IllustrationI WAS TRAVELING DOWN THE INTERSTATE AND THE THROTTLE CABLE WAS STUCK WIDE OPEN AND I REACHED SPEEDS OF ALMOST 100 IN HEAVY TRAFFIC
1996 GMC Sierra
Owner reports · Recalls · Investigations
More warning signs than most Sierra years
Owner complaints for the 1996 GMC Sierra are substantially higher than the model-year median of 53.
About this comparison →How this year compares
Owner complaints by model year
Compare all Sierra years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 26 of 246 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Visibility. Review the 84 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 47 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 24 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
19 crash reports3 fire reports13 injury reports
What owners actually said
246 reportsDT*: THE CONTACT STATED THE ABS ACTIVATED AT VARIOUS LOW SPEEDS AND THERE WERE INCREASED STOPPING DISTANCES. THERE IS A NHTSA RECALL, # 05V379000, REGARDING THE ANTILOCK BRAKES. THE VEHICLE HAS THE SAME PROBLEMS AS INDICATED IN THE RECALL; HOWEVER IT IS NOT INCLUDED IN THE RECALL DUE TO THE VIN. ALTHOUGH THESE PROBLEMS PERSI…
Read full complaint
DT*: THE CONTACT STATED THE ABS ACTIVATED AT VARIOUS LOW SPEEDS AND THERE WERE INCREASED STOPPING DISTANCES. THERE IS A NHTSA RECALL, # 05V379000, REGARDING THE ANTILOCK BRAKES. THE VEHICLE HAS THE SAME PROBLEMS AS INDICATED IN THE RECALL; HOWEVER IT IS NOT INCLUDED IN THE RECALL DUE TO THE VIN. ALTHOUGH THESE PROBLEMS PERSISTED, THE VEHICLE WAS NOT SEEN BY A DEALER.
WHILE TOWING TRAILER WITH 2 QUADS (4 WHEELERS) ON EXPRESSWAY WITH A GROUP OF CO-WORKERS, I WAS ATTEMPTING TO PASS ANOTHER VEHICLE WHEN MY TRUCK WOULD NOT SHIFT INTO PASSING GEAR. IT MADE A LOUD "REVING" NOISE AND BEGAN RAPIDLY DECREASING IN SPEED. I PULLED OFF THE EXPRESSWAY BRINGING THE VEHICLE TO A COMPLETE STOP. I THEN GRA…
Read full complaint
WHILE TOWING TRAILER WITH 2 QUADS (4 WHEELERS) ON EXPRESSWAY WITH A GROUP OF CO-WORKERS, I WAS ATTEMPTING TO PASS ANOTHER VEHICLE WHEN MY TRUCK WOULD NOT SHIFT INTO PASSING GEAR. IT MADE A LOUD "REVING" NOISE AND BEGAN RAPIDLY DECREASING IN SPEED. I PULLED OFF THE EXPRESSWAY BRINGING THE VEHICLE TO A COMPLETE STOP. I THEN GRADUALLY ACCELERATED AND SHIFTED MANUALLY, BUT WAS ONLY ABLE TO ACHEIVE 1ST GEAR. I HAD TO HAVE THE VEHICLE TOWED 150 MILES TO MY HOUSE WHERE IT STILL SITS THREE MONTHS LATER WITH ONLY REVERSE AND 1ST GEAR OPERABLE AT THIS TIME.
DT: THE WINDSHIELD WIPERS DO NOT WORK PROPERLY THEY HAVE A STRANGE PATTERN TO THEM. THEY QUIT, AND HAD A HUMMING NOISE FROM THE WIPER MOTOR.*AK HAD WINDSHIELD WIPER RECALL PERFORMED. MOTOR AND CIRCUIT BOARD WERE REPLACED. REPAIRS AT GMC DEALERSHIP ON 6/13/05. *TT *NM
1996 GMC SIERRA LOST ITS CABLES AS WELL AS THE REMAINING PARTS HOLDING THE TAILGATE IS RUSTING AND THE CATCH ON THE DRIVERS SIDE DOES NOT POP OPEN AUTOMATICALLY.*MR....REMAINING PARTS HOLDING TAILGATE ARE RUSTING. ALSO, CATCH ON DRIVER'S SIDE DOESN'T POP OPEN AUTOMATICALLY. WARRANTY EXPIRED WITHIN TRHEE YERAS OF PURCHASE. *AK
VEHICLE LEAKS ANTI-FREEZE FROM VICINITY OF UPPER INTAKE MANIFOLD. CHRONIC PROBLEM. OCCURS AFTER VEHICLE HAS SET FOR 3-5 HOURS AFTER RUNNING. DOES NOT APPEAR TO BE LEAKING INTO CRANKCASE. HAD SYSTEM PRESSURE TESTED. TOLD TO MONITOR TO SEE IF IT IS GETTING INTO OIL. LEAKS ABOUT 1-2 TABLESPOONS PER SHUT DOWN. ENOUGH TO BE NOTICEABL…
Read full complaint
VEHICLE LEAKS ANTI-FREEZE FROM VICINITY OF UPPER INTAKE MANIFOLD. CHRONIC PROBLEM. OCCURS AFTER VEHICLE HAS SET FOR 3-5 HOURS AFTER RUNNING. DOES NOT APPEAR TO BE LEAKING INTO CRANKCASE. HAD SYSTEM PRESSURE TESTED. TOLD TO MONITOR TO SEE IF IT IS GETTING INTO OIL. LEAKS ABOUT 1-2 TABLESPOONS PER SHUT DOWN. ENOUGH TO BE NOTICEABLE
