DOOR HANDLES HAVE BEEN DIFFICULT TO USE SINCE VEHICLE WAS PURCHASED. AFTER ARRIVING AT A DESTINATION DRIVER TRIED TO OPEN DOOR FROM THE INSIDE, AND DOOR WOULD NOT OPEN. THEN DRIVER TRIED PUSHING ON DOOR WHILE USING DOOR HANDLE, AND THE HANDLE BROKE. BOTH DOORS HAVE BEEN TOUGH TO USE. DIFFICULTY APPEARS TO COME FROM USE ON…
Read full complaint
DOOR HANDLES HAVE BEEN DIFFICULT TO USE SINCE VEHICLE WAS PURCHASED. AFTER ARRIVING AT A DESTINATION DRIVER TRIED TO OPEN DOOR FROM THE INSIDE, AND DOOR WOULD NOT OPEN. THEN DRIVER TRIED PUSHING ON DOOR WHILE USING DOOR HANDLE, AND THE HANDLE BROKE. BOTH DOORS HAVE BEEN TOUGH TO USE. DIFFICULTY APPEARS TO COME FROM USE ON THE INSIDE ONLY. *AK ALSO LATCH ON TAIL GATE FAILED. THE CONSUMER WAS EVEN MORE CONCERNED ABOUT THE POSSIBILITY THAT THE DOOR MIGHT NOT OPEN DURING ACCIDENT OR FIRE. *YH
NHTSA ODI #876586
Mileage unknown · Jan 28, 1997
Latches/locks/linkages
OWNER STATES THAT THE DOOR LATCH IS BROKEN ON THE LEFT SIDE AND THAT HE HAD VEHICLE IN THE SHOP ON THREE DIFFERENT TIMES AND THEY HAVE NOT CORRECTED PROBLEM. *AK
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES, 2 AND 4-WHEEL DRIVE. SOLDER JOINTS NEAR THE WIRING HARNESS CONNECTOR CAN CRACK CAUSING THE WINDSHIELD WIPERS TO WORK INTERMITTENTLY.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN INOPERATIVE WIPERS, REDUCING A DRIVER'S VISIBILITY, AND INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER.
THESE VEHICLES WERE ASSEMBLED WITH THE THROTTLE CABLE CONTACTING THE DASH MAT WHICH COULD BIND THE THROTTLE. THIS DOES NOT MEET WITH THE MAXIMUM RETURN TIMES REQUIRED BY FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 124, "ACCELERATOR CONTROL SYSTEMS."
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: THE ENGINE SPEED MAY NOT RETURN TO IDLE INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL INSPECT FOR ADEQUATE THROTTLE CABLE TO DASH MAT CLEARANCE, AND IF THERE IS INSUFFICIENT CLEARANCE, CUT OUT A PORTION OF THE DASH MAT TO PROVIDE PROPER CLEARANCE.
IF BOTH THE LAP-BELT AND SHOULDER-BELT ENERGY MANAGEMENT LOOPS ON THE FRONT SEAT BELT ASSEMBLIES RELEASE AT OR NEAR THE SAME TIME, ACCELERATION FORCES CAN CAUSE THE BUCKLE RELEASE MECHANISM TO ACTIVATE AND ALLOW THE BUCKLE TO SEPARATE FROM THE LATCH.
Consequence & remedy
Consequence: IF THE BUCKLE RELEASED, THE SYSTEM WOULD FAIL TO PROVIDE ADEQUATE OCCUPANT RESTRAINT PROTECTION.
Remedy: DEALERS WILL REMOVE THE STITCHING THAT CREATES THE ENERGY MANAGEMENT LOOP IN THE SHOULDER BELT(S).
THESE VEHICLES WERE BUILT WITH FRONT SEAT BELT SYSTEMS WITH NO ENERGY MANAGEMENT LOOPS AND MAY NOT MEET THE HEAD INJURY CRITERIA REQUIREMENTS OF FMVSS NO. 208, "OCCUPANT CRASH PROTECTION."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANTS OF THESE SEATS MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL REPLACE THE RETRACTOR PORTION OF THE SEAT BELT ASSEMBLY(S) WITH ONE HAVING THE NEWLY DESIGNED ENERGY-MANAGEMENT TWIN-LOOP SYSTEM.
THE TRANSMISSION SHIFT-CABLE LOCK CLIP CAN BACK OUT OF ITS INSTALLED POSITION RESULTING IN A LOSS OF CABLE ADJUSTMENT. WHEN THE SHIFT LEVER IS PLACED IN THE "PARK" POSITION, THE "PARK" INDICATOR LIGHT MAY NOT ILLUMINATE.
Consequence & remedy
Consequence: THE VEHICLE CAN MOVE UNINTENTIONALLY IF THE DRIVER DOES NOT NOTICE THAT THE INDICATOR LIGHT IS NOT ON AND DOES NOT APPLY THE PARKING BRAKE.
Remedy: DEALERS WILL ADJUST THE SHIFT CABLE AND INSTALL A LOCK CLIP.
DUE TO A THIN CASE CASTING, AN EXTERNAL TRANSMISSION LEAK CAN OCCUR.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE TRANSMISSION OIL TO SPRAYONTO THE EXHAUST SYSTEM AND RESULT IN A POSSIBLE VEHICLE FIRE.
Remedy: DEALERS WILL INSPECT THE TRANSMISSION CASE ASSEMBLY FOR THE INVOLVED CASE CASTING. IF THE ASSEMBLY IS INVOLVED, THE TRANSMISSION WILL BE REPLACED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
EA02006 · Windshield Wiper Failure
Opened May 31, 2002 · Closed Jul 23, 2003
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Additional source detail variants (2)
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
EA00024 · Headlight
Opened Sep 26, 2000 · Closed Dec 21, 2001
Status: closed (inferred from source dates) · Exterior Lighting
No summary supplied.
PE00017 · Headlight
Opened Apr 11, 2000 · Closed Sep 26, 2000
Status: closed (inferred from source dates) · Exterior Lighting
BASED ON THE REPORTS RECEIVED BY ODI FROM CONSUMERS, FAILURE OF THE HEADLIGHT ELECTRICAL CIRCUIT MAY OCCUR IN THE SUBJECT VEHICLES, AND MAY RESULT FROM REPEATED ADJUSTMENT OFTHE TILT STEERING WHEEL IN THE SUBJECT VEHICLES.REPEATED ADJUSTMENT OF THE STEERING WHEEL POSITION MAY STRAIN THE WIRING IN THE HEADLIGHT CIRCUIT TO THE POINT OF FAILURE WHERE THEY ARE ATTACHED TO THE MULTI-FUNCTION SWITCH, RESULTING IN THE UNANTICIPATED LOSS OF HEADLIGHTS WHILE THE VEHICLE IS IN MOTION.ODI HAS CONCERNS REGARDING THE HIGH RATE OF WARRANTY REPAIRS FOR PROBLEMS POTENTIALLY ASSOCIATED WITH THE ALLEGED DEFECT IN THE SUBJECT VEHICLES, WITH THE RECOGNITION THE EACH INCIDENT OF HEADLIGHT FAILURE REPRESENTS A CONDITION OF VEHICLE DISABLEMENT.IN ADDITION, THE MANUFACTURER'S EVALUATION OF THE ALLEGED DEFECT HAS NOT BEEN RECEIVED, AND THIS OFFICE HAS INTEREST IN THE DETAILS OF THE METHODOLOGIES AND RESULTS OF THAT ASSESSMENT.
1995 GMC Sierra Problems, Complaints & Recalls | Skip That Year
Illustration