IllustrationTHE CATAYTIC CONVERTER BROKE INTO PIECES AND THE CAR WOULD NOT GO ABOVE 25 MPH. *JS
2003 GMC Envoy Xl
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Envoy Xl years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
140–25K
3125–50K
4650–75K
3975–100K
52100–150K
14150K+
196 reports with mileage · 32 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 53 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 50 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 27 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
11 crash reports3 fire reports15 injury reports
Engine And Engine Cooling complaints
12 reportsONE OF THE OIL COOLER LINE ON MY 2003 GMC ENVOY IS CRACKED AND LEAKING TRANSMISSION FLUID ON THE CATAYLIC CONVERTER. THIS IS A SERIOUS FIRE HAZARD DUE TO THE EXTREMELY HIGH TEMPERATURE OF THE CONVERTER DURING NORMAL OPERATIONS. *KB
NO EVENTS LED UP TO FAILURE. EXHAUST MANIFOLD IS CRACKED AND LEAKING. GMC ENVOY XL SLT 6 LITER. HAVE NOT YET RECEIVED NEW PART. WILL BE REPLACING THIS WEEK. *TR
THE REAR DRIVER DOOR POPPED OPEN AND WON'T CLOSE. THE FAN CLUTCH FAILED 2 WEEKS AFTER I PURCHASED THE VEHICLE. I THOUGHT THE TRANSMISSION WENT OUT BECAUSE IT WAS WINDING REALLY HIGH AND NOT DRIVING NORMALLY. ALSO THE REAR PASSENGER DOORS ON BOTH SIDES HAVE MALFUNCTIONED. THE WINDOW ON THE PASSENGER REAR WENT OUT. I HAVE NOT CORR…
Read full complaint
THE REAR DRIVER DOOR POPPED OPEN AND WON'T CLOSE. THE FAN CLUTCH FAILED 2 WEEKS AFTER I PURCHASED THE VEHICLE. I THOUGHT THE TRANSMISSION WENT OUT BECAUSE IT WAS WINDING REALLY HIGH AND NOT DRIVING NORMALLY. ALSO THE REAR PASSENGER DOORS ON BOTH SIDES HAVE MALFUNCTIONED. THE WINDOW ON THE PASSENGER REAR WENT OUT. I HAVE NOT CORRECTED THE FAILURES AS OF NOW. *TR
WE BOUGHT THIS CAR USED. WELL BEFORE WE BOUGHT IT, THEY HAD THE A/C FIXED, DUE TO IT NOT WORKING PROPERLY. WELL THE REAR A/C AND HEAT STILL DO NOT WORK. SOMETIMES IT COMES ON, AND OTHER TIMES IT DOES NOT. IT DOES NOT GIVE OUT HEAT AT ALL IN THE REAR. THIS IS A REAL ISSUE FOR US AND MANY OTHERS WITH CHILDREN. I HAVE READ PLENTY O…
Read full complaint
WE BOUGHT THIS CAR USED. WELL BEFORE WE BOUGHT IT, THEY HAD THE A/C FIXED, DUE TO IT NOT WORKING PROPERLY. WELL THE REAR A/C AND HEAT STILL DO NOT WORK. SOMETIMES IT COMES ON, AND OTHER TIMES IT DOES NOT. IT DOES NOT GIVE OUT HEAT AT ALL IN THE REAR. THIS IS A REAL ISSUE FOR US AND MANY OTHERS WITH CHILDREN. I HAVE READ PLENTY OF OTHER REPORTS STATING THE SAME OR VERY CLOSE. IN ALL IN ALL, THIS SHOULD BE RECALLED AND FIXED. THESE CARS ARE WAY TO EXPENSIVE TO HAVE THIS ISSUE AND NOT HAVE GMC STEP UP TO THE PLATE AND FIX THEIR ISSUE. *TR
VEHICLE COOLING FAN CLUTCH MAKING TICKING SOUNDS DUE TO THE "PULSING OF THE SOLENOID AS DESCRIBED IN THE TECHNICAL SERVICE BULLETIN RELEASED BY GENERAL MOTORS (#05-06-06-004), WHICH SPECIFIES NOT TO REPLACE FAN CLUTCH, BUT REPROGRAM THE PCM. THIS SHOULD BE A RECALL COVERED BY GM, SINCE NO PARTS ARE BROKEN AND THE ONLY PROBLEM I…