MY WINDSHIELD WIPERS ONLY WORK INTERMITEDLY AND I FOUND THE RECAL FOR IT ON THIS SITE. 996 GMC SIERRA PICKUP..THE DEALORSHIP IS SAYING EVEN THOUGH MY WIPERS ARE BROKEN THEY CANNOT REPAIR FOR FREE BECAUSE MY PARTICULAR VIN # ISN'T ON THE LIST. *AK
THE BRAKE LINE ABOVE THE GAS TANK RUSTED AND FAILED WHILE IT WAS BEING DRIVEN. THERE WAS NO FOREWARNING OF THIS AND AS IT WAS ABOVE THE GAS TANK, WOULD NOT HAVE BEEN NOTICED. THE GAS TANK HAD TO BE DROPPED AND THE BRAKE LINE REPLACED. THANK GOODNESS THE VEHICLE STOPPED BEFORE REARENDING THE VEHICLE IN FRONT OF ME AND THANK GO…
Read full complaint
THE BRAKE LINE ABOVE THE GAS TANK RUSTED AND FAILED WHILE IT WAS BEING DRIVEN. THERE WAS NO FOREWARNING OF THIS AND AS IT WAS ABOVE THE GAS TANK, WOULD NOT HAVE BEEN NOTICED. THE GAS TANK HAD TO BE DROPPED AND THE BRAKE LINE REPLACED. THANK GOODNESS THE VEHICLE STOPPED BEFORE REARENDING THE VEHICLE IN FRONT OF ME AND THANK GOODNESS MY ONE YEAR OLD WASN'T IN THE VEHICLE AT THE TIME. OLD PART HAS BEEN RETAINED. REPAIR COST WAS $458.21.
THE WINDSHIELD WIPERS WORKED INTERMITTENTLY THE DEALER REFUSED TO REPLACE THEM. *JB
COMPLAINT RUSTED BRAKE LINES TO REAR BRAKES IN BEHIND FUEL TANK. *LA
Official recalls
298V150001 · Visibility:windshield Wiper/washer
Jul 1, 1998
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES, 2 AND 4-WHEEL DRIVE. SOLDER JOINTS NEAR THE WIRING HARNESS CONNECTOR CAN CRACK CAUSING THE WINDSHIELD WIPERS TO WORK INTERMITTENTLY.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN INOPERATIVE WIPERS, REDUCING A DRIVER'S VISIBILITY, AND INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER.
96V057000 · Vehicle Speed Control
Apr 4, 1996
THESE VEHICLES WERE ASSEMBLED WITH THE THROTTLE CABLE CONTACTING THE DASH MAT WHICH COULD BIND THE THROTTLE. THIS DOES NOT MEET WITH THE MAXIMUM RETURN TIMES REQUIRED BY FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 124, "ACCELERATOR CONTROL SYSTEMS."
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: THE ENGINE SPEED MAY NOT RETURN TO IDLE INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL INSPECT FOR ADEQUATE THROTTLE CABLE TO DASH MAT CLEARANCE, AND IF THERE IS INSUFFICIENT CLEARANCE, CUT OUT A PORTION OF THE DASH MAT TO PROVIDE PROPER CLEARANCE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA02006 · Windshield Wiper Failure
Opened May 31, 2002 · Closed Jul 23, 2003
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Additional source detail variants (2)
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
EA00024 · Headlight
Opened Sep 26, 2000 · Closed Dec 21, 2001
Status: closed (inferred from source dates) · Exterior Lighting
No summary supplied.
PE00017 · Headlight
Opened Apr 11, 2000 · Closed Sep 26, 2000
Status: closed (inferred from source dates) · Exterior Lighting
BASED ON THE REPORTS RECEIVED BY ODI FROM CONSUMERS, FAILURE OF THE HEADLIGHT ELECTRICAL CIRCUIT MAY OCCUR IN THE SUBJECT VEHICLES, AND MAY RESULT FROM REPEATED ADJUSTMENT OFTHE TILT STEERING WHEEL IN THE SUBJECT VEHICLES.REPEATED ADJUSTMENT OF THE STEERING WHEEL POSITION MAY STRAIN THE WIRING IN THE HEADLIGHT CIRCUIT TO THE POINT OF FAILURE WHERE THEY ARE ATTACHED TO THE MULTI-FUNCTION SWITCH, RESULTING IN THE UNANTICIPATED LOSS OF HEADLIGHTS WHILE THE VEHICLE IS IN MOTION.ODI HAS CONCERNS REGARDING THE HIGH RATE OF WARRANTY REPAIRS FOR PROBLEMS POTENTIALLY ASSOCIATED WITH THE ALLEGED DEFECT IN THE SUBJECT VEHICLES, WITH THE RECOGNITION THE EACH INCIDENT OF HEADLIGHT FAILURE REPRESENTS A CONDITION OF VEHICLE DISABLEMENT.IN ADDITION, THE MANUFACTURER'S EVALUATION OF THE ALLEGED DEFECT HAS NOT BEEN RECEIVED, AND THIS OFFICE HAS INTEREST IN THE DETAILS OF THE METHODOLOGIES AND RESULTS OF THAT ASSESSMENT.