NOC, POD, BOE, UOF, POB, EOG, AOI, QO8, TOJ, DO7, and SOK. This recall expands previous NHTSA recall number 24V064. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning May 29, 2026.
Apr 9, 2026
Honda (American Honda Motor Co.) is recalling certain 2018-2022 Odyssey vehicles. A software programming error can cause the side and side curtain air bags to deploy unexpectedly.
Consequence & remedy
Consequence: Air bags that deploy unexpectedly can increase the risk of injury.
Remedy: Dealers will reprogram the supplemental restraint system (SRS) electronic control unit (ECU) software or replace the ECU, as necessary, free of charge. Owner notification letters were mailed May 27, 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's number for this recall is UNW. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning April 16, 2026. The information in your report suggests that Honda (American Honda Motor Co.) may have been aware of this issue more than five business days before filing a report with NHTSA. Please be reminded that under Federal law, this agency is to be notified of all safety defect and/or noncompliance decisions within five business days. 49 CFR 573.6 Significant civil penalties can be assessed for this violation.
Dec 17, 2025
Vantage Mobility, LLC (VM) is recalling certain 2021-2026 Honda Odyssey, 2021-2025 Chrysler Pacifica, and Toyota Sienna vehicles equipped with QRT-Deluxe and QRT-Max wheelchair restraints. The retractors may not lock, preventing the wheelchair from being properly secured.
Consequence & remedy
Consequence: An unsecured wheelchair can move during transit, increasing the risk of injury.
Remedy: Dealers will inspect and replace the retractors, free of charge. Owner notification letters was mailed January 27, 2026. Owners may contact Vantage Mobility customer service at 1-800-488-9082.
Feb 1, 2024
Honda (American Honda Motor Co.) is recalling certain 2020-2022 Pilot, Accord, Civic sedan, HR-V, Odyssey, 2020 Civic coupe, Fit, 2021-2022 Civic hatchback, 2021 Civic Type R, Insight, 2020-2021 CR-V, CR-V Hybrid, Passport, Ridgeline, Accord Hybrid, 2020 Acura MDX, 2022 Acura MDX, 2020-2022 Acura RDX, and 2020-2021 Acura TLX vehicles. The front passenger seat weight sensor may crack and short circuit, failing to suppress the air bag as intended.
Consequence & remedy
Consequence: An air bag that deploys unintentionally during a crash can increase the risk of injury.
Remedy: Dealers will replace the seat weight sensors, free of charge. Owner notification letters were mailed March 28, 2024. This is a phased recall. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for these recalls are XHP and VHQ.
Dec 18, 2023
Honda (American Honda Motor Co.) is recalling certain 2013-2023 Honda Accord, Civic Coupe, Civic Sedan, Civic Hatchback, Civic Type R, CR-V, HR-V, Ridgeline, Odyssey, Acura ILX, MDX, MDX Hybrid, RDX, RLX, TLX, 2019-2022 Honda Insight, Passport, 2020 Honda CR-V Hybrid, 2018-2019 Honda Clarity PHEV, Fit, and 2015-2020 Honda Accord Hybrid, Pilot, Acura NSX vehicles. The fuel pump inside the fuel tank may fail.
Consequence & remedy
Consequence: Fuel pump failure can cause an engine stall while driving, increasing the risk of a crash.
Remedy: Dealers will replace the fuel pump module, free of charge. Owner letters were mailed September 6, 2024. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are KGC and KGD. This recall is an expansion of NHTSA recall numbers 21V-215 and 20V-314.
Jun 15, 2023
Honda (American Honda Motor Co.) is recalling certain 2018-2023 Odyssey, 2019-2022 Pilot, and 2019-2023 Passport vehicles. Due to a faulty Media Oriented Systems Transport (MOST) communication coaxial cable connector, the rearview camera image may not appear on the display. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: A rearview camera that does not display an image can reduce the driver's rear view, increasing the risk of a crash or injury.
Remedy: Dealers will replace the MOST cable harness and install a straightening cover over the vehicle cable connector, free of charge. Owner notification letters were mailed July 24, 2023. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are EEL, ZEM, and SFC.
Mar 16, 2023
Honda (American Honda Motor Co) is recalling certain 2020-2021 Pilot and Ridgeline, and 2020-2022 Passport and Odyssey vehicles. The heating pads behind both side-view mirrors may not be bonded properly, allowing the mirror glass to detach. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: Detached mirror glass can reduce driver visibility, increasing the risk of a crash.
Remedy: Dealers will replace both left and right side-view mirrors, free of charge. Owner letters were mailed January 17, 2024. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is FE5.
Jan 14, 2021
Braun Corporation (Braun) is recalling certain 2018-2021 Braun-modified Honda Odyssey vehicles. The fuel tank assembly installed by Braun may be susceptible to the fuel tank overfilling into the charcoal canister. If the charcoal canister fills with a sufficient amount of fuel, fuel may leak out.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source may increase the risk of fire.