Read full complaint
VEHICLE COOLING FAN CLUTCH MAKING TICKING SOUNDS DUE TO THE "PULSING OF THE SOLENOID AS DESCRIBED IN THE TECHNICAL SERVICE BULLETIN RELEASED BY GENERAL MOTORS (#05-06-06-004), WHICH SPECIFIES NOT TO REPLACE FAN CLUTCH, BUT REPROGRAM THE PCM. THIS SHOULD BE A RECALL COVERED BY GM, SINCE NO PARTS ARE BROKEN AND THE ONLY PROBLEM IS WITH THE MANUFACTURER'S SOFTWARE. CONSUMER CAN ONLY GET THIS FIXED BY GM DEALER. THIS EXPENSE SHOULD BE COVERED UNDER A RECALL BY GM SINCE IT INVOLVES ONLY THE DEFECTIVE COMPUTER PROGRAM. THE ARE NOT PARTS TO REPLACE, JUST A REPROGRAMMING OF THE COMPUTER. *TR
I HAVE A 2003 GMC ENVOY WHICH DEVELOPED A PROBLEM WITH THE FAN CLUTCH GOING BAD WHICH AN EXTREMELY LARGE NUMBER OF PEOPLE WHO OWN THIS MODEL AND THE TRAILBRAZER HAD ALSO. THE DEALERSHIP SERVICE MANAGER TOLD ME THAT THEY WERE COMPLETELY BACKED UP FOR A FEW DAYS AND COULD NOT GET TO MY PROBLEM BUT WITHOUT EVEN CHECKING IT OUT, HE…
Read full complaint
I HAVE A 2003 GMC ENVOY WHICH DEVELOPED A PROBLEM WITH THE FAN CLUTCH GOING BAD WHICH AN EXTREMELY LARGE NUMBER OF PEOPLE WHO OWN THIS MODEL AND THE TRAILBRAZER HAD ALSO. THE DEALERSHIP SERVICE MANAGER TOLD ME THAT THEY WERE COMPLETELY BACKED UP FOR A FEW DAYS AND COULD NOT GET TO MY PROBLEM BUT WITHOUT EVEN CHECKING IT OUT, HE KNEW WHAT THE PROBLEM WAS AND SAID THEY HAVE HAD TO REPLACE MANY. I FEEL AS THOUGH THERE SHOULD BE A RECALL DUE TO THE HIGH VOLUME OF THIS PROBLEM. YOU CAN READ MANY HUNDREDS OF COMPLAINTS ABOUT THIS PARTICULAR PROBLEM AT THIS WEB SITE, HTTP://WWW.CARSURVEY.ORG/VIEWCOMMENTS_REVIEW_64655.HTML. THERE ARE NO TELLING HOW MANY MORE WOULD HAVE POSTED SUCH A COMPLAINT IF THEY HAD KNOWN OF THIS OR OTHER SITES TO DO SO.
GAS TANK BACK SPITS WHEN FILLING AT STATION...GOES ALL OVER GROUND REAR ACCESS WINDOW POPS OPEN WHEN DRIVING PASSENGER WINDOW MECHANISM BROKEN AND GLASS PIECES FORMED IN DOOR. MECHANISM FAILED TO RAISE AND LOWER THE WINDOW...CAUSING A GRINDING SOUND. REPLACEMENT WAS COSTLY AND UNECESSARY FOR ME THE CAR OWNER. SHOULD WORK F…
Read full complaint
GAS TANK BACK SPITS WHEN FILLING AT STATION...GOES ALL OVER GROUND REAR ACCESS WINDOW POPS OPEN WHEN DRIVING PASSENGER WINDOW MECHANISM BROKEN AND GLASS PIECES FORMED IN DOOR. MECHANISM FAILED TO RAISE AND LOWER THE WINDOW...CAUSING A GRINDING SOUND. REPLACEMENT WAS COSTLY AND UNECESSARY FOR ME THE CAR OWNER. SHOULD WORK FOR YEARS WITHOUT FAILURE. *JB
THE ENGINE ON MY 2003 ENVOY XL CAUGHT FIRE AND THE CAR WAS COMPLETELY ENGULFED BY THE FIRE. THE INCIDENT OCCURRED AFTER DRIVING UP A ROAD RISING 1500 VERTICAL FEET OVER A DISTANCE OF 3.5 MILES. NO WARNING LIGHTS CAME ON BEFORE SOMEONE OUTSIDE THE CAR ALERTED US TO THE FIRE. THE VEHICLE HAD 36000 MILES ON IT AND HAD RECENTLY…
Read full complaint
THE ENGINE ON MY 2003 ENVOY XL CAUGHT FIRE AND THE CAR WAS COMPLETELY ENGULFED BY THE FIRE. THE INCIDENT OCCURRED AFTER DRIVING UP A ROAD RISING 1500 VERTICAL FEET OVER A DISTANCE OF 3.5 MILES. NO WARNING LIGHTS CAME ON BEFORE SOMEONE OUTSIDE THE CAR ALERTED US TO THE FIRE. THE VEHICLE HAD 36000 MILES ON IT AND HAD RECENTLY HAD ALL THE RECOMMENDED SERVICE COMPLETED INCLUDING OIL CHANGE AND TRANSMISSION AND FUEL SYSTEM FLUSHES. THE ONE ISSUE WHICH THE GMC DEALER HAD BEEN UNABLE TO FIX WAS A LEAK TO THE FRONT PINION SEAL. THE DEALER HAD THE CAR FOR TWO DAYS AND COULD FIND NO PROBLEM EVEN THOUGH A VERY REPUTABLE REPAIR SHOP HAD ALERTED US TO THE PROBLEM WHILE PERFORMING THE OTHER MAINTENANCE AND SUGGESTED THAT WE HAVE THE DEALER ADDRESS THE PROBLEM WHILE THE CAR WAS UNDER WARRANTY. AFTER THE DEALER SAID THERE WAS NOTHING THEY COULD DO I WAS TOLD BY A SERVICE MANAGER THAT HE DIDN'T WANT TO REPLACE THE SEAL BECAUSE IF IT WAS SOMETHING ELSE IT WOULD HAVE BEEN A WASTE OF MONEY TO REPLACE THE SEAL. THE FIRE SEEMED TO ORIGINATE FROM A LOCATION A QUARTER OF THE WAY IN FROM THE PASSENGER BUMPER ABOUT AS FAR BACK AS THE TIRE. SINCE THIS INCIDENT HAPPENED WITHIN THE LAST TWELVE HOURS I DON'T KNOW WHAT THE CAUSE COULD BE. OUR INSURANCE AGENT'S CLAIMS ADJUSTER WILL BE LOOKING INTO THIS I'M SURE. THERE DOESN'T APPEAR TO BE ANY RECALL RELATED TO THIS ISSUE. WE HAD SEVEN PEOPLE IN THE CAR TODAY INCLUDING 3 CHILDREN AND 2 SENIOR CITIZENS. LUCKILY EVERYONE WAS ABLE TO GET OUT UNHARMED BUT WE HAD NO WARNING. HAD WE NOT BEEN IN A LOCATION WHERE SOMEONE SAW THE FIRE AND ALERTED US I DON'T KNOW WHAT WOULD HAVE HAPPENED. WHAT CAN WE DO TO FIND THE CAUSE AND MAKE SURE IT DOESN'T HAPPEN TO SOMEONE ELSE? *NM
THE CONSUMER SMELLED GAS, TOOK THE VEHICLE IN AND THE FUEL RAIL WAS REPLACED. LATER GAS WAS SMELLED AGAIN, THERE WAS A VAPOR EMISSION LEAK. THEN THE CHECK ENGINE LIGHT CAME ON AND THE FUEL TANK IS BEING REPLACED TWICE. *NM
Official recalls
305V494000 · Latches/locks/linkages:doors:latch
Oct 27, 2005
CERTAIN SPORT UTILITY VEHICLES HAVE A REAR SIDE CLOSURE LATCH THAT MAY NOT LATCH OR UNLATCH DUE TO CORROSION CAUSED BY ROAD SPLASH, SUCH AS WATER AND ROAD SALT. THESE VEHICLES WERE ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA.
Consequence & remedy
Consequence: IF THE DOOR IS NOT LATCHED PROPERLY AND IT GOES UNNOTICED, IT MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN UNBELTED OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
Remedy: DEALERS WILL INSTALL A SEAL ALONG THE LOWER PART OF THE ROCKER PANEL TO PREVENT INTRUSION OF CORROSIVE MATERIAL, AND INSPECT THE REAR SIDE CLOSURE LATCHES. FUNCTIONAL LATCHES WILL BE CLEANED AND LUBRICATED. NON-FUNCTIONING LATCHES WILL BE REPLACED. THE RECALL BEGAN ON FEBRUARY 24, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR ISUZU AT 1-800-255-6727.
04V527000 · Exterior Lighting:brake Lights
Nov 1, 2004
ON CERTAIN SPORT UTILITY VEHICLES, VIBRATION AND HEAT MAY CAUSE THE TAIL LAMP/STOP LAMP BULB TO LOOSEN IN ITS SOCKET. IF THIS OCCURS, THE BULB MAY FLICKER AND EVENTUALLY BECOME INOPERATIVE.
Consequence & remedy
Consequence: AN INOPERATIVE BRAKE LAMP WILL NOT CONVEY THE DRIVER'S INTENTION OF STOPPING TO DRIVERS IN FOLLOWING VEHICLES, AND AN INOPERATIVE REAR TURN SIGNAL LAMP WILL NOT CONVEY THE DRIVER'S INTENTION TO TURN TO DRIVERS IN FOLLOWING VEHICLES. BOTH OF THESE FAILURES CAN INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE TAIL LAMP/STOP LAMP ASSEMBLIES, AND IF NECESSARY, REPLACE THEM. THE RECALL BEGAN ON NOVEMBER 22, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, BUICK AT 1-866-608-8080, OR GMC AT 1-866-996-9463.
04V046000 · Visibility:windshield Wiper/washer
Feb 4, 2004
CERTAIN SPORT UTILITY VEHICLES HAVE WINDSHIELD WIPER SYSTEMS THAT WILL NOT TURN ON, CEASE OPERATION WHILE IN USE, FAIL TO TURN OFF/ON BY THEMSELVES (MOISTURE SENSITIVE WIPER SYSTEM), OR HAVE CONTINUOUS WINDSHIELD WASHER PUMP OPERATION BECAUSE THE PRESENCE OF WATER WITHIN THE WIPER MODULES CAN EITHER CAUSE A SHORT CIRCUIT OR CAN LEAD TO THE CORROSION OF COMPONENTS WITHIN THE MODULE.
Consequence & remedy
Consequence: DEPENDING ON THE OCCURRENCE AND WEATHER SITUATION, DRIVER VISIBILITY COULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL COVER THE WINDSHIELD WIPER MODULE VENT HOLE WITH A PATCH. ALSO, THE WIPER MOTOR, CIRCUIT BOARD, AND ELECTRICAL CONNECTOR WILL BE INSPECTED TO SIGNS OF WATER INTRUSION AND/OR CORROSION AND BE REPLACED AS REQUIRED. THE RECALL BEGAN JULY 6, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438; OLDSMOBILE AT 1-800-630-6537; OR GMC AT 1-866-996-9463.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6RQ17002 · Loss Of Headlights
Opened Apr 24, 2017 · Closed Mar 29, 2021
Status: closed (inferred from source dates) · Exterior Lighting:headlights
The subject vehicles are model year (MY) 2002-2009 Chevrolet Trailblazer, GMC Envoy, 2004-2007 Buick Rainier, 2003-2008 Isuzu Ascender, 2005-2009 Saab 9-7X, 2002-2004 Oldsmobile Bravada, 2003-2006 Chevrolet SSR, 2005-2009 Buick Lacrosse, and 2006-2008 Pontiac Grand Prix. This scope includes the Trailblazer/Envoy variants: 2002-2006 Envoy XL/Trailblazer EXT and 2004-2005 Envoy XUV. The original scope of this investigation was expanded to include all vehicles equipped with the subject Headlight Driver Module (HDM). The focus of the investigation was to determine whether actions performed by General Motors adequately addressed any unreasonable risk to motor vehicle safety in the subject vehicles concerning the headlights and the HDM that controls them.Under normal electrical load and environmental conditions, the HDM can overheat inside the Underhood Electrical Center (UEC). This can cause the module to fail and result in a simultaneous loss of both low beam headlights and both daytime running lights (DRLs), often with no warning or prior detectability to the driver. This failure can be intermittent or permanent. No other exterior lights are affected. High beams, turn signals, brake lights, and reverse lights are still operational.General Motors addressed this issue with 2 recalls (14V755 & 15V519) and a special coverage program (N172091910). In view of the recalls and special coverage program implemented by GM and the vehicle high beams continuing to operate, ODI has tentatively concluded that the actions taken by GM mitigate any unreasonable risk to safety posed by HDM failure in the subject vehicles.Accordingly, the investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take additional action if warranted by new circumstances.The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
EA07009 · Fuel Pump Module Leaks Gasoline
Opened Jul 10, 2007 · Closed Aug 28, 2008
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump
DURING THE COURSE OF THIS EA INVESTIGATION, ODI OBSERVED THAT THE MAJORITY OF THE COMPLAINTS (88%) AND WARRANTY CLAIMS (94%) WERE REPORTED FOR VEHICLES THAT ARE REGISTERED FOR USE IN THE SALT BELT REGION OF THE US.THIS AREA INCLUDES 20 STATES IN THE NORTHEAST, MID ATLANTIC AND THE MIDWEST REGIONS AND THE DISTRICT OF COLUMBIA.CONSUMERS IN THE SALT BELT REGION REPORTED TO ODI THAT THEY COULD SMELL FUEL VAPORS IN THEIR VEHICLES WHILE DRIVING.UPON FURTHER EXAMINATION OF THEIR VEHICLES, THEY DISCOVERED THAT FUEL VAPORS WERE COMING OUT OF THE TOP OF THE FUEL TANK. THIS CONDITION IS CAUSED BY CORROSION OF THE RETURN AND SENDER LINES OF THE FUEL PUMP MODULE.WATER AND ROAD SALT COLLECT ON TOP OF THE FUEL PUMP LEADING TO SMALL PINHOLES APPEARING ON THE FUEL LINES.FUEL MAY LEAK AND COLLECT ON TOP OF THE MODULE AND/OR SPILL ONTO THE GROUND.THE DATA EVALUATED UNDER THIS INVESTIGATION REFLECT A RELATIVELY LOW FREQUENCY OF OCCURRENCE THAT LARGELY ARISES IN SALT BELT STATES.GM HAS EXTENDED THE WARRANTY ON THE SUBJECT COMPONENT TO TEN YEARS OR 120,000 MILES.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED AT THIS TIME; ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION SELECT DOCUMENT SEARCH.
PE07014 · Fuel Tank Leak
Opened Mar 13, 2007 · Closed Jun 12, 2007
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly; Fuel System, Other:delivery:hoses, Lines/piping, And Fittings
IN JUNE 2007, GM WILL EXPAND ITS SPECIAL POLICY TO ADDRESS FUEL TANK INLET CHECK VALVE (ICV) FRACTURES ON CERTAIN MODEL YEAR (MY) TRAILBLAZER EXT AND GMC ENVOY XL VEHICLES.THE EXPANDED POLICY COVERS MY 2002-2004 TRAILBLAZER EXT, GMC ENVOY XL, AND GMC ENVOY XUV VEHICLES AND WILL EXTEND FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER COMES FIRST).GM WILL PROVIDE FREE REPAIR OF THE FUEL TANK. IT IS SENDING LETTERS TO OWNERS BEGINNING IN JUNE OF 2007.THIS ACTION SUPERSEDES GM'S PREVIOUS 7 YEAR/70,000 MILE SPECIAL POLICY FOR MY 2002 TRAILBLAZER EXT AND ENVOY XL VEHICLES.THE CONDITION IS MOST OFTEN REPORTED AS ILLUMINATION OF THE SERVICE ENGINE SOON (SES) LIGHT.THE VEHICLE'S DIAGNOSTIC SYSTEM DETECTS THE PRESENCE OF A FUEL SYSTEM PRESSURE LEAK AND ILLUMINATES THE SES LIGHT.OTHER OWNERS REPORT SMELLING GASOLINE FUMES. THE ACTION TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Fuel System, Gasoline:storage:tank Assembly
IN JUNE 2007, GM WILL EXPAND ITS SPECIAL POLICY TO ADDRESS FUEL TANK INLET CHECK VALVE (ICV) FRACTURES ON CERTAIN MODEL YEAR (MY) TRAILBLAZER EXT AND GMC ENVOY XL VEHICLES.THE EXPANDED POLICY COVERS MY 2002-2004 TRAILBLAZER EXT, GMC ENVOY XL, AND GMC ENVOY XUV VEHICLES AND WILL EXTEND FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER COMES FIRST).GM WILL PROVIDE FREE REPAIR OF THE FUEL TANK. IT IS SENDING LETTERS TO OWNERS BEGINNING IN JUNE OF 2007.THIS ACTION SUPERSEDES GM'S PREVIOUS 7 YEAR/70,000 MILE SPECIAL POLICY FOR MY 2002 TRAILBLAZER EXT AND ENVOY XL VEHICLES.THE CONDITION IS MOST OFTEN REPORTED AS ILLUMINATION OF THE SERVICE ENGINE SOON (SES) LIGHT.THE VEHICLE'S DIAGNOSTIC SYSTEM DETECTS THE PRESENCE OF A FUEL SYSTEM PRESSURE LEAK AND ILLUMINATES THE SES LIGHT.OTHER OWNERS REPORT SMELLING GASOLINE FUMES. THE ACTION TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Fuel System, Other:delivery:hoses, Lines/piping, And Fittings
IN JUNE 2007, GM WILL EXPAND ITS SPECIAL POLICY TO ADDRESS FUEL TANK INLET CHECK VALVE (ICV) FRACTURES ON CERTAIN MODEL YEAR (MY) TRAILBLAZER EXT AND GMC ENVOY XL VEHICLES.THE EXPANDED POLICY COVERS MY 2002-2004 TRAILBLAZER EXT, GMC ENVOY XL, AND GMC ENVOY XUV VEHICLES AND WILL EXTEND FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER COMES FIRST).GM WILL PROVIDE FREE REPAIR OF THE FUEL TANK. IT IS SENDING LETTERS TO OWNERS BEGINNING IN JUNE OF 2007.THIS ACTION SUPERSEDES GM'S PREVIOUS 7 YEAR/70,000 MILE SPECIAL POLICY FOR MY 2002 TRAILBLAZER EXT AND ENVOY XL VEHICLES.THE CONDITION IS MOST OFTEN REPORTED AS ILLUMINATION OF THE SERVICE ENGINE SOON (SES) LIGHT.THE VEHICLE'S DIAGNOSTIC SYSTEM DETECTS THE PRESENCE OF A FUEL SYSTEM PRESSURE LEAK AND ILLUMINATES THE SES LIGHT.OTHER OWNERS REPORT SMELLING GASOLINE FUMES. THE ACTION TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE07013 · Fuel Pump Module Leaks Gasoline
Opened Mar 12, 2007 · Closed Jul 10, 2007
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump
ODI HAS RECEIVED REPORTS THAT THE FUEL PUMP MODULE LEAKS FUEL AND OR VAPOR UNDERNEATH THE VEHICLE.GM STATES, THE FAILURE MECHANISM IS CORROSION OF THE FUEL PUMP MODULE FLANGE WHICH MAY LEAD TO A FUEL LEAK.CORROSION OF THE FUEL PUMP MODULE FLANGE IS THE RESULT OF THE VEHICLE OPERATING IN A CORROSIVE ENVIRONMENT.ODI HAS UPGRADED THIS PE TO ENGINEERING ANALYSIS (EA07-009) TO FURTHER ASSESS THIS ISSUE.
EA04021 · Brake Lamp Failure
Opened Aug 3, 2004 · Closed Nov 4, 2004
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights
GM STATES THAT SOME BRAKE/TAIL LAMP BULBS CAN PREMATURELY BECOME INOPERATIVE DUE TO MALFUNCTIONING BRAKE/TAIL LAMP SOCKETS.ON MARCH 2, 2004, GM INITIATED A 6-YEAR/72,000 MILE SPECIAL POLICY FOR 989,487 SUBJECT VEHICLES TO INSPECT AND REPLACE THE REAR BRAKE/TAIL LAMP BULB SOCKET ASSEMBLIES.ON APRIL 4, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE04-032) BASED ON CONSUMER COMPLAINTS ALLEGING BRAKE LIGHTS NOT OPERATING WHEN THE BRAKE PEDAL IS DEPRESSED.ON AUGUST 3, 2004 ODI UPGRADED PE04-032 TO AN ENGINEERING ANALYSIS (EA04-021).BY LETTER DATED OCTOBER 27, 2004 GM NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA # 04V527) COVERING SUBJECT VEHICLES THAT WERE NOT ALREADY REPAIRED UNDER GM'S SPECIAL POLICY.MY 2004 SUBJECT VEHICLES BUILT AFTER AUGUST 8, 2003 CONTAIN IMPROVED BRAKE LAMP ASSEMBLIES AND ARE NOT INCLUDED IN THE RECALL.GM DEALERS WILL INSTALL THE IMPROVED BRAKE LAMP ASSEMBLY ON SUBJECT VEHICLES BUILT ON AUGUST 8, 2003 AND EARLIER.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
PE04001 · Fuel Spillage During Refueling
Opened Jan 5, 2004 · Closed May 7, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
THIS INVESTIGATION WAS OPENED ON THE MODEL YEAR (MY) 2003 CHEVROLET TRAILBLAZER.BASED ON GM'S INFORMATION REQUEST (IR) RESPONSE, ODI ADDED TO ITS ANALYSIS THE MY 2003 GMC ENVOY AND OLDSMOBILE BRAVADA VEHICLES.THESE VEHICLES SHARE THE SAME VEHICLE PLATFORM (GM 360/370) AND FUEL FILL COMPONENTS.INCIDENT SUMMARY NUMBERS REPORTED ABOVE INCLUDE THESE VEHICLES.EPA REGULATES THE FUEL DISPENSING RATES AT FILLING STATIONS AND GM STATES THAT THE REPORTS OF SPITBACK FOR THE SUBJECT VEHICLES ARE PRINCIPALLY CAUSED BY FUEL DISPENSING PUMPS EXCEEDING THE RATE SPECIFIED BY EPA.ODI FINDS THAT THE RATE OF COMPLAINTS, FIELD REPORTS AND WARRANTY IS LOW COMPARED TO OTHER VEHICLES THAT HAVE BEEN RECALLED FOR A SPITBACK ISSUE.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF THE AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED REPORT FOR ADDITIONAL INFORMATION.
Additional source detail variants (2)
Fuel System, Gasoline:storage
THIS INVESTIGATION WAS OPENED ON THE MODEL YEAR (MY) 2003 CHEVROLET TRAILBLAZER.BASED ON GM'S INFORMATION REQUEST (IR) RESPONSE, ODI ADDED TO ITS ANALYSIS THE MY 2003 GMC ENVOY AND OLDSMOBILE BRAVADA VEHICLES.THESE VEHICLES SHARE THE SAME VEHICLE PLATFORM (GM 360/370) AND FUEL FILL COMPONENTS.INCIDENT SUMMARY NUMBERS REPORTED ABOVE INCLUDE THESE VEHICLES.EPA REGULATES THE FUEL DISPENSING RATES AT FILLING STATIONS AND GM STATES THAT THE REPORTS OF SPITBACK FOR THE SUBJECT VEHICLES ARE PRINCIPALLY CAUSED BY FUEL DISPENSING PUMPS EXCEEDING THE RATE SPECIFIED BY EPA.ODI FINDS THAT THE RATE OF COMPLAINTS, FIELD REPORTS AND WARRANTY IS LOW COMPARED TO OTHER VEHICLES THAT HAVE BEEN RECALLED FOR A SPITBACK ISSUE.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF THE AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED REPORT FOR ADDITIONAL INFORMATION.
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
THIS INVESTIGATION WAS OPENED ON THE MODEL YEAR (MY) 2003 CHEVROLET TRAILBLAZER.BASED ON GM'S INFORMATION REQUEST (IR) RESPONSE, ODI ADDED TO ITS ANALYSIS THE MY 2003 GMC ENVOY AND OLDSMOBILE BRAVADA VEHICLES.THESE VEHICLES SHARE THE SAME VEHICLE PLATFORM (GM 360/370) AND FUEL FILL COMPONENTS.INCIDENT SUMMARY NUMBERS REPORTED ABOVE INCLUDE THESE VEHICLES.EPA REGULATES THE FUEL DISPENSING RATES AT FILLING STATIONS AND GM STATES THAT THE REPORTS OF SPITBACK FOR THE SUBJECT VEHICLES ARE PRINCIPALLY CAUSED BY FUEL DISPENSING PUMPS EXCEEDING THE RATE SPECIFIED BY EPA.ODI FINDS THAT THE RATE OF COMPLAINTS, FIELD REPORTS AND WARRANTY IS LOW COMPARED TO OTHER VEHICLES THAT HAVE BEEN RECALLED FOR A SPITBACK ISSUE.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF THE AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED REPORT FOR ADDITIONAL INFORMATION.