Electrical System. Review the 81 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Service Brakes. Review the 43 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Service Brakes, Hydraulic. Review the 22 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

8 crash reports1 fire reports4 injury reports

Fuel System, Gasoline complaints

1 reports

Clear category filter

92,405 miles · Sep 26, 2011

Fuel System, Gasoline

Read full complaint

FUEL TANK HAS RUSTED STEEL SUPPORT STRAPS; REAR STRAP BROKE AND TANK DROPPED A FEW INCHES PLACING ADDITIONAL PRESSURE ON RUSTED FRONT SUPPORT STRAP. TANK WOULD BOUNCE UP AND DOWN DUE TO BUMPS IN ROAD. FORTUNATELY MY FRIEND, FOLLOWING MY TRUCK, ALERTED ME AND WE SECURED TANK WITH A LENGTH OF ROPE. HAD HE NOT ALERTED ME IT IS LIKELY FRONT STRAP WOULD HAVE FAILED, DROPPING TANK ONTO PAVEMENT. THE DEFECT WAS NOTED JUST BEFORE I WAS ABOUT TO PROCEED ONTO INTERSTATE 93. HAD THE FRONT STRAP FAILED, THE FUEL TANK WOULD HAVE DRAGGED FOR A DISTANCE AT HIGH SPEED, POSSIBLY CAUSING AN EXPLOSION/FIRE. THIS IS THE FIRST TIME I HAVE EVER HAD A FUEL TANK DISLODGE AND I NORMALLY KEEP VEHICLE FOR 150,000 MILES AND 10 YEARS. HIGHLY RECOMMEND VEHICLES WITH STEEL FUEL TANK SUPPORT STRAPS BE RECALLED FOR INSPECTION; IN NORTHEAST WHERE SALT IS USED ON HIGHWAYS, STEEL ON THE UNDERCARRIAGE OF A VEHICLE WILL RUST. FUEL TANK SUPPORT STRAPS SHOULD BE MADE OF STAINLESS STEEL OR ANOTHER MATERIAL THAT IS NOT SUBJECT TO DEGRADATION/CORROSION DUE TO ROAD SALT. OCCUPANTS OF VEHICLES, FIRST RESPONDERS AND OTHERS ARE AT RISK DUE TO THIS DESIGN FLAW. *TR

NHTSA ODI #10427199

Official recalls

04V562000 · Equipment Adaptive/mobility

Nov 26, 2004

ON CERTAIN VANS EQUIPPED WITH SURE-LOK WHEELCHAIR SECUREMENT SYSTEMS, THE SPROCKET TEETH OF THE RETRACTOR ASSEMBLY IS OUT OF ALIGNMENT.

Consequence & remedy

Consequence: IN THE EVENT OF A VEHICLE CRASH, THE WHEELCHAIR MAY NOT BE ADEQUATELY SECURED POSSIBLY RESULTING IN INJURIES TO A WHEELCHAIR OCCUPANT.

Remedy: DEALERS WILL INSPECT AND REPLACE THE WHEELCHAIR SECUREMENT RETRACTORS AS NECESSARY. SURE-LOK WILL HANDLE THE REPAIRS FOR THIS CAMPAIGN. OWNERS SHOULD CONTACT SURE-LOCK AT 1-908-231-1804 OR MOBILITYWORKS AT 1-800-769-8267.

04V240000 · Tires:temporary/emergency Spare Tire

May 17, 2004

THE SPARE TIRE AND WHEEL ASSEMBLY THAT WAS PROVIDED ON CERTAIN CONVERSION VEHICLES WILL NOT FIT ON THE FRONT WHEEL HUB DUE TO OFFSET OF THE WHEEL. HOWEVER, IT WILL FIT ON THE REAR WHEELS.

Consequence & remedy

Consequence: IF SOMEONE HAS A FLAT TIRE ON THE FRONT WHEEL, THEY WILL NOT BE ABLE TO INSTALL THE PROVIDED SPARE TIRE.

Remedy: DEALERS WILL INSTALL A SPARE WHEEL WITH THE CORRECT OFFSET. OWNER NOTIFICATION BEGAN ON JUNE 11, 2004. OWNERS SHOULD CONTACT REGENCY AT 1-800-989-4727.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

No exact-year investigations in this snapshot.