Remedy: Braun will notify owners, and dealers will inspect vehicles. If evidence of a fuel leak is present, a new fuel tank assembly and a new Honda charcoal canister will be installed, free of charge. The recall began February 22, 2021. Owners may contact Braun customer service at 1-800-488-0359.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE25018 · Inadvertent Deployment Of Side Air Bags
Opened Oct 28, 2025 · Closed Jun 25, 2026
Status: closed (inferred from source dates) · Air Bags; Air Bags:sensor:side Impact; Air Bags:side/window
On October 28, 2025, the Office of Defects Investigations (ODI) opened PE25018 to investigate complaints of inadvertent deployment of the side curtain and/or side thorax air bags. These complaints concern model year (MY) 2018-2022 Honda Odyssey vehicles manufactured by American Honda Motor Co. (Honda). Honda issued recall 26V227 on April 9, 2026, to address concerns of inadvertent side air bag deployment. In the recall filing, the company stated that “[a]s of April 2, 2026, Honda has had 130 warranty claims, 25 reports of an injury, and no reports of death related to this issue from January 24, 2017 – April 2, 2026.” Honda states that the Supplemental Restraint System (SRS) Electronic Control Unit (ECU) contains incorrect deployment parameters for the side thorax and side curtain air bags, which may cause inadvertent deployment when the vehicle encounters strong road impacts, such as driving over potholes, speed bumps, or road debris. Honda stated that the SRS control logic for the second and third rows of seating contained an insufficient deployment threshold margin, allowing signal inputs to be misinterpreted as side impacts and causing inadvertent deployment of the side thorax and side curtain air bags. Recall 26V227 states that dealers will reprogram or replace the SRS ECU with improved air bag deployment parameters. Consumers received notice of this recall in late May 2026. In view of the recall being conducted by Honda, ODI is closing this Preliminary Evaluation (PE). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Air Bags
On October 28, 2025, the Office of Defects Investigations (ODI) opened PE25018 to investigate complaints of inadvertent deployment of the side curtain and/or side thorax air bags. These complaints concern model year (MY) 2018-2022 Honda Odyssey vehicles manufactured by American Honda Motor Co. (Honda). Honda issued recall 26V227 on April 9, 2026, to address concerns of inadvertent side air bag deployment. In the recall filing, the company stated that “[a]s of April 2, 2026, Honda has had 130 warranty claims, 25 reports of an injury, and no reports of death related to this issue from January 24, 2017 – April 2, 2026.” Honda states that the Supplemental Restraint System (SRS) Electronic Control Unit (ECU) contains incorrect deployment parameters for the side thorax and side curtain air bags, which may cause inadvertent deployment when the vehicle encounters strong road impacts, such as driving over potholes, speed bumps, or road debris. Honda stated that the SRS control logic for the second and third rows of seating contained an insufficient deployment threshold margin, allowing signal inputs to be misinterpreted as side impacts and causing inadvertent deployment of the side thorax and side curtain air bags. Recall 26V227 states that dealers will reprogram or replace the SRS ECU with improved air bag deployment parameters. Consumers received notice of this recall in late May 2026. In view of the recall being conducted by Honda, ODI is closing this Preliminary Evaluation (PE). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Air Bags:sensor:side Impact
On October 28, 2025, the Office of Defects Investigations (ODI) opened PE25018 to investigate complaints of inadvertent deployment of the side curtain and/or side thorax air bags. These complaints concern model year (MY) 2018-2022 Honda Odyssey vehicles manufactured by American Honda Motor Co. (Honda). Honda issued recall 26V227 on April 9, 2026, to address concerns of inadvertent side air bag deployment. In the recall filing, the company stated that “[a]s of April 2, 2026, Honda has had 130 warranty claims, 25 reports of an injury, and no reports of death related to this issue from January 24, 2017 – April 2, 2026.” Honda states that the Supplemental Restraint System (SRS) Electronic Control Unit (ECU) contains incorrect deployment parameters for the side thorax and side curtain air bags, which may cause inadvertent deployment when the vehicle encounters strong road impacts, such as driving over potholes, speed bumps, or road debris. Honda stated that the SRS control logic for the second and third rows of seating contained an insufficient deployment threshold margin, allowing signal inputs to be misinterpreted as side impacts and causing inadvertent deployment of the side thorax and side curtain air bags. Recall 26V227 states that dealers will reprogram or replace the SRS ECU with improved air bag deployment parameters. Consumers received notice of this recall in late May 2026. In view of the recall being conducted by Honda, ODI is closing this Preliminary Evaluation (PE). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Air Bags:side/window
On October 28, 2025, the Office of Defects Investigations (ODI) opened PE25018 to investigate complaints of inadvertent deployment of the side curtain and/or side thorax air bags. These complaints concern model year (MY) 2018-2022 Honda Odyssey vehicles manufactured by American Honda Motor Co. (Honda). Honda issued recall 26V227 on April 9, 2026, to address concerns of inadvertent side air bag deployment. In the recall filing, the company stated that “[a]s of April 2, 2026, Honda has had 130 warranty claims, 25 reports of an injury, and no reports of death related to this issue from January 24, 2017 – April 2, 2026.” Honda states that the Supplemental Restraint System (SRS) Electronic Control Unit (ECU) contains incorrect deployment parameters for the side thorax and side curtain air bags, which may cause inadvertent deployment when the vehicle encounters strong road impacts, such as driving over potholes, speed bumps, or road debris. Honda stated that the SRS control logic for the second and third rows of seating contained an insufficient deployment threshold margin, allowing signal inputs to be misinterpreted as side impacts and causing inadvertent deployment of the side thorax and side curtain air bags. Recall 26V227 states that dealers will reprogram or replace the SRS ECU with improved air bag deployment parameters. Consumers received notice of this recall in late May 2026. In view of the recall being conducted by Honda, ODI is closing this Preliminary Evaluation (PE). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
EA25004 · No Restart After Auto Start/stop Engages
Opened Mar 26, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:crank/camshaft Position Sensor; Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (4)
Engine And Engine Cooling:engine:crank/camshaft Position Sensor
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration